Electrophoretic studies of chhana whey and effect of temperature and time of storage on its quality

Chhana whey contains less protein than Cheddar cheese whey, acid casein and cottage cheese whey, and the protein composition is quite different. Electrophoretic methods demonstrated that most of the proteins in chhana whey were denatured, and there was considerable variation in the protein composition between samples of chhana whey and paneer whey obtained from different sources. The effect of storage temperature and time (up to 10 h at 40°C, 50°C, 60°C, 70°C and 80°C) on the quality of chhana whey was investigated. There were no significant changes in the pH and titratable acidity in any of these cases. Electrophoretic separation showed no qualitative changes in the protein composition pattern of chhana whey after up to 10 h of storage at 70°C.     

Industrial yogurt manufacture: monitoring of fermentation process and improvement of final product quality

Lactic acid fermentation during the production of skim milk and whole fat set-style yogurt was continuously monitored by measuring pH. The modified Gompertz model was successfully applied to describe the pH decline and viscosity development during the fermentation process. The viscosity and incubation time data were also fitted to linear models against ln(pH). The investigation of the yogurt quality improvement practices included 2 different heat treatments (80°C for 30 min and 95°C for 10 min), 3 milk protein fortifying agents (skim milk powder, whey powder, and milk protein concentrate) added at 2.0%, and 4 hydrocolloids (κ-carrageenan, xanthan, guar gum, and pectin) added at 0.01% to whole fat and skim yogurts. Heat treatment significantly affected viscosity and acetaldehyde development without influencing incubation time and acidity. The addition of whey powder shortened the incubation time but had a detrimental effect on consistency, firmness, and overall acceptance of yogurts. On the other hand, addition of skim milk powder improved the textural quality and decreased the vulnerability of yogurts to syneresis. Anionic stabilizers (κ-carrageenan and pectin) had a poor effect on the texture and palatability of yogurts. However, neutral gums (xanthan and guar gum) improved texture and prevented the wheying-off defect. Skim milk yogurts exhibited longer incubation times and higher viscosities, whereas they were rated higher during sensory evaluation than whole fat yogurts.     

Effect of substituting whey cream for sweet cream on the textural and rheological properties of cream cheese

In the manufacture of cream cheese, sweet cream and milk are blended to prepare the cream cheese mix, although other ingredients such as condensed skim milk and skim milk powder may also be included. Whey cream (WC) is an underutilized fat source, which has smaller fat droplets and slightly different chemical composition than sweet cream. This study investigated the rheological and textural properties of cream cheeses manufactured by substituting sweet cream with various levels of WC. Three different cream cheese mixes were prepared: control mix (CC; 0% WC), cream cheese mixes containing 25% WC (25WC; i.e., 75% sweet cream), and cream cheese mixes with 75% WC (75WC; i.e., 25% sweet cream). The CC, 25WC, and 75WC mixes were then used to manufacture cream cheeses. We also studied the effect of WC on the initial step in cream cheese manufacture (i.e., the acid gelation process monitored using dynamic small amplitude rheology). Acid gels were also prepared with added denatured whey proteins or membrane proteins/phospholipids (PL) to evaluate how these components affected gel properties. The rheological, textural, and sensory properties of cream cheeses were also measured. The WC samples had significantly higher levels of PL and insoluble protein compared with sweet cream. An increase in the level of WC reduced the rate of acid gel development, similar to the effect of whey phospholipid concentrate added to mixes. In cream cheese, an increase in the level of added WC resulted in significantly lower storage modulus values at temperatures <20°C. Texture results, obtained from instrumental and sensory analyses, showed that high level of WC resulted in significantly lower firmness or hardness values and higher stickiness compared with cream cheeses made with 25WC or CC cream cheeses. The softer, less elastic gels or cheeses resulting from the use of high levels of WC are likely due to the presence of components such as PL and proteins from the native milk fat globule membrane. The use of low levels of WC in cream cheese did not alter the texture, whereas high levels of WC could be used if manufacturers want to produce more spreadable products.     

Smoothing temperature and ratio of casein to whey protein: Two tools to improve nonfat stirred yogurt properties

Consumers are not always ready to compromise on the loss of texture and increased syneresis that nonfat stirred yogurts display compared with yogurts that contain fat. In this study, we investigated milk protein composition and smoothing temperature as a means to control nonfat yogurt microstructure, textural properties, and syneresis. Yogurts were prepared with different ratios of casein to whey protein (R1.5, R2.8, and R3.9). Yogurts were pumped through a smoothing pilot system comprising a plate heat exchanger set at 15, 20, or 25°C and then stored at 4°C until analysis (d 1, 9, and 23). Yogurt particle size and firmness were measured. Yogurt syneresis and water mobility were determined, respectively, by centrifugation and time domain low-frequency proton nuclear magnetic resonance (¹H-LF-NMR). Increasing the smoothing temperature increased gel firmness and microgel (dense protein aggregates) sizes independently of the whey protein content. Also, yogurt microgel sizes changed with storage time, but the evolution pattern depended on protein ratio. Yogurt R1.5 showed the largest particles, and their sizes increased with storage, whereas R2.8 and R3.9 had smaller microgels, and R3.9 did not show any increase in microgel size during storage. Micrographs showed a heterogeneous gel with the empty area occupied by serum for R1.5, whereas R2.8 and R3.9 showed fewer serum zones and a more disrupted gel embedding microgels. Induced syneresis reduced with greater whey protein content and time of storage. This is in agreement with ¹H-LF-NMR showing less bulk water mobility with increasing whey protein content during storage. However, ¹H-LF-RMN revealed higher values of spontaneous serum separation during storage for R1.5 and R3.9 yogurts, whereas these were lower and stable for R2.8 yogurt. Microgels play an important structural role in yogurt textural attributes, and their characteristics are modulated by whey protein content and smoothing temperature. Optimization of these parameters may help improve nonfat stirred dairy gel.     

Effects of fructooligosaccharide and whey protein concentrate on the viability of starter culture in reduced-fat probiotic yogurt during storage

ABSTRACT:  Viability of yogurt starter cultures and Bifidobacterium animalis was assessed during 28 d storage in reduced-fat yogurts containing 1.5% milk fat supplemented with 1.5% fructooligosaccharide or whey protein concentrate. These properties were examined in comparison with control yogurts containing 1.5% and 3% milk fat and no supplement. Although fructooligosaccharide improved the viability of Streptococcus thermophilus , Lactobacillus delbrueckii subs. bulgaricus, and Bifidobacterium animalis , the highest growth was obtained when milk was supplemented with whey protein concentrate in reduced-fat yogurt ( P < 0.05). Supplementation with 1.5% whey protein concentrate in reduced-fat yogurt increased the viable counts of S. thermophilus , L. delbrueckii subs. bulgaricus, and B. animalis by 1 log cycle in the 1st week of storage when compared to control sample. Similar improvement in the growth of both yogurt bacteria and B. animalis was also obtained in the full-fat yogurt containing 3% milk fat and no supplement. Addition of whey protein concentrate also resulted in the highest content of lactic and acetic acids ( P < 0.05). A gradual increase was obtained in organic acid contents during the storage.     

Comparison of micellar casein isolate and nonfat dry milk for use in the production of high-protein cultured milk products

High protein levels in yogurt, as well as the presence of denatured whey proteins in the milk, lead to the development of firm gels that can make it difficult to formulate a fluid beverage. We wanted to prepare high-protein yogurts and explore the effects of using micellar casein isolate (MCI), which was significantly depleted in whey protein by microfiltration. Little is known about the use of whey protein-depleted milk protein powders for high-protein yogurt products. Microfiltration also depletes soluble ions, in addition to whey proteins, and so alterations to the ionic strength of rehydrated MCI dispersions were also explored, to understand their effects on a high-protein yogurt gel system. Yogurts were prepared at 8% protein (wt/wt) from MCI or nonfat dry milk (NDM). The NDM was dispersed in water, and MCI powders were dispersed in water (with either low levels of added lactose to allow fermentation to achieve the target pH, or a high level to match the lactose content of the NDM sample) or in ultrafiltered (UF) milk permeate to align its ionic strength with that of the NDM dispersion. Dispersions were then heated at 85°C for 30 min while stirring, cooled to 40°C in an ice bath, and fermented with yogurt cultures to a final pH of 4.3. The stiffness of set-style yogurt gels, as determined by the storage modulus, was lowest in whey protein-depleted milk (i.e., MCI) prepared with a high ionic strength (UF permeate). Confocal laser scanning microscopy and permeability measurements revealed no large differences in the gel microstructure of MCI samples prepared in various dispersants. Stirred yogurt made from MCI that was prepared with low ionic strength showed slow rates of elastic bond reformation after stirring, as well as slower increases in cluster particle size throughout the ambient storage period. Both the presence of denatured whey proteins and the ionic strength of milk dispersions significantly affected the properties of set and stirred-style yogurt gels. Results from this study showed that the ionic strength of the heated milk dispersion before fermentation had a large influence on the gelation pH and strength of acid milk gels, but only when prepared at high (8%) protein levels. Results also showed that depleting milk of whey proteins before fermentation led to the development of weak yogurt gels, which were slow to rebody and may be better suited for preparing cultured milk beverages where low viscosities are desirable.     

How is an ideal satiating yogurt described? A case study with added-protein yogurts

Protein is recognized as the macronutrient with the highest satiating ability. Yogurt can be an excellent basis for designing satiating food as it is protein-based food product. Five different set-type yogurts were formulated by adding extra skim milk powder (MP), whey protein concentrate (WPC), calcium caseinate (CAS) or a blend of whey protein concentrate with calcium caseinate (CAS–WPC). A control yogurt without extra protein content was also prepared. Differences in sensory perceptions (through CATA questions) were related to the consumers' expected satiating ability and liking scores (of several modalities). In addition, an “Ideal satiating yogurt” was included in the CATA question to perform a penalty analysis to show potential directions for yogurt reformulation and to relate sensory and non-sensory yogurt characteristics to satiating capacity.     

Effects of Polymerized Whey Proteins on Consistency and Water-holding Properties of Goat's Milk Yogurt

ABSTRACT The effects of polymerized whey proteins (PWP) on functional properties of goat's milk yogurt were investigated. PWP were prepared by heating whey protein isolate (WPI) dispersion (8.0% protein, pH 7.0) at 90 °C for 30 min. Three reconstituted goat milk (RGM) (12% total solids [TS] as control; RGM with 2.4% unheated WPI; and RGM with 2.4% PWP) and 1 RGM with 16.7% TS were prepared and inoculated with 0.04% yogurt starter culture. Inoculated milk was incubated at 43 °C for 5 h, cooled to 4 °C in an ice‐water bath, and then placed at refrigerator (4 °C) overnight before testing. Incorporation of PWP significantly (P < 0.001) increased the viscosity (by 80%) and decreased the syneresis (by 25%) of the yogurt samples, whereas addition of unheated WPI did not significantly affect the viscosity and syneresis compared with the control. There were no changes in pH, TS, ash, fat, protein, and lactose contents among yogurt samples except the solids fortified control. Yogurt with 16.7% TS had the lowest syneresis but did not improve in viscosity. Transmission electron microscopy micrographs demonstrated that the microstructure of the goat's milk yogurt gel with PWP was denser than the control. Results of this study indicate that polymerized whey proteins may be a novel protein‐based thickening agent for improving the functional properties of goat's milk yogurt and other similar products.     

Physiochemical Properties,Microstructure, and Probiotic Survivability of Nonfat Goats’ Milk Yogurt Using Heat‐Treated Whey Protein Concentrate as Fat Replacer

There is a market demand for nonfat fermented goats’ milk products. A nonfat goats’ milk yogurt containing probiotics (Lactobacillus acidophilus, and Bifidobacterium spp.) was developed using heat‐treated whey protein concentrate (HWPC) as a fat replacer and pectin as a thickening agent. Yogurts containing untreated whey protein concentrate (WPC) and pectin, and the one with only pectin were also prepared. Skim cows’ milk yogurt with pectin was also made as a control. The yogurts were analyzed for chemical composition, water holding capacity (syneresis), microstructure, changes in pH and viscosity, mold, yeast and coliform counts, and probiotic survivability during storage at 4 °C for 10 wk. The results showed that the nonfat goats’ milk yogurt made with 1.2% HWPC (WPC solution heated at 85 °C for 30 min at pH 8.5) and 0.35% pectin had significantly higher viscosity (P < 0.01) than any of the other yogurts and lower syneresis than the goats’ yogurt with only pectin (P < 0.01). Viscosity and pH of all the yogurt samples did not change much throughout storage. Bifidobacterium spp. remained stable and was above 10⁶CFU g^‐1 during the 10‐wk storage. However, the population of Lactobacillus acidophilus dropped to below 10⁶CFU g^‐1 after 2 wk of storage. Microstructure analysis of the nonfat goats’ milk yogurt by scanning electron microscopy revealed that HWPC interacted with casein micelles to form a relatively compact network in the yogurt gel. The results indicated that HWPC could be used as a fat replacer for improving the consistency of nonfat goats’ milk yogurt and other similar products.     

Compositional and functional properties of buttermilk: a comparison between sweet, sour, and whey buttermilk

Buttermilk is a dairy ingredient widely used in the food industry because of its emulsifying capacity and its positive impact on flavor. Commercial buttermilk is sweet buttermilk, a by-product from churning sweet cream into butter. However, other sources of buttermilk exist, including cultured and whey buttermilk obtained from churning of cultured cream and whey cream, respectively. The compositional and functional properties (protein solubility, viscosity, emulsifying and foaming properties) of sweet, sour, and whey buttermilk were determined at different pH levels and compared with those of skim milk and whey. Composition of sweet and cultured buttermilk was similar to skim milk, and composition of whey buttermilk was similar to whey, with the exception of fat content, which was higher in buttermilk than in skim milk or whey (6 to 20% vs. 0.3 to 0.4%). Functional properties of whey buttermilk were independent of pH, whereas sweet and cultured buttermilk exhibited lower protein solubility and emulsifying properties as well as a higher viscosity at low pH (pH ≤ 5). Sweet, sour, and whey buttermilks showed higher emulsifying properties and lower foaming capacity than milk and whey because of the presence of milk fat globule membrane components. Furthermore, among the various buttermilks, whey buttermilk was the one showing the highest emulsifying properties and the lowest foaming capacity. This could be due to a higher ratio of phospholipids to protein in whey buttermilk compared with cultured or sweet buttermilk. Whey buttermilk appears to be a promising and unique ingredient in the formulation of low pH foods.     

High Performance Liquid Chromatographic Determination of Organic Acids in Dairy Products

A simple isocratic HPLC technique was developed for the quantitative analysis of organic acids in dairy products. An Ammex HPX- 87 column at 65°C, 0.0090N H₂SO₄ mobile phase and UV detection at 220 and 275 nm were utilized. Orotic, citric, pyruvic, lactic, uric, formic, acetic, propionic, butyric, and hippuric acids were quantitated for whole milk, skim powder, cultured buttermilk, sour cream, cottage cheese, yogurt, sharp Cheddar cheese, and blue cheese. Over 90% recoveries of acids added to whole milk were observed for ail acids except butyrid; the average recovery for butyric was 86%.     

Manufacture of nonfat yogurt from a high milk protein powder.

Nonfat yogurts were manufactured from skim milk fortified with a new high milk protein powder. The powder, containing approximately 84% milk protein, was added to skim milk to obtain 5.2 to 11.3% total protein, 11.1 to 15% total solids, and 1.6 to 7.9% lactose in the yogurt mix. Mixes were homogenized, pasteurized at 90 degrees C for 10 min, and fermented with a yogurt culture at 42 degrees C to pH 4.6. Controls were made from the same skim milk fortified with NDM to approximately 14% total solids. Yogurts made with the protein powder and containing 5.6% protein were similar in firmness to the control and had good flavor when fresh and after 2 wk of storage. Yogurts with more than 5.6% protein were too firm and had an astringent flavor. Acetaldehyde content of all yogurts was comparable with that of the control, and fat content ranged from .18 to .33%. As the protein content of yogurts increased, the porosity of yogurts, as seen by scanning electron microscopy, decreased. Good quality nonfat yogurts can be produced by supplementing skim milk with a high milk protein powder up to 5.6% protein. The added protein assists in providing a firm body and minimal whey separation without the use of stabilizers.     

Preliminary observations on the effects of milk fortification and heating on microstructure and physical properties of stirred yogurt

The aim of this work was to study how milk fortification and heating affect yogurt microstructure (micellar characteristics, protein network) and physical properties (viscosity, water-holding capacity (WHC), and graininess). Milk was fortified with skim milk powder (control), whey protein concentrate (WPC), caseinate, or a mixture of caseinate and whey protein. Two heat treatments were applied, giving average whey protein denaturation levels of 58% and 77%. For caseinate-enriched yogurts, the heating effect was negligible. When milk was enriched with WPC, heating led to a high level of cross-linking within the gel network. Heating increased yogurt viscosity and WHC, but also graininess. When milk was fortified with a blend of WPC and caseinate giving a whey protein-to-casein ratio of 0.20, the yogurt viscosity was greatly improved, while graininess was kept low. The results show a relationship between micelle solvation and yogurt microstructure, as well as micelle size in milk base and yogurt graininess.     

Physical properties of yogurt fortified with various commercial whey protein concentrates

The effects of whey protein concentrates on physical and rheological properties of yogurt were studied. Five commercial whey protein concentrates (340 g kg^?1 protein nominal) were used to fortify milk to 45 g protein kg^?1. Fermentation was performed with two different starters (ropy and non‐ropy). Resulting yogurts were compared with a control yogurt enriched with skim milk powder. The water‐holding capacity of the yogurt fortified with skim milk powder was 500 g kg^?1 and ranged from 600 to 638 g kg^?1 when fortified with whey protein concentrates. Significant rheological differences have been noticed between the yogurts fortified with different whey protein concentrates, independent of the starter used. Three whey protein concentrates generated yogurts with a behavior similar to the control. The two others produced yogurt with lower firmness (15 g compared with 17 g), lower Brookfield viscosity (6 Pa s compared with 9 Pa s), lower yield stress (2 Pa compared with 4 Pa), lower complex viscosity (13 Pa s compared with 26 Pa s), and lower apparent viscosity (0.4 Pa s compared with 1 Pa s) than the control, respectively. The yogurts with the lowest firmness and viscosity were produced with concentrates which contained the highest amount of non‐protein nitrogen fraction (160 g kg^?1 versus 126 g kg^?1 of the total nitrogen), and the highest amount of denaturation of the whey protein (262 versus 200 g kg^?1 of the total nitrogen). Copyright © 2004 Society of Chemical Industry     

The effect of inulin as a fat replacer on the quality of set-type low-fat yogurt manufacture

The influence of different levels of inulin on the quality of fat-free yogurt production was investigated. Inulin was added to milk containing 0.1% of milk fat to give inulin levels of 1, 2 and 3%. The experimental yogurts were compared with control yogurt produced from whole milk. The total solids content of milk was standardized to 14% by adding skim milk powder to the experimental yogurt. The chemical composition, pH, titratable acidity, whey separation, consistency, acetaldehyde and volatile fatty acidity contents were determined in the experimental yogurts after 1, 7 and 15 days. Sensory properties of the yogurts were evaluated during storage. The addition of inulin at more than 1% increased whey separation and consistency. Acetaldehyde, pH and titratable acidity were not influenced by addition of inulin. Tyrosine and volatile fatty acidity levels were negatively affected by inulin addition. With respect to the organoleptic quality of yogurt, inulin addition caused a decrease in organoleptic scores: the control yogurt had the highest score, and the lowest score was obtained in yogurt samples containing 3% of inulin. Overall, the yogurt containing 1% of inulin was similar in quality characteristics to control yogurt made with whole milk.     

蛋白质强化对搅拌型酸奶品质特性的影响

为了研究蛋白质强化对搅拌型酸奶品质特性的影响,以脱脂奶粉(SMP)和乳清浓缩蛋白-80(WPC-80)作为蛋白源,研究了强化不同种类及不同含量(2.7%、3.1%、3.5%、3.9%)的蛋白质强化对搅拌型酸奶感官品质、黏度和持水性的影响。结果表明:用SMP和WPC-80强化原料乳的蛋白质均可提高搅拌型酸奶的感官品质、黏度和持水性;比较同种蛋白源、不同蛋白质强化水平制得的搅拌型酸奶,其组织状态变化明显,风味稍有变化,色泽保持不变;酸奶的黏度和持水性都随蛋白质水平的上升而显著提高。SMP强化蛋白质含量至2.7%时,酸奶的感官品质最好;WPC-80含量则在3.5%时,酸奶的感官品质最好。同一蛋白质水平、不同强化蛋白相比较,WPC-80强化酸奶比SMP有更好的感官品质和更高的持水性,而SMP强化则得到更高的黏度值;从感官评定的黏稠度得分和测得的黏度值对比得出,搅拌型酸奶的黏度并不是越高越好,最佳黏度值在537～712mPa.s之间。实验中搅拌型酸奶的最佳蛋白强化配方为WPC-80强化蛋白质含量3.5%。     

Compositional and physical properties of yogurts manufactured from milk and whey cheese concentrated by ultrafiltration

Yogurts made with 80% milk retentate (MR) [Volume Reduction Factor (VRF) = 1.5] and 20% cheese whey retentate (WR; VRF = 8.0) (yogurt 1) and yogurts made with 100% MR through ultrafiltration have been evaluated as to flow, texture profile analysis (TPA) and syneresis index. As with MR and WR, their physico‐chemical composition was also determined. The yogurt to which WR had been added showed; less apparent viscosity and greater tixotrophya; less firmness and adhesiveness and greater cohesiveness; higher syneresis index, less protein and mineral content, and greater lipid content in comparison with the yogurt made only with MR.     

A microfiltration process to maximize removal of serum proteins from skim milk before cheese making

Microfiltration (MF) is a membrane process that can separate casein micelles from milk serum proteins (SP), mainly beta-lactoglobulin and alpha-lactalbumin. Our objective was to develop a multistage MF process to remove a high percentage of SP from skim milk while producing a low concentration factor retentate from microfiltration (RMF) with concentrations of soluble minerals, nonprotein nitrogen (NPN), and lactose similar to the original skim milk. The RMF could be blended with cream to standardize milk for traditional Cheddar cheese making. Permeate from ultrafiltration (PUF) obtained from the ultrafiltration (UF) of permeate from MF (PMF) of skim milk was successfully used as a diafiltrant to remove SP from skim milk before cheese making, while maintaining the concentration of lactose, NPN, and nonmicellar calcium. About 95% of the SP originally in skim milk was removed by combining one 3 x MF stage and two 3 x PUF diafiltration stages. The final 3 x RMF can be diluted with PUF to the desired concentration of casein for traditional cheese making. The PMF from the skim milk was concentrated in a UF system to yield an SP concentrate with protein content similar to a whey protein concentrate, but without residuals from cheese making (i.e., rennet, culture, color, and lactic acid) that can produce undesirable functional and sensory characteristics in whey products. Additional processing steps to this 3-stage MF process for SP removal are discussed to produce an MF skim retentate for a continuous cottage cheese manufacturing process.     

Effects of partially replacing skimmed milk powder with dairy ingredients on rheology, sensory profiling, and microstructure of probiotic stirred-type yogurt during cold storage

This study aimed to evaluate the quality of stirred-type skim milk probiotic yogurt fortified by partially replacing skim milk powder (SMP) with whey protein concentrate (WPC) and sodium caseinate (Na-CN) during cold storage for 28 d compared with nonfortified yogurt. The rheological properties (as measured using dynamic oscillation) and sensory profiles of probiotic yogurts were greatly enhanced when SMP (i.e., 45%) was replaced with WPC and Na-CN. Higher values of mechanical parameters related to storage and loss modulus and consistent microstructure were found in the fortified yogurts. The acidification profile was not affected by supplementation of the solids in the milk base, and the viable counts of probiotic microbiota were high and satisfactory. These positive characteristics of probiotic yogurts were maintained until the end of the storage period. The microstructure of the fortified yogurt showed some differences compared with the nonfortified product, which were due to changes in chemical composition of the milk base in addition to the colloidal characteristics of the product.