红外辐射联合回火与冷激杀菌技术对胡萝卜粉品质的影响

首先研究不同红外辐射温度(100,110,120℃)及辐射时间(2.5,5,10 min)对胡萝卜粉微生物及品质的影响,然后根据栅栏效应原理研究红外辐射-回火、红外辐射-冷激联合杀菌对胡萝卜粉微生物、色调值、类胡萝卜素含量等品质的影响。结果表明:100℃、10 min的红外辐射处理使细菌和真菌分别降低了1.9 lg(CFU/g)和2.32 lg(CFU/g),110℃、5 min的红外辐射处使细菌和真菌分别降低了1.58 lg(CFU/g)和2.57 lg(CFU/g)。在上述两种处理条件下胡萝卜粉的水分活度从0.238分别降至0.123和0.147,胡萝卜粉中总类胡萝卜素含量从308.8μg/g降至227.8μg/g和238.8μg/g,色差值(ΔE)为9.11和7.89。与红外辐射单独作用相比,联合回火后的处理没有显著影响细菌数目,处理后保持在5.40~5.80 CFU/g,霉菌、酵母数却在处理过程中显著减少,然而减少量较低,总数仍不低于4.5 lg(CFU/g)。红外辐射-冷激联合处理相比红外辐射单独处理,100℃、10 min联合冷激7 d处理可将细菌数量降低0.25 lg(CFU/g),可将霉菌与酵母数量降低0.28 lg(CFU/g),110℃、5 min联合冷激7 d处可将细菌数量降低0.26 lg(CFU/g),可将霉菌、酵母数量降低0.40 lg(CFU/g),且这些处理下胡萝卜粉的色调值、水分活度、类胡萝卜素含量变化不显著。本试验结果表明,红外辐射-冷激处理具有协同效应,且处理过程中胡萝卜粉的色调值及总类胡萝卜素含量不受影响,这为低水分粉体食品红外辐射联合杀菌提供了参考。     

The influence of the carrier addition and spray drying temperatures on physicochemical properties of microencapsulated carrot juice powder

The objective of this study was to determinate the influence of carrier addition and spray drying temperatures (160 or 200°C) on physicochemical properties of spray-dried carrot juice powder. As carriers, maltodextrin and gum Arabic in different proportions were used. In powders were determined the following: moisture content, water activity, apparent density, size of particles, colour and carotenoids content. The content of carotenoids in powders prepared from solutions with juice to carrier ratio 2:3 was 324.3–406.6 mg/kg d.m., while in powders with a J:C = 3:2 values ranged from 576.7 to 637.7 mg/kg d.m. The highest content of carotenoids and the most yellow colour were observed in powders with 1:3 gum Arabic to maltodextrin ratio. Powders with the highest amount of gum Arabic have the highest diameter and the lowest water activity. High inlet temperature caused brighter colour of powders, higher dry matter content, lower water activity and apparent density of powders.     

多学科结合,实现裂缝控制——读《钢筋混凝土结构裂缝控制指南》

对《指南》中的一些观点进行了讨论,认为将补偿收缩混凝土等抗裂新材料排斥在《指南》之外,仅强调"好好打"存在局限性。赞赏"抗放兼施"的混凝土抗裂原则,提倡只有多学科结合,才能实现混凝土结构的裂缝控制。     

Improvement of the quality of gluten‐free sponge cake using different levels and particle sizes of carrot pomace powder

In this study, carrot pomace powder (CPP) with particle sizes of 210 μm (CPP210) and 500 μm (CPP500) was added in the gluten‐free sponge cake recipe. Flour (rice and corn flour, 1:1, w/w) was replaced with 0, 10, 20 and 30% CPP. With increasing the level and particle size of CPP, batter density, viscosity, consistency and firmness increased. The control cake had a dense, hard texture, irregular shape and low sensory scores. These properties improved with addition of CPP so that the cake density, hardness and cohesiveness reduced, while symmetry index and sensory scores increased. Varying the particle size of CPP had no considerable effects on most of the batter and cake properties, while increasing the level of CPP had great positive effects on the quality of batter and cake. Overall, addition of 30% CPP with either of the particle sizes resulted in an acceptable gluten‐free cake.     

Anthocyanin profile of red fruits and black carrot juices,purees and concentrates by HPLC‐DAD‐ESI/MS‐QTOF

A fast and reliable method for anthocyanin extraction and identification by HPLC‐DAD‐ESI/MS‐QTOF was used to analyse the anthocyanin composition of commercial red fruit juices (blackberry, redcurrant and pomegranate), purees (strawberry, cherry and raspberry) and concentrates (elderberry, blueberry and red grape). The anthocyanin profile of black carrot juice is also reported. The extraction and analysis method allowed us to detect and quantify a wide range of individual anthocyanins in a simple and rapid way. Pelargonidin‐3‐glucoside was detected in redcurrant for the first time and petunidin‐3‐galactoside quantified for the first time in blueberries. Considering the health benefits that have been associated with anthocyanin consumption, all these fruit and vegetables processed products could appear as a good source of this group of phytochemical compounds for their direct consumption or their use as ingredients for the design of new food product or food supplements.     

Clarification and pasteurisation effects on monomeric anthocyanins and percent polymeric colour of black carrot (Daucus carota L.) juice

Black carrots (BCs) are a rich source of stable anthocyanins (ACNs). The purpose of this study was to evaluate the effects of clarification and pasteurisation on ACNs of black carrot juice (BCJ). Monomeric ACNs, ACN profile and percent polymeric colour were determined during processing of BCJ. While depectinisation and bentonite treatments resulted in 7% and 20% increases in monomeric ACN content of BCJ, respectively, gelatine–kieselsol treatment and pasteurisation resulted in 10% and 3–16% reduction. Percent polymeric colour decreased after clarification, but substantially increased in samples subjected to heat. ACNs of BCJ samples were identified by HPLC–MS. Unclarified BCJ contained cyanidin-3-galactoside-xyloside-glucoside-ferulic acid as the major ACN, followed by cyanidin-3-galactoside-xyloside-glucoside-coumaric acid, and cyanidin-3-galactoside-xyloside-glucoside. After depectinisation, two more ACNs (cyanidin-3-galactoside-xyloside and cyanidin-3-galactoside-xyloside-glucoside-sinapic acid) were also identified. These results indicated that depectinisation and bentonite treatment had positive effect on the colour of BCJ, while gelatin–kieselsol treatment and pasteurisation had negative effect.     

微波辅助提取胡萝卜中果胶的工艺研究

采用微波辐射的方法提取胡萝卜中的果胶.实验考察了微波辐射时间、微波火力、草酸铵浓度、料液比及醇析中乙醇浓度对提取率的影响.实验确定微波条件下提取果胶的最佳工艺条件是:微波辐射时间2min,微波火力为中火,草酸铵浓度4g·L-1,料液比1:15 (g:mL),醇析中乙醇的浓度是70％,提取率可达6.907％.     

Aroma Characteristic and Volatile Profiling of Carrot Varieties and Quantitative Role of Terpenoid Compounds for Carrot Sensory Attributes

The aroma characteristics and volatile profiles of 14 carrot varieties were investigated by sensory evaluations and gas chromatography–mass spectrometry volatile analyses. The sensory map obtained by principal components analysis showed that the sensory attributes comprised 3 categories: sour/green, overall carrot/harsh/ink‐like, and fruity/fresh/sweet. The Kuroda type is characterized by lower intensities of overall carrot/harsh/ink‐like and fruity/fresh/sweet notes. Furthermore, volatile profiling indicated that this type did not have significantly higher amounts of volatiles. Partial least squares regression analysis determined the quantitative contributions to ink‐like, harsh, and fruity carrot aromas; monoterpenes had significant positive correlations with these attributes, while bisabolene isomers had negative correlations. The aroma attribute intensity and contents of volatiles and nutritional compounds are relatively low in the Kuroda type than in other carrot types. This type may be useful for reducing carrot harshness during the development of new carrots with good eating qualities.     

Binding of polyphenols to plant cell wall analogues – Part 2: Phenolic acids

Bacterial cellulose and cellulose–pectin composites were used as well-defined model plant cell wall (PCW) systems to study the interaction between phenolic acids (PA) derived from purple carrot juice concentrate (PCJC) and PCW components. Significant PA depletion from solution occurred, with pure cellulose initially (30 s–1 h) absorbing more than cellulose–pectin composites in the first hour (ca 20% cf 10–15%), but with all composites absorbing similar levels (ca 30%) after several days. Individual PAs bound to different relative extents with caffeic acid > chlorogenic acid > ferulic acid. Extrapolation of data for these model systems to carrot puree suggests that nutritionally-significant amounts of PAs could bind to cell walls, potentially restricting bioavailability in the small intestine and, as a consequence, delivering PAs to the large intestine for fermentation and metabolism by gut bacteria.