Physical characteristics of sintered fly ash aggregate containing clay binders

A comprehensive research has been conducted to explore the influence of sintering on the properties of fly ash aggregate containing clay binders (bentonite and kaolinite). Fly ash aggregate containing clay binders, have been subjected to various sintering temperatures at different durations of 700?C1400?°C and 15?C120?min, respectively. The variation in aggregate properties, viz strength, water absorption, density and shrinkage during sintering, have been determined and discussed. In addition to these, the uniformity of sintering and rate of water absorption of sintered aggregate were also determined. No significant changes in aggregate properties were observed for aggregate sintered up to 900?°C, due to the insufficient sintering temperature range. However, the aggregate properties substantially enhanced for temperature above 1000?°C, which is attributed to the activation of liquid phase sintering. For temperatures between 1000 and 1300?°C, the aggregate with bentonite shows significant increase in shrinkage (30?%), density (density ratio 0.70), higher ten percent fines value (TPFV) (6.13?tonne), reduction in porosity (35?%), and water absorption of 4?%. However, at 1400?°C, the aggregate properties degraded due to the decomposition of mineral phases in bentonite. For aggregates with kaolinite, highest TPFV of 8.5?tonne with lowest water absorption of 2?% have been observed at 1400?°C. The presence of a higher amount of interconnected pores for aggregates sintered between 700 and 1000?°C leads to a higher rate of water absorption and then reduces to 30?% for temperatures between 1200 and 1300 and 1200 to 1400?°C for bentonite and kaolinite aggregates, respectively. This reduction is due to the reduced interconnected pores. Duration of sintering has no impact on the aggregate properties for temperatures up to 800 and 1000?°C for aggregates with bentonite and kaolinite, respectively. However, between 1000 and 1400?°C, there has been considerable improvement in the aggregate properties for increasing duration up to 60?min. In comparison, during sintering, aggregates with bentonite possessed better properties for temperature less than 1000?°C, whereas aggregates with kaolinite exhibited superior properties between 1100 and 1400?°C.     

Procedures adopted for the laboratory cultivation of Trichodesmium erythraeum

The present paper describes the procedures adopted for axenic or pure cultivation of the marine blue-green alga Trichodesmium erythraeum (Ehr.)¹ in the laboratory. Strains of T. erythraeum were isolated from the nearshore waters of the Bay of Bengal (11°29 N 79°49 E) during the pre-bloom period in March, 1965, at a depth of 9 to 12m. Modified, enriched, Erdschreiber medium was used for laboratory cultivation of T. erythraeum. A differential concentration of streptomycin 6 mg/100 ml, tetracycline 5 mg/100 ml and sulfadiazine 4 mg/100 ml was used to inhibit the microbial growth in cultures. Difficulties experienced in the initial culture stages of T. erythraeum and the necessary specific instructions employed are described in detail.     

Click chemistry approach to conventional vegetable tanning process: accelerated method with improved organoleptic properties

Click chemistry approaches are tailored to generate molecular building blocks quickly and reliably by joining small units together selectively and covalently, stably and irreversibly. The vegetable tannins such as hydrolyzable and condensed tannins are capable to produce rather stable radicals or inhibit the progress of radicals and are prone to oxidations such as photo and auto-oxidation, and their anti-oxidant nature is well known. A lot remains to be done to understand the extent of the variation of leather stability, color variation (lightening and darkening reaction of leather), and poor resistance to water uptake for prolonged periods. In the present study, we have reported click chemistry approaches to accelerated vegetable tanning processes based on periodates catalyzed formation of oxidized hydrolysable and condensed tannins for high exhaustion with improved properties. The distribution of oxidized vegetable tannin, the thermal stability such as shrinkage temperature (T _s) and denaturation temperature (T _d), resistance to collagenolytic activities, and organoleptic properties of tanned leather as well as the evaluations of eco-friendly characteristics were investigated. Scanning electron microscopic analysis indicates the cross section of tightness of the leather. Differential scanning calorimetric analysis shows that the T _d of leather is more than that of vegetable tanned or equal to aldehyde tanned one. The leathers exhibited fullness, softness, good color, and general appearance when compared to non-oxidized vegetable tannin. The developed process benefits from significant reduction in total solids and better biodegradability in the effluent, compared to non-oxidized vegetable tannins.     

Occurrence,toxicity and remediation of polyethylene terephthalate plastics. A review

Environmental Chemistry Letters - Polyethylene terephthalate is a common plastic in many products such as viscose rayon for clothing, and packaging material in the food and beverage industries....     

Expert System for Terrestrial Vegetation Distribution, Potential Impact and Mitigation Abatement Measures

The tropical rainforest of Malaysia holds one of the richest flora in the world. The favourable climate has produced flora of amazing richness and variety. Terrestrial vegetation of tropical rainforests is an important feature of the environment. Plants play a major role in the environment and conservation of a particular environment depends fundamentally on the maintenance of existing plants and their communities and hierarchies. Interference in the balance of the ecosystem may produce radical changes that lead to progressive deviations from the original situation. Therefore, the application of a computer technology in the form of an expert system (ES) will be able to help in the analysis and management of the EIA information. The ES is named VEGEVIC. Application of the system will lead to greater consistency in the application of EIA through implementation of a standard approach.     

Reuse potential of low-calcium bottom ash as aggregate through pelletization

Coal combustion residues which include fly ash, bottom ash and boiler slag is one of the major pollutants as these residues require large land area for their disposal. Among these residues, utilization of bottom ash in the construction industry is very low. This paper explains the use of bottom ash through pelletization. Raw bottom ash could not be pelletized as such due to its coarseness. Though pulverized bottom ash could be pelletized, the pelletization efficiency was low, and the aggregates were too weak to withstand the handling stresses. To improve the pelletization efficiency, different clay and cementitious binders were used with bottom ash. The influence of different factors and their interaction effects were studied on the duration of pelletization process and the pelletization efficiency through fractional factorial design. Addition of binders facilitated conversion of low-calcium bottom ash into aggregates. To achieve maximum pelletization efficiency, the binder content and moisture requirements vary with type of binder. Addition of Ca(OH)₂ improved the (i) pelletization efficiency, (ii) reduced the duration of pelletization process from an average of 14–7 min, and (iii) reduced the binder dosage for a given pelletization efficiency. For aggregate with clay binders and cementitious binder, Ca(OH)₂ and binder dosage have significant effect in reducing the duration of pelletization process.     

Experimental study relating to red tide

In laboratory cultures, increased growth of Trichodesmium erythraeum was induced by the addition of gibberellic acid (GA). Addition of 2.0 mg/l GA to basal medium increased the initial concentration of 62 to 68 cells/10 ml to 450 to 950 cells/10 ml in 7 days, while no cell division occurred in control cultures. Addition of inorganic phosphate and nitrate have very little growth promoting effects; during a period of 7 days, the initial concentration of 62 cells/10 ml increased to only 74 to 80 cells/10 ml. These results suggest that red tide outbreaks in tropical oceans may be caused by growth promoting substances.     

CAPITAL COSTS OF RURAL WATER SYSTEMS: AN EMPIRICAL APPROACH1

ABSTRACT: In the last two decades the federal government has provided substantial capital to construct rural water distribution systems. Loans at subsidized interest rates and front-end grants through the Farmers Home Administration have been the main source of this capital. Recent federal policy redirections have reduced substantially the availability of grants and subsidized loans. Because of design and material differences, capital cost estimates from urban systems are not uniformly applicable to rural water services. This study presents an econometric analysis of capital costs, using Illinois rural water system construction contract bids. Cost equations by systems components representing 90 percent of capital costs are estimated. The type of information developed here can be used in initial planning and optimization design models contributing to the efficient provision of rural water services.     

Antibacterial activity of the marine blue-green alga Trichodesmium erythraeum in the gastro-intestinal contents of the sea gull Laurus brunicephalus

The gastro-intestinal contents of the sea gull Laurus brunicephalus Jerdon were found to possess antibacterial activity. This activity could be traced to heavy accumulations of the marine blue-green alga Trichodesmium erythraeum in the gut. During 1969, a bloom of T. erythraeum began in Porto Novo waters about the middle of February, and attained a peak during the second week of March. It has been reported previously by the author that antibacterial properties are exhibited by T. erythraeum maintained in laboratory cultures, as well as in water samples collected from a red tide area. It was also reported (Ramamurthy, 1970) that the gut contents in 2 pelagic fishes, Hilsa kanagurta and Rastrelliger kanagurta, collected during the same red tide bloom period, possessed antibacterial properties. During this period large numbers of these fishes were consumed by sea gulls L. brunicephalus. In view of this finding, experimental procedures were adopted to determine whether extracts of T. erythraeum occurring in the gut of the sea gulls might exhibit antibacterial activity. It was found that T. erythraeum collected from the gut of L. brunicephalus could inhibit both gram positive and gram negative bacteria. Gastro-intestinal extracts from L. brunicephalus collected during the non-bloom period of T. erythraeum showed heavy microbial growth of bacteria and fungi. Evidently, antibacterial or sterile conditions prevail in the gut of these tropical sea gulls in a manner similar to that observed in Polar penguins by Sieburth (1959, 1961).