Degradation and toxicity reduction of textile effluent by combined photocatalytic and ozonation processes

To minimize the environmental impact of textile effluents, mainly related to their high coloration and the presence of toxic or carcinogenic reactive dyes, the efficiency of photochemical and ozonation processes, applied in the form of isolated and combined procedures, were evaluated. The investigation was focused on the reduction of total organic carbon content (TOC), color and acute toxicity (monitoring by inhibition of Escherichia coli respiration). For a reaction time of 60 min, the anatase TiO2-assisted photocatalytic process produces color and TOC reduction of about 90% and 50%, respectively. Meanwhile, the ozonation process gives a decolorization of about 60% but negligible TOC reduction. When the processes were applied in a simultaneous form, the decolorization was almost complete and the TOC reduction was higher than 60%. The three treatments studied yield an acute toxicity reduction of around 50%.     

臭氧催化氧化降解苯胺的机理

对臭氧单独氧化和臭氧催化氧化下的苯胺降解效率进行了比较,并通过液质联机分析了氧化过程中产物变化情况。实验结果表明,催化剂MnO2-CuO-CeO2/沸石的添加能有效地提高臭氧氧化苯胺的降解率,当苯胺初始浓度为200mg/L,反应20 min后,苯胺的去除率由原来的75%提高到89%;通过LC-MS分析,臭氧催化氧化苯胺降解过程中代谢产物依次为对亚胺醌、对苯醌、马来酸和草酸,并由此推断出了臭氧催化氧化降解苯胺的途径。     

Degradation of diuron in aqueous solution by ozonation

Degradation of diuron [3-(3,4-dichlorophenyl)-1,1-dimethylurea] in aqueous solution and the proposed degradation mechanism of diuron by ozonation were investigated. The factors that affect the degradation efficiency of diuron were examined. The generated inorganic ions and organic acids during the ozonation process were detected. Total organic carbon removal rate and the amount of the released Cl^? increased with increasing ozonation time, but only 80.0% of the maximum theoretical concentration of Cl^? at total mineralization was detected when initial diuron concentration was 13.8 mg L^?1. For N species, the final concentrations of NO₃ ^? and NH₄ ⁺ after 60 min of reaction time were 0.28 and 0.19 mg L^?1, respectively. The generated acetic acid, formic acid and oxalic acid were detected during the reaction process. The main degradation pathway of diuron by ozonation involved a series of dechlorination-hydroxylation, dealkylation and oxidative opening of the aromatic ring processes, leading to small organic species and inorganic species. The degradation efficiency of diuron increased with decreasing initial diuron concentration. Higher pH value, more ozone dosage, additive Na₂CO₃, additive NaHCO₃ and additive H₂O₂ were all advantageous to improve the degradation efficiency of diuron.     

Degradation of diuron in aqueous solution by ozonation

Degradation of diuron [3-(3,4-dichlorophenyl)-1,1-dimethylurea] in aqueous solution and the proposed degradation mechanism of diuron by ozonation were investigated. The factors that affect the degradation efficiency of diuron were examined. The generated inorganic ions and organic acids during the ozonation process were detected. Total organic carbon removal rate and the amount of the released Cl(-) increased with increasing ozonation time, but only 80.0% of the maximum theoretical concentration of Cl(-) at total mineralization was detected when initial diuron concentration was 13.8 mg L(-1). For N species, the final concentrations of NO3(-) and NH4+ after 60 min of reaction time were 0.28 and 0.19 mg L(-1), respectively. The generated acetic acid, formic acid and oxalic acid were detected during the reaction process. The main degradation pathway of diuron by ozonation involved a series of dechlorination-hydroxylation, dealkylation and oxidative opening of the aromatic ring processes, leading to small organic species and inorganic species. The degradation efficiency of diuron increased with decreasing initial diuron concentration. Higher pH value, more ozone dosage, additive Na2CO3, additive NaHCO3 and additive H2O2 were all advantageous to improve the degradation efficiency of diuron.     

非均相催化臭氧氧化深度处理炼油废水

采用非均相催化剂催化臭氧氧化处理炼油废水,考察了催化剂负载率、pH、催化剂投加量和臭氧投加量及反应时间对处理效果的影响。结果表明,组合工艺最佳工艺条件为:催化剂负载率2.1%、pH 9、催化剂投量80 g/L、臭氧投量8.1 mg/L、反应时间60 min,COD、石油类、NH3-N、硫化物和SS去除率分别为91.3%、92.7%、80.5%、34.5%和59%。处理炼油废水过程中组合工艺存在明显协同效应,协同因子为1.47。中间臭氧氧化和催化臭氧氧化在最优工艺条件下对炼油废水COD的降解均符合准一级动力学规律。基于叔丁醇的实验结果,结合降解动力学可以推测,降解炼油废水过程中非均相催化剂催化臭氧产生高活性羟基自由基是降解效率提高的主导因素。     

臭氧氧化法处理反渗透浓缩垃圾渗滤液

采用臭氧氧化法处理经反渗透膜处理后的浓缩垃圾渗滤液,考察了反应时间、臭氧投量、pH和温度对COD,色度以及浓缩液中腐殖酸的去除影响,通过BOD₅/COD变化分析了臭氧氧化对浓缩液生化性的提高作用。结果表明：在pH 8.0,温度30℃,臭氧投量5 g/h,反应时间90 min的条件下,浓缩液的COD、色度以及浓缩液中腐殖酸的去除率分别达到67.6%、98.0%和86.1%, BOD₅/COD从0.008提升到0.26,生化性有很大提高。     

Degradation of industrial surfactants by photocatalysis combined with ozonation

The efficiency of titanium dioxide-mediated photocatalytic degradation of pollutants can be enhanced by combination with another advanced oxidation procedure such as ozonation. Mineralization of hydroxy- and dihydroxybenzenesulfonate based on these methods, both individually and combined, was investigated by monitoring the total organic carbon content, sulfate concentration, pH, high-performance liquid chromatography as well as the absorption spectral changes. The mineralization efficiency of the combined procedure significantly exceeded the sum of those of the individual techniques. The comparison of the disappearance of the starting material and the formation of the sulfate ions indicates that desulfonation is not the primary step of the degradation. Moreover, in the case of the combined method, ring cleavage, and thus, partial mineralization can occur without desulfonation. Efficient degradation of other, widely used industrial surfactants, such as alkylbenzene sulfonates and alkyl ether sulfates, was also achieved by heterogeneous photocatalysis combined with ozonation, offering an applicable method for the removal of these pollutants.     

Degradation of nitrogen containing organic compounds by combined photocatalysis and ozonation

The combination of TiO2-assisted photocatalysis and ozonation in the degradation of nitrogen-containing substrates such as alkylamines, alkanolamines, heterocyclic and aromatic N-compounds has been investigated. A laboratory set-up was designed and the influence of the structure of the N-compound, the TiO2 and ozone concentration on the formation of breakdown products were examined. The experimental results showed that a considerable increase in the degradation efficiency of the N-compounds is obtained by a combination of photocatalysis and ozonation as compared to either ozonation or photocatalysis only. The mineralization of the model substances was monitored by measurements of the TOC and ion-chromatographic determinations of the formed NO2- and NO3-. The temporal changes of concentrations of breakdown products, such as NH4+, short chain alkyl- and alkanolamines were determined by single column ion chromatography (SCIC) and as well as by electrospray mass spectrometry (EI-MS).     

Heterogeneous and homogeneous catalytic ozonation of benzothiazole promoted by activated carbon: kinetic approach

Ozone oxidation combined with activated carbon adsorption (O(3)/AC) has recently started to be developed as a single process for water and wastewater treatment. While a number of aspects of aqueous ozone decomposition are well understood, the importance and relationship between aqueous ozone decomposition and organic contaminant degradation in the presence of activated carbon is still not clear. This study focuses on determining the contribution of homogeneous and heterogeneous reactions to organic contaminants removal in O(3)/AC system. Benzothiazole (BT) was selected as a target organic pollutant due to its environmental concern. A reactor system based on a differential circular flow reactor composed by a 19 cm(3) activated carbon fixed bed column and 1 dm(3) storage tank was used. Ozone was produced from pure and dry oxygen using an Ozocav ozone generator rated at 5 g O(3)h(-1). Experimental results show that BT removal rate was proportional to activated carbon dosage. Activated carbon surface contribution to BT oxidation reactions with ozone, increased with pH in absence of radical scavengers. The radical reaction contribution within the pH range 2-11 accounted for 67-83% for BT removal in O(3)/AC simultaneous treatment. Results suggest that at pH higher than the pH of the point of zero charge of the activated carbon dissociated acid groups such as carboxylic acid anhydrides and carboxylic acids present on activated carbon surface could be responsible for the observed increase in the ozone decomposition reaction rate. A simplified mechanism and a kinetic scheme representing the contribution of homogeneous and heterogeneous reactions on BT ozonation in the presence of activated carbon is proposed.     

Degradation of methylparaben in water by corona plasma coupled with ozonation

The degradation of methylparaben (MeP) in water was investigated using a pulsed corona discharge generated in oxygen, above the liquid. A comparison was made between results obtained in semi-batch corona (SBC) configuration (stationary solution, continuous gas flow) and results obtained in a semi-batch corona with recirculation combined with ozonation (SBCR?+?O₃), where the liquid is continuously circulated between a solution reservoir and the plasma reactor and the effluent gas containing ozone is bubbled through the solution in the reservoir. It was found that MeP was completely degraded after 10–15 min of treatment in both configurations. Oxidation by ozone alone, in the absence of plasma, was a slower process. The energy efficiency for MeP removal (Y _MeP) and for mineralization (Y _TOC) was significantly higher in the SBCR?+?O₃ configuration (Y _MeP?=?7.1 g/kWh at 90 % MeP removal and Y _TOC?=?0.41 g/kWh at 50 % total organic carbon (TOC) removal) than in the SBC configuration (Y _MeP?=?0.6 g/kWh at 90 % MeP removal and Y _TOC?=?0.11 g/kWh at 50 % TOC removal).     

多相催化臭氧氧化技术处理染料废水生化出水

采用多相催化臭氧氧化技术对某染料废水一级好氧生化出水进行系统实验研究,考察该技术对废水COD、色度的去除能力,并探讨其提高废水可生化性的能力。结果表明：在最佳操作条件下,即臭氧投加量200 mg·L-1,接触时间20 min时,COD平均从647 mg·L-1降低到440 mg·L-1,臭氧化指数约等于1;进水色度2 000倍左右,色度去除率达95%以上;SOUR值平均提高至原水的4倍;毒性由65%左右降低至0%;GC-MS结果显示废水中苯胺类、挥发酚类和硝基苯类等有毒污染物几乎全部被去除。另外,对实验所用的自制催化剂（连续使用90 d）进行ICP、BET、SEM、EDS分析,其有效成分锰、铈基本无损耗,催化剂性能稳定。研究表明在废水处理一级生化阶段后增加多相催化臭氧技术,不仅能够进一步去除COD,还可以明显提高二级好氧生化脱氮能力,对于污水处理的升级改造具有重要意义。     

紫外光助臭氧化处理活性艳红K-2BP废水研究

以 30 0W高压汞灯为光源 ,研究了紫外光联合臭氧化、单纯臭氧氧化及单纯紫外光照处理 4 0 0mg/L的活性艳红K 2BP废水的可行性。结果表明 :光催化臭氧化可加速有机物的矿化。在同样时间条件下 ,三者氧化能力由大至小为 :UV/O3 >单独O3 >单独UV。运用TOC、紫外 可见光谱 (UV Vis)、毛细管电泳 (CE)等分析技术初步探讨了紫外光催化臭氧化活性艳红K 2BP溶液的降解效果及降解机理。     

不同晶型二氧化锰催化臭氧化降解亚甲基蓝废水

采用水溶液化学沉积法制备纳米二氧化锰,生成了δ-MnO2、γ-MnO2、α-MnO2,采用XRD、SEM和BET等手段进行了表征。以碱性染料亚甲基蓝为目标污染物,不同晶型纳米二氧化锰作吸附剂进行了静态吸附实验;在催化臭氧化亚甲基蓝的实验中,研究了溶液的pH值、催化剂的加量以及自由基引发剂与促灭剂对催化效果的影响。结果表明：3种催化剂δ-MnO2、γ-MnO2和α-MnO2的平衡吸附量分别为58.47、50.87和40.52 mg·g-1,其中δ-MnO2的吸附性能较强;3种催化剂的吸附动力学符合准二级吸附动力学。当溶液pH=11时,催化臭氧化反应体系对亚甲基蓝的降解效果最佳。在此催化臭氧化系统下,主要遵循的是羟基自由基的反应机理。δ-MnO2应用于催化臭氧化亚甲基蓝,不仅具有良好的脱色效果,并具有一定的矿化能力。     

臭氧氧化及其他强化技术协同降解聚乙烯醇

采用O₃氧化降解水中聚乙烯醇（PVA）,考察了O₃氧化的影响因素及与其他强化技术协同下的降解效果。结果表明,经12 min处理,O₃/超声波、O₃/紫外光协同作用下PVA降解率较直接O₃氧化的63.2%有显著提高,表现出了良好的协同效应。通过比较酸性条件下添加不同量Fenton试剂的作用效果可知,·OH的氧化作用是PVA降解的重要原因。     

非均相UV/Fenton氧化法降解水中六氯苯的研究

采用超声辐照促进浸渍法制备了非均相UV/Fenton催化剂Fe/Al2O3,并对其进行了表征.以制备的催化剂对水中六氯苯进行非均相UV/Fenton法氧化降解.考察了铁的负载量、初始pH、H2O2投加量、催化剂投加量和反应时间对六氯苯降解效果的影响,并探讨了六氯苯的降解动力学规律.结果表明,制备的催化剂表面活性组分分散均匀,对六氯苯具有较高的催化活性和重复利用性.非均相UV/Fenton法降解六氯苯的最佳实验条件为:铁的负载量为2%,废水初始pH为3,H2O2和Fe/Al2O3催化剂的投加量分别为34 mg/L和150 mg/L,反应时间为20 min.在此条件下,浓度为500μg/L的六氯苯降解效率达94.5%.HCB的降解反应动力学规律可用Langmuir-Hinshwood方程很好地描述.六氯苯在催化剂表面的吸附常数为1.962 L/mg,表面反应速率常数为0.08 mg/(L·min).     

Degradation of chlordecone and beta-hexachlorocyclohexane by photolysis, (photo-)fenton oxidation and ozonation

Intensive use of chlorinated pesticides from the 1960s to the 1990s has resulted in a diffuse contamination of soils and surface waters in the banana-producing areas of the French West Indies. The purpose of this research was, for the first time, to examine the degradation of two of these persistent pollutants – chlordecone (CLD) and beta-hexachlorocyclohexane (β-HCH) in 1 mg L^?1 synthetic aqueous solutions by means of photolysis, (photo-) Fenton oxidation and ozonation processes. Fenton oxidation is not efficient for CLD and yields less than 15% reduction of β-HCH concentration in 5 h. Conversely, both molecules can be quantitatively converted under UV-Vis irradiation reaching 100% of degradation in 5 h, while combination with hydrogen peroxide and ferrous iron does not show any significant improvement except in high wavelength range (>280 nm). Ozonation exhibits comparable but lower degradation rates than UV processes. Preliminary identification of degradation products indicated that hydrochlordecone was formed during photo-Fenton oxidation of CLD, while for β-HCH the major product peak exhibited C₃H₃Cl₂ as most abundant fragment.     

Aromatic photonitration in homogeneous and heterogeneous aqueous systems

This work describes the nitration of aromatics upon near-UV photolysis of nitrate and nitrite in aqueous solution and upon photocatalytic oxidation of nitrite in TiO2 suspensions. Phenol is used in this work as a model aromatic molecule and as a probe for *NO2/N2O4. The photoinduced nitration of phenol in aqueous systems occurs upon the reaction between phenol and *NO2 or N2O4, and is enhanced by the photocatalytic oxidation of nitrite to *NO2 by TiO2. Aromatic photonitration in the liquid phase can play a relevant role in the formation of nitroaromatics in natural waters and atmospheric hydrometeors, thus being a potential pathway for the condensed-phase nitration of aromatics. Furthermore, the photoinduced oxidation of nitrite to nitrogen dioxide suggests a completely new role for nitrite in natural waters and atmospheric aerosols.     

Degradation of ethylenethiourea pesticide metabolite from water by photocatalytic processes

In this study, photocatalytic (photo-Fenton and H₂O₂/UV) and dark Fenton processes were used to remove ethylenethiourea (ETU) from water. The experiments were conducted in a photo-reactor with an 80 W mercury vapor lamp. The mineralization of ETU was determined by total organic carbon analysis, and ETU degradation was qualitatively monitored by the reduction of UV absorbance at 232 nm. A higher mineralization efficiency was obtained by using the photo-peroxidation process (UV/H₂O₂). Approximately 77% of ETU was mineralized within 120 min of the reaction using [H₂O₂]₀ = 400 mg L^?1. The photo-Fenton process mineralized 70% of the ETU with [H₂O₂]₀ = 800 mg L^?1 and [Fe²⁺] = 400 mg L^?1, and there is evidence that hydrogen peroxide was the limiting reagent in the reaction because it was rapidly consumed. Moreover, increasing the concentration of H₂O₂ from 800 mg L^?1 to 1200 mg L^?1 did not enhance the degradation of ETU. Kinetics studies revealed that the pseudo-second-order model best fit the experimental conditions. The k values for the UV/H₂O₂ and photo-Fenton processes were determined to be 6.2 × 10^?4 mg L^?1 min^?1 and 7.7 × 10^?4 mg L^?1 min^?1, respectively. The mineralization of ETU in the absence of hydrogen peroxide has led to the conclusion that ETU transformation products are susceptible to photolysis by UV light. These are promising results for further research. The processes that were investigated can be used to remove pesticide metabolites from drinking water sources and wastewater in developing countries.     

碳纳米管/钒酸铋光催化降解盐酸四环素

采用静电纺丝技术制备了碳纳米管/钒酸铋（CNTs/BiVO4）光催化剂,利用SEM、XRD和UV-vis漫反射光谱对催化剂进行了表征。通过对盐酸四环素的降解,研究了CNTs/BiVO4在模拟可见光下的光催化降解性能,考察了pH对光降解率的影响,分析了不同活性基团在光催化过程中的作用。结果表明,制备出的CNTs/BiVO4具有较高可见光响应,且CNTs与BiVO4结合紧密,形成了单斜晶型支架结构。与BiVO4相比,CNTs/BiVO4光降解盐酸四环素的活性显著增强,催化性能提高的原因可能是由于催化剂中光生电子-空穴的高效分离造成的;同时发现随着溶液pH的增大,盐酸四环素的降解率减小。添加捕获剂的实验结果表明：空穴在CNTs/BiVO4光催化降解盐酸四环素的过程中起主导作用;但随着辐照时间的延长,·OH的作用越来越明显。     

Solar photocatalytic mineralization of commercial pesticides: acrinathrin

A comparative study of the degradation of commercial acrinathrin spiked in water using TiO2 photocatalysis and photolysis under sunlight was performed. Samples were analysed by liquid chromatography-diode array detector (HPLC-DAD) and gas chromatography-ion trap-mass spectrometric detector (GC-ITMS). Additional total organic carbon (TOC) analyses were carried out to evaluate the mineralisation rates. One photoproduct, 2-phenoxy benzaldehyde, was unequivocally identified and evaluated by GC-ITMS during the processes. Although acrinathrin is almost destroyed when exposed to irradiation for more than 400 h, photocatalysis with TiO2 noticeably reduced degradation to a few hours. In this case, with the additional presence of peroxydisulphate, in less than 2 h acrinathrin is completely destroyed. Mineralisation of acrinathrin, without catalyst, was only around 50% after 400 h of irradiation.