电沉积制备羟基磷灰石-碳化硅复合涂层

采用电沉积技术在碳/碳复合材料表面制备出羟基磷灰石-碳化硅复合涂层,通过扫描电镜、x.射线衍射仪、能谱仪、傅里叶红外光谱仪研究了电解液浓度与电流密度对复合涂层形貌与组成的影响,采用粘接拉伸法测试羟基磷灰石-碳化硅涂层、羟基磷灰石涂层与基体的结合强度.结果表明:随着电解液浓度的降低,涂层的组成由磷酸氢钙转变为羟基磷灰石,晶体从大尺寸的片状逐渐转变为纳米级球状.随着电流密度的升高,涂层的钙、磷摩尔比逐渐升高,晶体向疏松的针状转变.选取适当的工艺参数,羟基磷灰石-碳化硅与基体结合强度高于羟基磷灰石涂层.     

等离子喷涂高强陶瓷复合骨内种植体实验研究

以氮化硅陶瓷为基底材料,应用等离子喷涂技术,在其表面喷涂羟基磷灰石陶瓷涂层,制成氮化硅-羟基磷灰石陶瓷复合种植体.应用扫描电子显微镜、能谱X线、X-射线衍射仪观测种植体涂层结构和晶相结构变化情况,及Ca/P比值.结果显示羟基磷灰石呈熔和状态,颗粒较大,形成相互沟通的孔道,因而有利于骨组织的长入,喷涂前后其晶相结构及Ca/P比值无明显变化.用推出法测定的涂层结合强度(剪切强度)为23.60MPa.     

溶胶-凝胶法二氧化钛薄膜诱导沉积磷酸钙层

碳／碳复合材料作为骨植入材料具有良好的生物力学相容性，但没有生物活性。以玻璃片为基板进行预试，发现溶胶凝胶法制备的锐钛矿型二氧化钛薄膜呵在快速钙化溶液中诱导沉积出由磷酸八钙和羟基磷灰石组成的磷酸钙层，二氧化钛薄膜的微观形貌对快速钙化溶液中磷酸钙沉积物的沉积速度和组成影响不大。在以上预试的基础上，通过溶胶凝胶法制备的二氧化钛薄膜在碳/碳复合材料上复合了生物活性磷酸钙涂层。     

生物活性梯度涂层中羟基磷灰石的相转变与结构稳定性

重点研究了生物活性梯度涂层中羟基磷灰石高温结构稳定性。探讨了羟基磷灰石在喷涂和热处理过程中的相变化,对比研究了不同热处理条件对羟基磷灰石晶体稳定性和羟基恢复的影响。发现经等离子喷涂后的生物活性梯度涂层中的羟基磷灰石结晶程度明显降低,并出现β－ＴＣＰ杂相。羟基磷灰石晶体中的羟基已完全分解脱落。适当条件的热处理可使喷涂涂层中的磷酸三钙转变为羟基磷灰石,晶体中的羟基可大部分恢复,其中大气热处理比真空热处     

等离子喷涂羟基磷灰石涂层

羟基磷灰石由于具有优良的生物性能，被广泛应用于生物材料领域，而等离子喷涂制备羟基磷灰石涂层是应用最为广泛的制备方法之一。在综合国内外献的基础上，本从羟基磷灰石的本征性能、喷涂工艺的影响、结合强度和梯度涂层等方面进行综述。     

等离子喷涂羟基磷灰石涂层

羟基磷灰石由于具有优良的生物性能，被广泛应用于生物材料领域，而等离子喷涂制备羟基磷灰石涂层是应用最为广泛的制各方法之一。在综合国内外文献的基础上，本文从羟基磷灰石的本征性能、喷涂工艺的影响、结合强度和梯度涂层等方面进行综述。     

水热电沉积法制备羟基磷灰石/氧化钛复合涂层的研究

采用水热电沉积法．在钛金属基体￡：成功制备了羟基磷灰石(hydroxyapatite,HA)氧化钛(HA／TiO2)复合涂层．对涂层的表面形貌、相组成、TiO2共沉积量、热稳定性和结合强度进iir研究。实验结果表明：复合涂层具有较均匀的微观结构。TiO2的加入明显改善了涂层与基体的结合强度．涂层中TiO2含量越高．结合强度的提高也越显著。在200℃．100g／L TiO2条件下．电沉积制备的HA／TiO2复合涂层的结合强度为21.0MPa,约为纯HA涂层的2倍。TiO2共沉积量随电解液中TiO2浓度的提高逐渐增加;随电解液温度的提高先增后降,在160C达到最大。涂层经800℃热处理后,TiO2促使HA部分分解为β-磷酸钙(β-tricalciumphosphate,β-TCP)和CaO;经1200℃热处理后,HA和TiO2发生相互作用生成α-TCP和CaTiO3。     

电化学沉积-水热合成法制备羟基磷灰石生物涂层的工艺研究

采用电化学沉积法,在低温条件下从含钙、磷离子的电解水溶液中沉积磷酸钙涂层,经过水热合成获得羟基磷灰石（ＨＡ）涂层．用扫描电镜（ＳＥＭ）、Ｘ射线衍射（ＸＲＤ）和红外光谱（ＩＲ）对涂层的组织结构和化学组成进行分析．结果表明：电化学沉积涂层由ＣａＨＰＯ４·２Ｈ２Ｏ,经水热合成后转变为羟基磷灰石．随蒸气温度和压力的升高,羟基磷灰石的含量增加,在适当条件下可获得纯羟基磷灰石涂层．该方法重复性好,是制备羟基磷灰石生物涂层的理想方法之一．     

溶胶凝胶法制备羟基磷灰石/TiO2复合生物活性涂层的研究

通过溶胶凝胶法在纯钛基体上制备了羟基磷灰石/TiO2复合生物活性涂层.HA可以提高钛基的生物活性,TiO2可以提高涂层与基体的物理、化学相容性和结合强度.HA和TiO2溶胶由前驱体制得,按不同物质的量比直接混合两种溶胶来制备复合溶胶.使用XRD、SEM研究了不同温度下热处理后涂层的组成和结构.实验结果表明HA的结晶度和晶粒随着温度的升高而提高和变大;涂层表面为连续多孔结构.粘结拉伸结果表明复合涂层与基体结合良好,较纯HA涂层与基体的结合强度有较大提高.复合涂层试样于SBF中浸泡2d、7d和14d的SEM分析结果表明复合涂层表面的磷灰石形成量较高.电位动力学曲线分析表明复合涂层可以提高基体的耐蚀性.     

等离子喷涂羟基磷灰石涂层的增韧改性方法及磨损机理研究进展

纯的羟基磷灰石涂层(HA)脆性大、强度低、耐磨性较差,难于达到在人体负重部位使用的力学要求。因此制备增韧HA复合涂层材料,增加其耐磨性和机械强度,是硬组织植入材料今后发展的一个重要方向。本文介绍了等离子喷涂羟基磷灰石(HA)涂层的增韧改性研究进展及磨损机理,并叙述其存在的问题。     

Many Drugs of Abuse May Be Acutely Transformed to Dopamine,Norepinephrine and Epinephrine In Vivo

It is well established that a wide range of drugs of abuse acutely boost the signaling of the sympathetic nervous system and the hypothalamic–pituitary–adrenal (HPA) axis, where norepinephrine and epinephrine are major output molecules. This stimulatory effect is accompanied by such symptoms as elevated heart rate and blood pressure, more rapid breathing, increased body temperature and sweating, and pupillary dilation, as well as the intoxicating or euphoric subjective properties of the drug. While many drugs of abuse are thought to achieve their intoxicating effects by modulating the monoaminergic neurotransmitter systems (i.e., serotonin, norepinephrine, dopamine) by binding to these receptors or otherwise affecting their synaptic signaling, this paper puts forth the hypothesis that many of these drugs are actually acutely converted to catecholamines (dopamine, norepinephrine, epinephrine) in vivo, in addition to transformation to their known metabolites. In this manner, a range of stimulants, opioids, and psychedelics (as well as alcohol) may partially achieve their intoxicating properties, as well as side effects, due to this putative transformation to catecholamines. If this hypothesis is correct, it would alter our understanding of the basic biosynthetic pathways for generating these important signaling molecules, while also modifying our view of the neural substrates underlying substance abuse and dependence, including psychological stress-induced relapse. Importantly, there is a direct way to test the overarching hypothesis: administer (either centrally or peripherally) stable isotope versions of these drugs to model organisms such as rodents (or even to humans) and then use liquid chromatography-mass spectrometry to determine if the labeled drug is converted to labeled catecholamines in brain, blood plasma, or urine samples.     

Sapindaceae,cyanolipids, and bugs

Scentless plant bugs (Heteroptera: Rhopalidae) are so named because adults of the Serinethinae have vestigial metathoracic scent glands. Serinethines are seed predators of Sapindales, especially Sapindaceae that produce toxic cyanolipids. In two serinethine species whose ranges extend into the southern United States,Jadera haematoloma andJ. sanguinolenta, sequestration of host cyanolipids as glucosides renders these gregarious, aposematic insects unpalatable to a variety of predators. The blood glucoside profile and cyanogenesis ofJadera varies depending on the cyanolipid chemistry of hosts, and adults and larvae fed golden rain tree seeds (Koelreuteria paniculata) excrete the volatile lactone, 4-methyl-2(5H)-furanone, to which they are attracted.Jadera fed balloon vine seeds (Cardiospermum spp.) do not excrete the attractive lactone. Loss of the usual heteropteran defensive glands in serinethines may have coevolved with host specificity on toxic plants, and the orientation ofJadera to a volatile excretory product could be an adaptive response to save time.Mention of a commercial product does not consititute an endorsement by the USDA.     

Insect antifeedant properties of anthranoids from the genusVismia

Vismiones and ferruginins, representatives of a new class of lypophilic anthranoids from the genusVismia were found to inhibit feeding in larvae of species ofSpodoptera, Heliothis, and inLocusta migratoria.     

Direct observation of freeze-thaw instability of latex coatings via high pressure freezing and cryogenic SEM

Despite its industrial importance, the subject of freeze-thaw (F/T) stability of latex coatings has not been studied extensively. There is also a lack of fundamental understanding about the process and the mechanisms through which a coating becomes destabilized. High pressure (2100 bar) freezing fixes the state of water-suspended particles of polymer binder and inorganic pigments without the growth of ice crystals during freezing that produce artifacts in direct imaging scanning electron microscopy (SEM) of fracture surfaces of frozen coatings. We show that by incorporating copolymerizable functional monomers, it is possible to achieve F/T stability in polymer latexes and in low-VOC paints, as judged by the microstructures revealed by the cryogenic SEM technique. Particle coalescence as well as pigment segregation in F/T unstable systems are visualized. In order to achieve F/T stability in paints, latex particles must not flocculate and should provide protection to inorganic pigment and extender particles. Because of the unique capabilities of the cryogenic SEM, we are able to separate the effects of freezing and thawing, and study the influence of the rate of freezing and thawing on F/T stability. Destabilization can be caused by either freezing or thawing. A slow freezing process is more detrimental to F/T stability than a fast freezing process; the latter actually preserves suspension stability during freezing. Presented at the 82nd Annual Meeting of the Federation of Societies for Coatings Technology, October 27–29, 2004 in Chicago, IL. Tied for first place in The John A. Gordon Best Paper Competition.     

Ethanol and (−)-α-Pinene: Attractant Kairomones for Bark and Ambrosia Beetles in the Southeastern US

In 2002–2004, we examined the flight responses of 49 species of native and exotic bark and ambrosia beetles (Coleoptera: Scolytidae and Platypodidae) to traps baited with ethanol and/or (−)-α-pinene in the southeastern US. Eight field trials were conducted in mature pine stands in Alabama, Florida, Georgia, North Carolina, and South Carolina. Funnel traps baited with ethanol lures (release rate, about 0.6 g/day at 25–28°C) were attractive to ten species of ambrosia beetles (Ambrosiodmus tachygraphus, Anisandrus sayi, Dryoxylon onoharaensum, Monarthrum mali, Xyleborinus saxesenii, Xyleborus affinis, Xyleborus ferrugineus, Xylosandrus compactus, Xylosandrus crassiusculus, and Xylosandrus germanus) and two species of bark beetles (Cryptocarenus heveae and Hypothenemus sp.). Traps baited with (−)-α-pinene lures (release rate, 2–6 g/day at 25–28°C) were attractive to five bark beetle species (Dendroctonus terebrans, Hylastes porculus, Hylastes salebrosus, Hylastes tenuis, and Ips grandicollis) and one platypodid ambrosia beetle species (Myoplatypus flavicornis). Ethanol enhanced responses of some species (Xyleborus pubescens, H. porculus, H. salebrosus, H. tenuis, and Pityophthorus cariniceps) to traps baited with (−)-α-pinene in some locations. (−)-α-Pinene interrupted the response of some ambrosia beetle species to traps baited with ethanol, but only the response of D. onoharaensum was interrupted consistently at most locations. Of 23 species of ambrosia beetles captured in our field trials, nine were exotic and accounted for 70–97% of total catches of ambrosia beetles. Our results provide support for the continued use of separate traps baited with ethanol alone and ethanol with (−)-α-pinene to detect and monitor common bark and ambrosia beetles from the southeastern region of the US.     

ICP-MS法测定地球化学样品中As、Cr、Ge、V等18种微量痕量元素的研究

建立了测定地球化学样品中包括As、Cr、Ge、V等18种微量、痕量元素的ICP-MS方法。地化试样用HF-HNO3混酸分解后,以1 1 HNO3溶解干渣。由于制样不使用盐酸,避免了Cl对As、Cr、Ge、V的质谱干扰。用国家一级地球化学标准物质GBW 07309制备溶液优化仪器工作参数,并用于校准。方法测定限(6s)为:0.007~6.4μg/g,精密度(RSD%,n=12)为:29%~9.4%,经过国家一级地球化学标准物质的分析验证,结果与标准值吻合。方法已应用于国土资源调查的试样分析。     

2008～2009年世界塑料工业进展

收集了2008年7月～2009年6月世界塑料工业的相关资料,介绍了2008～2009年国外塑料工业的发展情况,提供了世界塑料产量、消费量及全球各类树脂的需求量及产能情况。按通用热塑性树脂(聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂)、工程塑料(尼龙、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚)、特种工程塑料(聚苯硫醚、液晶聚合物、聚醚醚酮)、通用热固性树脂(酚醛、聚氨酯、环氧树脂、不饱和聚酯树脂)不同品种的顺序,对树脂的产量、消费量、供需状况及合成工艺、产品应用开发、树脂品种的延伸及应用的进一步扩展等技术作了详细介绍。