小麦麸皮固态发酵的研究应用现状

小麦麸皮是小麦粉碾磨过程产生的最主要副产物,含有丰富的生物活性物质,可作为固态发酵过程中微生物生长的基质,用于各种工业生产领域。综述小麦麸皮固态发酵在代谢产物生产、微生物菌剂制备、全谷物食品加工及饲料替代等领域的国内外研究应用现状,并对其未来的研究发展方向进行展望,以期为小麦麸皮固态发酵系统研究提供参考。     

固态发酵对麸皮抗氧化特性及全麦面包感官品质的提升作用

用植物乳杆菌LB-1和酿酒酵母对小麦麸皮进行固态发酵,利用发酵麸皮重组全麦粉制备全麦面包,并对固态发酵麸皮的抗氧化特性及全麦面包的色泽、组织结构、风味、口感等感官品质进行分析.结果表明:经过乳酸菌LB-1与酵母菌协同发酵36?h后,麸皮的总游离氨基酸、可溶性蛋白、可溶性多酚和可溶性阿拉伯木聚糖分别增加了0.44、0.8...     

乳酸菌固态发酵过程中麦麸组分的动态变化

麦麸是小麦加工的主要副产物,营养丰富且产量大,采用乳酸菌处理麦麸可提高其附加值。为明确乳酸菌发酵对麦麸各组分的影响,作者采用植物乳杆菌、鼠李糖乳杆菌、戊糖片球菌和布氏乳杆菌分别对麦麸进行固态发酵,在48 h内每隔8 h取样,分析可溶性膳食纤维、粗蛋白质、淀粉、总酚、植酸等成分的质量分数及DPPH自由基清除能力的动态变化。结果表明,在麦麸基质中,4株乳酸菌在24 h内生长较为迅速;麦麸经乳酸菌发酵后可溶性膳食纤维质量分数显著提高,其中布氏乳杆菌发酵48 h后可溶性膳食纤维质量分数由4.72%增加至6.58%;随着发酵时间的增加,麦麸中淀粉质量分数逐渐降低,粗蛋白质量分数先增加后降低最后趋于稳定;植物乳杆菌在提高麦麸多酚质量分数方面有更好的效果,多酚质量分数由1.34 mg/g增加至3.86 mg/g,麦麸抗氧化活性显著增加;此外,乳酸菌发酵麦麸可显著降低其植酸质量分数。综合而言,植物乳杆菌和布氏乳杆菌在提高麦麸的营养特性方面具有较好的效果,可有效改善麦麸的综合利用价值。     

Single‐cell protein production through microbial conversion of lignocellulosic residue (wheat bran) for animal feed

Agricultural residue (wheat bran) rich in carbohydrates was utilized in the fermentation process to produce microbial biomass. Single‐cell biomass consists of the dried cells of microorganisms, which are used as protein supplements in human food and in animal feed. In the present study, two different microorganisms (Candida utilis and Rhizopus oligosporus) were studied for biomass production. To enhance the nutritional contents of wheat bran, a number of different fermentation parameters (effect of inoculum size, age of inoculum, incubation period, moisture to substrate ratio and incubation temperature) were optimized. Maximum yield was obtained at an inoculum size of 10% (v/w), with the age of the inoculum being a 48 h old culture. A fermentation period of 48 h was found to give the maximum protein yield and viable counts of yeast cells and mould hyphae. The microorganisms showed good growth at 30 °C. After complete optimization of the fermentation parameters, a batch of wheat bran was fermented with C. utilis and R. oligosporus under the optimized conditions, resulting in a maximum crude protein yield of 41.02% compared with the 4.21% crude protein of the non‐fermented wheat bran. Copyright © 2015 The Institute of Brewing & Distilling     

麦麸阿魏酸糖酯微生物发酵工艺优化及体外抗氧化和益生活性评价

以麦麸为原料,对固态发酵制备麦麸阿魏酸糖酯（Feruloylated glycosides,FGs）的工艺进行优化,并对其体外抗氧化及益生活性进行评价。以植物乳杆菌、枯草芽孢杆菌、地衣芽孢杆菌、酿酒酵母为发酵菌种,采取单菌发酵和混菌发酵筛选最优菌种组合,考察接种量、发酵温度、发酵时间、料水比对麦麸FGs产量的影响,通过响应面试验设计优化发酵工艺。结果表明:以枯草芽孢杆菌:地衣芽孢杆菌:酿酒酵母=1:1:1发酵麦麸时,FGs产量最高;最佳固态发酵工艺条件为发酵温度42.5℃,发酵时间58.5 h,接种量10.7%,料水比1:1.16（g/mL）,在此条件下FGs产量为1273.18 nmol/g;抗氧化实验结果表明,DPPH自由基清除率高达87.42%（1 mg/mL）,羟基自由基清除率为33.68%（4 mg/mL）,还原力为1.078（4 mg/mL）。发酵麦麸FGs可有效促进嗜热链球菌和植物乳杆菌的增殖。综上所述,以枯草芽孢杆菌、地衣芽孢杆菌和酿酒酵母混菌发酵制备的麦麸FGs有一定的抗氧化和益生活性。     

固体发酵麦麸对小麦粉和面条品质的影响

研究发酵后麦麸（fermented wheat bran,FWB）对小麦粉和面条品质的影响,为麦麸深加工的应用与相关功能性产品的研发提供参考。结果表明,米根霉固体发酵使麦麸中的蛋白质含量增加85.44%,可溶性膳食纤维含量增加2.71 倍,说明固体发酵可以提升麦麸营养。5%～15%添加量的FWB可提升小麦粉的糊化特性和熟面条的质构特性,但FWB的加入对粉质特性产生了不良影响。采用模糊数学法和响应面法优化FWB面条的配方为7.54%（质量分数,以小麦粉为基准）FWB、8%谷朊粉和0.5%食盐（均以混合粉为基准）,该配方下的面条理化性质符合行业标准要求。研究FWB面条的淀粉体外消化特性,其淀粉水解指数和预测血糖生成指数分别为61.29±3.68和73.36±2.01,显著低于普通小麦粉面条,说明FWB可以提升面条的营养价值。     

Biological response to different diets of fermented and unfermented mixtures of flour and cereal brans

The objective of this study was to biologically evaluate eight mixtures of flour and brans prepared with non‐conventional foods popularly denominated ‘multimixtures’, which differed from each other in terms of type of bran (wheat or rice), presence or absence of cassava leaf powder and submission or non‐submission to a solid‐state fermentation with Saccharomyces cerevisiae for 6 h/30 °C, utilising female Wistar/UFPEL rats. Biological indices determined were food efficiency ratio (FER), protein efficiency ratio (PER), net protein efficiency ratio (NPR) and in vivo digestibility. Liver, spleen and kidney specimens were collected at the end of the experiment. In vivo digestibility of diets containing multimixtures formulated with wheat bran was superior to diets containing rice bran, presenting values from 76.5% to 82.8%, which corresponds to up to 85% of casein digestibility. The results allowed the conclusion that fermentation tended to improve food efficiency, but did not influence in vivo digestibility.     

麦麸发酵副产物清除重金属离子汞的研究

黑曲霉可发酵麦麸生产阿拉伯木聚糖酶和阿魏酸酯酶。发酵后的固体残渣质地柔软,比表面积大。为了加强综合利用能力,研究了其对重金属离子汞的清除作用。结果表明,样品颗粒越小,pH越高,越有利于对汞的吸附,最大吸附量为033g/g(麦麸),最小残留率为02%。     

回添固态发酵麸皮对重组全麦粉品质特性的影响研究

旨在研究回添固态发酵麸皮对所制得的重组全麦粉的品质特性的影响。将固态发酵麸皮和未发酵麸皮回添入小麦粉中制得重组全麦粉,研究重组全麦粉及全麦馒头的品质特性。结果表明:发酵使麸皮的营养成分得到改善,添加固态发酵麸皮的重组全麦粉在粉质特性,糊化特性,热特性和面团黏弹特性上都接近空白小麦粉。未经发酵的麸皮的存在使馒头比容显著(P0.05)降低,质构变差,气孔紧缩,而添加发酵麸皮可以使重组全麦粉制作的馒头的比容显著(P0.05)增大,全麦馒头的质构特性得到明显改善。这说明麸皮经过固态发酵后再回添入小麦粉中能够有效的改善麸皮加入小麦粉带来的负面作用,回添发酵麸皮制得的重组全麦粉品质较好。     

Comparison of releasing bound phenolic acids from wheat bran by fermentation of three Aspergillus species

Wheat bran was fermented at 28 °C for 7 days under 70% humidity by Aspergillus niger, Aspergillus oryzae and Aspergillus awamori. Total phenolic content (TPC) of the unfermented sample was 1531.5 μg g^?1 wheat bran. After the fermentation of Aspergillus awamori, Aspergillus oryzae and Aspergillus niger, TPC reached 5362.1, 7462.6 and 10 707.5 μg g^?1, respectively. The antioxidant activity in the extractions of fermented wheat bran also increased significantly compared with the unfermented sample (P < 0.05). Aspergillus niger showed the greatest capacity to release bound ferulic acid (416.6 μg g^?1). Aspergillus oryzae and Aspergillus awamori had the advantages of releasing more chlorogenic acid (84.0 μg g^?1) and syringic acid (142.3 μg g^?1), respectively. The destructive effect of Aspergillus niger on wheat bran structure was the strongest, followed by that of Aspergillus oryzae. This effect of Aspergillus niger may be due to its higher cellulase, xylanase, arabinofuranosidase and β‐xylosidase activities. Besides, Aspergillus oryzae possessed higher β‐glucosidase activity, and Aspergillus awamori had higher α‐amylase and feruloyl esterase activities. Aspergillus niger may be the best to release bound phenolic acids in the three Aspergillus species. These will provide the helpful information for understanding mechanism of the fermentation by Aspergillus species releasing bound phenolic in wheat bran.     

Characterization of the flavor compounds in wheat bran and biochemical conversion for application in food

Wheat bran, an abundant and low-cost by-product from agricultural processing, can be used as an alternative food resource. Biochemical conversion of wheat bran to food ingredient involves pretreatments of bran to enhance its acceptability. In this work, the effects of the Maillard reaction and enzymolysis on flavor properties of wheat bran and sensory evaluation of steamed buns fortified with wheat bran were analyzed using GC-MS combined with sensory evaluation. The results showed that the Maillard reaction and enzymatic hydrolysis, as well as flavoring process, could effectively improve the flavor profiles of wheat bran. The flavor compounds in modified wheat bran products as well as its fuzzy sensory score increased significantly (P < 0.05) compared with those in commercially available dry malt extract. Additionally, steamed buns fortified with wheat bran had enhanced flavor and overall acceptability. The study can be useful in valorization a plethora of grain bran (waste) into valuable resources.     

In vitro fermentation of polysaccharides of rye,wheat and oat brans and inulin by human faecal bacteria

The in vitro fermentabilities of rye, wheat and oat brans and of a commercial fibre preparation, inulin, were compared. The brans were first digested enzymatically to remove starch and protein. The digested brans and inulin were then fermented with human faecal inoculum. The progress of fermentation was studied by following the consumption of carbohydrates and the production of short‐chain fatty acids and gases. Inulin, a short fructose polymer, was consumed significantly faster than the more complex carbohydrates of cereal brans. Carbohydrates of oat bran (rich in β‐glucan) were consumed at a higher rate than those of rye and wheat brans (rich in arabinoxylan). In all brans, glucose was consumed faster than the other main sugars, arabinose and xylose, and arabinose was degraded only slightly. The total production of short‐chain fatty acids was slightly higher with oat bran than with rye and wheat brans and inulin. In the fermentation of inulin, relatively more butyric acid and less propionic acid were produced than in the fermentation of brans. The decrease in pH was also greater in the case of inulin. Wheat bran led to a slightly slower gas formation than rye and oat brans. Formation of gases was fastest and greatest in the case of inulin. In conclusion, rye, wheat and oat brans were fermented in a rather similar way. Fermentation of the brans was different from that of inulin. Cereal brans might serve as a more balanced source of dietary fibre supplement than gas‐producing, readily fermentable polysaccharides such as inulin. © 2000 Society of Chemical Industry     

布拉迪酵母发酵对麦麸活性成分的影响

以小麦麸皮为原材料,通过布拉迪酵母发酵处理小麦麸皮降低植酸含量,提高可溶性戊聚糖(WEAX)和总酚含量以改善小麦麸皮的营养价值。研究固态发酵过程中小麦麸皮的基本组分与活性成分的变化,结果表明,经过发酵处理小麦麸皮的总膳食纤维(TDF)与不可溶性膳食纤维(IDF)含量显著提高,可溶性膳食纤维(SDF)含量提高但不显著;WEAX和总酚含量均呈现先增加后降低的趋势,最大分别增加了12.95倍、1.45倍;植酸含量显著降低,最大降解率为74.67%。     

黑曲霉发酵副产物中营养成分分析

为了再利用黑曲霉发酵生产阿魏酸酯酶和阿拉伯木聚糖酶的副产物,通过评价麦麸、玉米麸皮和蔗渣发酵副产物的营养价值,从而探讨它们作为饲料的可行性。研究了硝酸钠、硫酸铵和碳酸铵等氮源对黑曲霉固体发酵所得的水提液和残渣中的可溶性固形物、阿魏酸、低聚糖、氨基态氮、核黄素和蛋白质含量的影响。结果表明,黑曲霉在以麦麸为原料的培养基上生长良好,且以硝酸钠为无机氮源发酵所得水提液的营养价值最佳,但蛋白质含量却比未发酵麦麸减少了36%。另外,蔗渣发酵后其核黄素和蛋白质含量却大大增加,分别是原料的50倍和2.5倍,但在玉米麸皮发酵产物中增加的幅度不大。     

Breeding of lager yeast with Saccharomyces cerevisiae improves stress resistance and fermentation performance

Lager beer brewing relies on strains collectively known as Saccharomyces carlsbergensis, which are hybrids between S. cerevisiae and S. eubayanus‐like strains. Lager yeasts are particularly adapted to low‐temperature fermentations. Selection of new yeast strains for improved traits or fermentation performance is laborious, due to the allotetraploid nature of lager yeasts. Initially, we have generated new F1 hybrids by classical genetics, using spore clones of lager yeast and S. cerevisiae and complementation of auxotrophies of the single strains upon mating. These hybrids were improved on several parameters, including growth at elevated temperature and resistance against high osmolarity or high ethanol concentrations. Due to the uncertainty of chromosomal make‐up of lager yeast spore clones, we introduced molecular markers to analyse mating‐type composition by PCR. Based on these results, new hybrids between a lager and an ale yeast strain were isolated by micromanipulation. These hybrids were not subject to genetic modification. We generated and verified 13 hybrid strains. All of these hybrid strains showed improved stress resistance as seen in the ale parent, including improved survival at the end of fermentation. Importantly, some of the strains showed improved fermentation rates using 18°Plato at 18–25°C. Uniparental mitochondrial DNA inheritance was observed mostly from the S. cerevisiae parent. Copyright © 2012 John Wiley & Sons, Ltd.     

Effects of hydrothermal processing on rutin retention and physicochemical properties of Tartary buckwheat enriched dough and Chinese steamed bread

Effects of hydrothermal processing on content changes of rutin, quercetin and total flavonoids and physicochemical properties of Tartary buckwheat (TB) enriched dough and Chinese steamed bread (CSB) were investigated. Rutin loss and bitterness in CSB made from mixed wheat flour and hydrothermally processed TB flour decreased markedly compared with control. Total flavonoids were increased in dough after fermentation but decreased afterwards in CSB significantly (P < 0.05). The development time, stability time, extensibility, storage and loss moduli and tan δ of TB enriched dough, along with the volume, textural properties, sensory evaluation and bitterness of derived CSB, were significantly affected by hydrothermal processing temperature and time. Hydrothermal processing of TB flour at 100 °C for 20 min, compared with 100 °C for 10 min, 30 min or 121 °C for 10 min, 20 min, 30 min, was suggested to be a relatively better pretreatment condition for the present TB enriched CSB.     

Effects of mediums on fermentation behaviour and aroma composition in pure and mixed culture of Saccharomyces cerevisiae with Torulaspora delbrueckii

The nutrient status and composition in mediums have a significant effect on yeast metabolism and phenotypic characteristics in wine fermentation. In this study, the effects of three frequently used mediums, including synthetic grape juice (SGJ), grape juice without grape pericarp and seeds (GJ) and grape must with grape pericarp and seeds (GMPS), on yeast fermentation behaviour and aroma compounds produced by pure and mixed culture of Saccharomyces cerevisiae T73 with Torulaspora delbrueckii TD20 were investigated after alcoholic fermentation. The results showed that high fermentation activities and cell population were always found in GJ medium irrespective of inoculated approach. More esters and higher alcohols were produced in GMPS medium fermented by pure S. cerevisiae, while SGJ medium had increased levels of fatty acids. Consistent with previous literatures, the mixed fermentation of T. delbrueckii and S. cerevisiae produced more acetate esters and fatty acids than the pure culture of S. cerevisiae, while this enological trait was only found in SGJ and GJ, not in GMPS. Our results highlighted that more attention should be paid to the fermentation medium when evaluating the enological and aromatic properties of selected yeasts used in industrial winemaking. In this regard, the combined use of GJ and GMPS medium might be a suitable choice.     

Potential for prevention of non‐O157 Shiga toxin‐producing Escherichia coli contamination in traditionally fermented African maize gruel by fermentative probiotic Lactobacillus plantarum

Non‐O157 Shiga toxin‐producing Escherichia coli (STEC) are a frequent cause of STEC‐related infections such as diarrhoea. Fermentation by presumptive probiotic Lactobacillus plantarum strain B411 isolated from cereal fermentation was investigated to prevent the growth of acid‐adapted (AA) and non‐acid‐adapted (NAA) non‐O157 STEC in traditionally fermented maize gruel, a widely used complementary food in Africa. L. plantarum strain B411 possessed probiotic characteristics and antimicrobial activity against selected pathogenic bacteria. Growth of AA and NAA non‐O157 STEC strains was substantially inhibited by 3.6 and 4.8 log reductions, respectively, in the maize gruel fermented with the L. plantarum B411, while their growth was only inhibited by 1.0 and 1.2 log reductions, respectively, by traditional fermentation alone. Inclusion of fermentative strains of L. plantarum exhibiting probiotic activity is a feasible method to ensure safety of traditionally fermented African cereal porridges through inhibition of non‐O157 STEC.     

Composition of Saccharomyces cerevisiae strains in spontaneous fermentations of Pinot Noir and Chardonnay

There is a lack of knowledge about the composition of Saccharomyces cerevisiae strains in spontaneous fermentations of Pinot Noir and Chardonnay cultivars. The objectives were to determine the relative abundance of indigenous and commercial S. cerevisiae strains in spontaneous fermentations at three wineries from the two cultivars and to compare the composition of the S. cerevisiae strains between cultivars and wineries. Three fermentation vessels were sampled at three stages of fermentation for each cultivar at each winery. Isolates were identified to the strain level using seven microsatellite loci. Commercial S. cerevisiae strains were isolated at a frequency higher than that of the indigenous strains at each winery for both cultivars. The composition of S. cerevisiae strains was different for each cultivar and at each winery. Our results illustrate the clear influence of inoculated commercial active dry yeast strains on the composition of S. cerevisiae strains in spontaneous fermentations at wineries conducting both inoculated and spontaneous fermentations.     

蛹虫草固态发酵对玉米粉加工性质及消化性的影响

利用蛹虫草固态发酵法对玉米粉性质进行改良。测定发酵前后玉米粉的理化性质,利用快速粘度分析仪和质构仪测定发酵前后玉米粉加工性质,来探究蛹虫草发酵对玉米粉性质的影响。研究结果表明,发酵0~2 d理化成分变化不显著（P>0.05）,2 d后发生明显变化,至发酵第3 d,总淀粉含量降低了11.7%,直链淀粉增加了29.8%;经固态发酵后,水溶指数增加了87.7%,吸水指数降低了28.2%;固态发酵可改善玉米粉的糊化特性和质构特性,到发酵的第3 d,峰值粘度降低了47.3%,回生值下降了34.9%,凝胶硬度和咀嚼性分别降低了45.4%和34.8%,提高了玉米主食制品适口性。蛹虫草固态发酵后的玉米粉具有更高的营养价值,到发酵的第3 d,可溶性蛋白、必需氨基酸,分别增加了52.3%和26%;慢消化淀粉及抗性淀粉分别提高至原来的1.83和1.41倍。通过本研究所得玉米粉的改良方法,可改善玉米粉的加工性能和淀粉消化性,为蛹虫草在玉米主食制品品质改良方面提供一定参考。