木糖发酵生产乙醇的研究

选育出一株优良的木糖发酵菌株树干毕赤酵母菌7124,并利用纯木糖优化了木糖发酵条件,利用海藻酸钠固定化树干毕赤酵母菌增殖细胞,不仅能较好满足限氧发酵条件,而且能耐较高糖浓度,使乙醇发酵浓度提高到20g/L。利用半纤维素水解液进行了乙醇发酵的初步研究,基本达到了纯木糖发酵的效果。     

树干毕赤酵母NLP31发酵产乙醇的研究

研究了树干毕赤酵母NLP31在木糖质量浓度为45 g/L的3种发酵培养基Ⅰ、Ⅱ和Ⅲ上发酵3轮的发酵性能以及在45 g/L木糖或混合糖(葡萄糖30 g/L,木糖15 g/L)的发酵培养基Ⅲ上的代谢历程。结果表明:树干毕赤酵母NLP31在发酵培养基Ⅲ上,乙醇浓度和乙醇得率均达到最高,分别为(17.29±0.15)g/L和(84.65±0.58)%。在45 g/L木糖或混合糖(葡萄糖30 g/L,木糖15 g/L)的发酵培养基Ⅲ上的代谢历程表明:混合糖发酵达到最大乙醇得率的时间仅为12 h,要比单一木糖发酵缩短了8 h。树干毕赤酵母NLP31在以廉价的无机N源为发酵培养基上的乙醇发酵性能高,能够降低燃料乙醇的生产成本。     

Ethanol production from pentoses and sugar-cane bagasse hemicellulose hydrolysate by Mucor and Fusarium species

The fermentation of carbohydrates and hemicellulose hydrolysate by Mucor and Fusarium species has been investigated, with the following results. Both Mucor and Fusarium species are able to ferment various sugars and alditols, including d-glucose, pentoses and xylitol, to ethanol. Mucor is able to ferment sugar-cane bagasse hemicellulose hydrolysate to ethanol. Fusarium F5 is not able to ferment sugar-cane bagasse hemicellulose hydrolysate to ethanol. During fermentation of hemicellulose hydrolysates, d-glucose was utilized first, followed by d-xylose and l-arabinose. Small amounts of xylitol were produced by Mucor from d-xylose through oxidoreduction reactions, presumably mediated by the enzyme aldose reductase¹ (alditol: NADP⁺ 1-oxidoreductase, EC 1.1.1.21). For pentose fermentation, d-xylose was the preferred substrate. Only small amounts of ethanol were produced from l-arabinose and d-arabitol. No ethanol was produced from l-xylose, d-arabinose or l-arabitol.     

Ethanol production from hardwood spent sulfite liquor using an adapted strain of Pichia stipitis

Conditions have been optimized for fermentation of pretreated hardwood spent sulfite liquor (HSSL) using an adapted strain of Pichia stipitis. The pretreatments, consisting of boiling and overliming with Ca(OH)₂ of HSSL, to partially remove inhibitors, and adaptation of the yeast strain to HSSL, were both critical for a successful fermentation. Ethanol concentration was increased from 6.7 to 20.2 g l⁻¹ using adapted P. stipitis (A) and pretreated HSSL. The maximum ethanol yield (Y _p/s) and productivity (Q _p) were 0.41 g g⁻¹ and 0.44 g l⁻¹ h⁻¹, respectively, at an oxygen transfer rate of 2.0 mmol O₂ l⁻¹ h⁻¹. The optimized results with this strain were compared to those of other xylose-fermenting yeasts and Saccharomyces cerevisiae (SSL-acclimatized) currently used at an industrial plant for the fermentation of spent sulfite liquor. Journal of Industrial Microbiology & Biotechnology (2001) 26, 145–150. Received 23 June 2000/ Accepted in revised form 21 October 2000     

Ethanol production from wheat straw hemicellulose hydrolysate by Pichia stipitis

Ethanol production was evaluated from wheat straw (WS) hemicellulose acid hydrolysate using an adapted and parent strain of Pichia stipitis. NRRL Y-7124. The treatment by boiling and overliming with Ca(OH)(2) significantly improved the fermentability of the hydrolysate. Ethanol yield (Yp/s) and productivity (Qp av) were increased 2.4+/-0.10 and 5.7+/-0.24 folds, respectively, compared to neutralized hydrolysate. Adaptation of the yeast to the hydrolysate resulted further improvement in yield and productivity. The maximum yield was 0.41+/-0.01 g(p) g(s)(-1), equivalent to 80.4+/-0.55% theoretical conversion efficiency. Acetic acid, furfurals and lignins present in the hydrolysate were inhibitory to microbial growth and ethanol production. The addition of these inhibitory components individually or in various combinations at a concentrations similar to that found in hydrolysate to simulated medium resulted a reduction in ethanol yield (Yp/s) and productivity (Qp av). The hydrolysate used had the following composition (expressed in g x l(-1)): xylose 12.8+/-0.25; glucose 1.7+/-0.3; arabinose 2.6+/-0.21 and acetic acid 2.7+/-0.33.     

Critical factors affecting ethanol production by immobilized Pichia stipitis using corn cob hemicellulosic hydrolysate

Fermentation of xylose from hydrolysate of acid-treated corn cob by Pichia stipitis is inhibited by acetic acid and lignin derivatives. In the present study, we have designed and implemented an immobilized cell culture for xylose to ethanol conversion from acid-treated corn cob hydrolysate without the removal of fermentation inhibitors. In this study, cultivations of suspended and immobilized Pichia were compared in terms of ethanol yield and productivity to investigate whether the cell immobilization could improve resistance to inhibitors. Cell immobilization clearly favored the fermentative metabolism in nondetoxified corn cob hydrolysate leading to an improvement of twofold ethanol productivity as compared to that achieved with suspension culture. Calcium alginate as an immobilization matrix was selected to immobilize Pichia cells. Concentrations of sodium alginate, calcium chloride, and fermentor agitation speed were optimized for ethanol production using statistical method. Statistical analysis showed that agitation speed had maximum influence on ethanol production by immobilized Pichia cells. In comparison to suspension culture, immobilization had a positive impact on the fermentative metabolism of Pichia, improving the ethanol yield from 0.40 to 0.43?g/g and productivity from 0.31 to 0.51?g/L/h for acid-treated corn cob hydrolysate.     

Influence of magnesium concentration on growth,ethanol and xylitol production by Pichia stipitis NRRL Y-7124

Summary The effect of Mg⁺² on Pichia stipitis growth and ethanol production was studied under condition of constant oxygen uptake rate (OUR) . Biomass/xylose and biomass/Mg⁺² yields increased with Mg⁺² concentration with a maximum value at Mg⁺² 4mM, ethanol being the main product obtained. At low Mg⁺² levels (ImM) 49 % of carbon flux to ethanol was redirected to xylitol production, accomplished through NADH intracellular accumulation.     

Xylitol production from aspenwood hemicellulose hydrolysate by Candida guilliermondii

The production of xylitol by the yeast Candida guilliermondii was investigated in batch fermentations with aspenwood hemicellulose hydrolysate and compared with results obtained in semi-defined media with a mixture of glucose and xylose. The hemicellulose hydrolysate had to be supplemented by yeast extract and the maximum xylitol yield (0.8 g g^–1) and productivity (0.6 g l^–1 h^–1) were reached by controlling oxygen input.     

An improvement in Pichia stipitis fermentation of acid-hydrolysed hemicellulose achieved by overliming (calcium hydroxide treatment) and strain adaptation

The fermentability of a corn cob, acid-hydrolysed hemicellulose by Pichia stipitis was considerably improved by pre-treatment with Ca(OH)₂. The total sugars utilized and ethanol yield for the untreated hydrolysate were 18% and 0.21 g/g, respectively, compared with 82% and 0.32 g/g respectively for the treated material. Adaptation of the yeast to the hydrolysate resulted in a significantly higher fermentation rate with over 90% of the initial total sugars being utilized and an ethanol yield and maximum ethanol concentration of 0.41 g/g and 13.3 g/l, respectively.The authors are with the USDA Forest Products Laboratory. One Gifford Pinchot Drive. Madison, WI, 53705 USA     

酚酮类对树干毕赤酵母乙醇发酵及脂肪酸组成的影响

木质素降解产物对微生物产生的抑制作用,是燃料乙醇生物炼制的主要瓶颈之一。本文以树干毕赤酵母为发酵菌株,研究木质素降解产物中3种酚酮类(4-羟基苯乙酮、4-羟基-3-甲氧基苯乙酮、4-羟基-3,5-二甲氧基苯乙酮)对其木糖乙醇发酵及酵母细胞脂肪酸组成的影响。采用高效液相色谱(HPLC)和气相色谱-质谱联用(GC/MS)技术对乙醇发酵性能和酵母细胞脂肪酸组成进行分析。研究结果表明,酚酮类物质对乙醇发酵呈现抑制作用且其分子量越低抑制作用越明显,当4-羟基苯乙酮浓度为1.50 g/L时,发酵24 h的木糖利用率、乙醇得率和乙醇浓度分别下降了42.47%、5.30%和9.76 g/L;培养基中存在酚酮类物质时,酵母细胞中的不饱和脂肪酸的比例上升,添加1.50 g/L的3种酚酮类物质后,树干毕赤酵母细胞不饱和脂肪酸和饱和脂肪酸的比例从原来的2.58分别上升到3.03、3.06和3.61,酵母细胞膜的流动性随之上升,不稳定性提高。因此,酚酮类物质能够降低酵母生长、提高不饱和脂肪酸的比例以及降低乙醇发酵能力,有效降低或去除木质素降解产物含量是提高木质纤维原料生物炼制的关键。     

Fermentation of sugar cane bagasse hemicellulose hydrolysate to l(+)-lactic acid by a thermotolerant acidophilic Bacillus sp.**

Sugar cane bagasse hemicellulose, hydrolyzed by dilute H2SO4, supplemented with mineral salts and 0.5% corn steep liquor, was fermented to L(+)-lactic acid using a newly isolated strain of Bacillus sp. In batch fermentations at 50 degrees C and pH 5, over 5.5% (w/v) L(+)-lactic acid was produced (89% theoretical yield; 0.9 g lactate per g sugar) with an optical purity of 99.5%.     

树干毕赤酵母酒精发酵碳元素代谢流向分析

实验对树干毕赤酵母（Pichia stipitis）进行了4个阶段共400 h连续恒化培养,在不同阶段以30.0 g/L葡萄糖作为基本碳源,添加30.0或15.0 g/L的木糖,通过控制温度（35±1）℃,进气量100～150mL/min,搅拌转速250～300 r/min。4个阶段共建立4个连续培养的"稳态"。对碳元素进行物料衡算发现,四个阶段碳元素回收率分别为118.0 %、105.6 %、113.5 %和94.7 %。对4个近似"稳态"的碳元素的代谢流向进行分析发现：将近50.0 %左右碳元素流向产物酒精,其次是CO2和酵母细胞;木糖醇浓度与流入底物中木糖浓度有直接关系,在相同发酵条件下流入的木糖浓度越大代谢生成木糖醇浓度也越高;实验所采用的通气条件更适合底物为30.0 g/L葡萄糖和30.0 g/L木糖混合液的连续发酵。     

Ethanol production from sulphuric acid wood hydrolysate ofPinus radiata using free and immobilized cells ofPichia stipitis

Summary Ethanol was produced by a strain ofPichia stipitis adapted to an inhibitory acid wood hydrolysate ofPinus radiata. The best ethanol productivity for batch cultures was 0.21 g/l h at 0.7% ethanol. Varying culture conditions increased ethanol concentration to 0.76%, however the productivity decreased to 0.18 g/l h. A decrease in ethanol concentration in the culture fluid was noted late in the batch which suggested ethanol catabolism. Values of kinetic parameters (K _m,K _s, _max, andV _max) were evaluated for this system. The use of calcium alginate immobilized cells in a continuous-flow stirred tank reactor lead to enhanced fermentative performance, namely a maximum productivity of 0.27 g/l h and 1.13% ethanol yield. The immobilized cells in continuous flow reactors represent an attractive option for fermenting sugars released by sulphuric acid hydrolysis ofP. radiata wood.     

Ethanol production from acid hydrolysates based on the construction and demolition wood waste using Pichia stipitis

The feasibility of ethanol production from the construction and demolition (C&D) wood waste acid hydrolysates was investigated. The chemical compositions of the classified C&D wood waste were analyzed. Concentrated sulfuric acid hydrolysis was used to obtain the saccharide hydrolysates and the inhibitors in the hydrolysates were also analyzed. The C&D wood waste composed of lumber, plywood, particleboard, and medium density fiberboard (MDF) had polysaccharide (cellulose, xylan, and glucomannan) fractions of 60.7-67.9%. The sugar composition (glucose, xylose, and mannose) of the C&D wood wastes varied according to the type of wood. The additives used in the wood processing did not appear to be released into the saccharide solution under acid hydrolysis. Although some fermentation inhibitors were detected in the hydrolysates, they did not affect the ethanol production by Pichia stipitis. The hexose sugar-based ethanol yield and ethanol yield efficiency were 0.42-0.46 g ethanol/g substrate and 84.7-90.7%, respectively. Therefore, the C&D wood wastes dumped in landfill sites could be used as a raw material feedstock for the production of bioethanol.     

树干毕赤酵母和酿酒酵母混合糖发酵产乙醇

以树干毕赤酵母和酿酒酵母为发酵菌株,酸性蒸汽爆破玉米秸秆预水解液和纯糖模拟液为C源,采用固定化酵母细胞的方法,研究了酸爆玉米秸秆预水解液初始pH、N源种类及其浓度、3种发酵模式对树干毕赤酵母戊糖发酵的影响。结果表明:玉米秸秆预水解液适合发酵的初始pH范围为6.0～7.0;1.0 g/L的(NH4)2SO4作为N源,在40 g/L葡萄糖和25 g/L木糖培养基中发酵24 h,糖利用率达到99.47%,乙醇质量浓度为24.72 g/L,优于尿素和蛋白胨作为N源;3种模式的发酵体系中,以游离树干毕赤酵母和固定化酿酒酵母发酵性能最好,糖利用率和乙醇得率分别为99.43%和96.39%。     

发酵木糖生产乙醇的野生菌和转基因菌的研究进展

木糖发酵是利用植物纤维原料生物转化制取乙醇工业化生产的技术基础和关键。野生酵母中有些种属菌株可以高效利用木糖产生乙醇,其中毕赤酵母（Pichiastipim）的乙醇转化速度最高达到0．99g／L／h,转化率几乎接近理论值0．5g／g,发酵液中最高乙醇浓度可迭到（61±9）g／L。但工业生产中要达到毕赤酵母所要求的微氧最佳发酵条件比较困难。近十几年来许多研究尝试根据代谢工程原理,利用基因工程技术对酿酒酵母进行改造。从而提高其发酵木糖产生乙醇的能力。这些研究大多是将毕赤酵母的一些木糖发酵关键酶基因（XYL1、XYL2、XYL3以及ADHl、ADH2等）转入酿酒酵母细胞内,并试图得到正常转录和表达。但到目前为止,大部分的重组菌株的乙醇发酵性能还没有达到工业生产的要求。     

Simultaneous saccharification and fermentation of steam-pretreated bagasse using Saccharomyces cerevisiae TMB3400 and Pichia stipitis CBS6054

Sugarcane bagasse--a residue from sugar and ethanol production from sugar cane--is a potential raw material for lignocellulosic ethanol production. This material is high in xylan content. A prerequisite for bioethanol production from bagasse is therefore that xylose is efficiently fermented to ethanol. In the current study, ethanolic fermentation of steam-pretreated sugarcane bagasse was assessed in a simultaneous saccharification and fermentation (SSF) set-up using either Saccharomyces cerevisiae TMB3400, a recombinant xylose utilizing yeast strain, or Pichia stipitis CBS6054, a naturally xylose utilizing yeast strain. Commercial cellulolytic enzymes were used and the content of water insoluble solids (WIS) was 5% or 7.5%. S. cerevisiae TMB3400 consumed all glucose and large fraction of the xylose in SSF. Almost complete xylose conversion could be achieved at 5% WIS and 32 degrees C. Fermentation did not occur with P. stipitis CBS6054 at pH 5.0. However, at pH 6.0, complete glucose conversion and high xylose conversion (>70%) was obtained. Microaeration was required for P. stipitis CBS6054. This was not necessary for S. cerevisiae TMB3400.     

A parametric study on ethanol production from xylose byPichia stipitis

Characteristics of ethanol production by a xylose-fermenting yeast,Pichia stipitis Y-7124, were studied. The sugar consumption rate and specific growth rate were higher in the glucose-containing medium than in the xylose-containing medium. Specific activities of xylose reductase and xylitol dehydrogenase were higher in the medium with xylose than glucose, suggesting their induction by xylose. Maximum specific growth rate and ethanol yield were achieved at 30 g xylose/L concentration without formation of by-products such as xylitol and acetic acid whereas a maximum ethanol concentration was obtained at 130 g/L xylose. Adding a respiratory inhibitor, rotenone, increased a maximum ethanol concentration by 10% compared with the control experiment. In order to evaluate the pattern of ethanol inhibition on specific growth rate, a kinetic model based on Luong’s equations was applied. The relationship between ethanol concentration and specific growth rate was hyperbolic for glucose and parabolic for xylose. A maximum ethanol concentration at which cells did not grow was 33.6 g/L for glucose and 44.7 g/L for xylose.     

系统代谢工程改造树干毕赤酵母生产琥珀酸

为提高树干毕赤酵母发酵生产琥珀酸的产量,借助基因组规模代谢网络模型iTL885获得琥珀酸合成的最佳代谢途径为扩增icl1基因和敲除sdh1基因。在此基础上,借助代谢工程策略构建过量表达异柠檬酸裂解酶基因icl1的重组菌株FPLicl、缺失琥珀酸脱氢酶基因sdh1的重组菌株FPLΔsdh和缺失sdh1基因同时过量表达icl1基因的重组菌株FPLΔsdh-icl。结果表明:3株重组菌的异柠檬酸裂解酶活性由0.33 U/mg分别增加为1.6、5.6和6.6U/mg;而琥珀酸脱氢酶活性则从13.8 U/mg分别降为10.7、0.3和0.3 U/mg。在以木糖为C源的培养基中,3株重组菌生产琥珀酸的能力分别是0.30、1.20和1.60 g/L。     

Alcohol fermentation of enzymatic hydrolysate of exploded rice straw by Pichia stipitis

The xylose in an enzymatic hydrolysate of steam-exploded rice straw was not consumed by Pichia stipitis until the glucose was almost exhausted. A diauxic lag of 2 to 3 h in both cell growth and ethanol production occurred as metabolism switched from glucose to xylose utilization. Ethanol production was maximal [6 g ethano/l from 15 g reducing sugars/l (78% theoretical yield)] at an aeration rate of 0.2 vol/vol. min.The author was with the Department of Chemical Engineering, Kanazawa University, Kanazawa 920, Japan, but is now with the Engineering Biosciences Research Center, Cater-Mattil Hall, The Texas A&M University System, College Station, Texas 77843-2476, USA.