喷射环流反应器的放大效应

实验测量了两种塔径(?200和?500mm)和两种操作模式(气体单独喷射和气液同轴喷射)下喷射环流反应器内的全塔平均气含率、局部气含率及轴向液速径向分布、循环液速,归纳出全塔平均气含率的关联式。实验发现,喷射环流反应器具有十分显著的放大效应。小塔(?200)与大塔(?500)中的全塔平均气含率存在很大差异:小塔的全塔平均气含率～气速关系曲线比大塔陡峭,低气速下小塔气含率低于大塔、较高气速下高于大塔。根据漂移通量法分析得到小塔中流型转变点在表观气速0.1 m·s~(-1)左右,在实验气速范围内只存在拟均匀鼓泡流;大塔中流型转变点在表观气速0.04 m·s~(-1)左右,随气速增大从拟均匀鼓泡流转变为湍动鼓泡流。喷射环流反应器比气升式环流反应器、一般鼓泡塔全塔平均气含率略低,但循环液速更大,适用于强化固体悬浮与混合的气液固三相反应过程。     

逆流鼓泡塔气含率分布的试验测量与CFD模拟

利用热膜测速仪测得了气液逆流鼓泡塔内不同表观气速、表观液速和径向位置下的气液信号,采用改进的阈值法进行分析,得到塔内气含率的径向分布。结果表明气含率在各个截面上都是从塔中心到塔壁逐渐减小;同时利用计算流体力学方法对气液逆流的鼓泡塔内的气液两相流动进行了模拟,计算了不同气速和不同液速下的气含率,计算结果与试验数据吻合较好。     

气—液鼓泡塔中流动域和气含率的分布

利用压力传感器测定了气、液两相鼓泡塔内不同轴、径向位置上压强的脉动信号,分析了压强的脉动特征,计算了各种操作条件下塔内不同轴向位置截面上的平均气含率,发现在不同操作条件下,塔内可能出现不同的流动域分布,即全塔均匀鼓泡域、全塔过渡域、全塔湍动鼓泡域以及均匀鼓泡域,过渡域和湍动鼓泡域中的相邻2种或3种流域同时出现在塔内不同高度上。提出了不同轴向位置流域转变的判据。并发现,同一截面的不同径向位置基本处于同一流域内。同时研究了鼓泡塔内气含率在轴向上的分布规律,给出了不同流动域内气含率的关系式。     

鼓泡塔列管传热系数的测量与估算

在φ500 mm×5000 mm的冷模实验装置中,使用自制传热探头,对无内构件的空塔和安装31根竖直换热列管的鼓泡塔内列管传热系数进行了测量.实验表明,列管传热系数随表观气速的增加而增大,传热系数沿径向呈抛物型分布,垂直列管内构件的加入使得传热系数的径向分布变得更为陡峭.基于表面更新理论,结合鼓泡塔内气含率和液速分布的测量及计算结果,提出了计算传热系数的数学模型.该模型既可以用于空塔的局部传热系数与平均传热系数计算,也可以用于安装列管束的局部传热系数与平均传热系数计算.模型计算值与实验数据符合良好,最大相对误差为5.62％.     

加温加压下CFD-PBM耦合模型空气-水两相流数值模拟研究

计算流体力学与群体平衡模型（CFD-PBM）结合可有效地模拟鼓泡塔内流体行为,较准确地预测流场、相含率以及局部气泡尺寸分布。以直径100 mm、高1.3 m的加温加压鼓泡塔为模拟对象,在系统压力为1 MPa、表观气速为0.08~0.24 m/s、温度为30~160℃条件下系统地考察了空气-水体系的表观气速、温度以及固含率对平均气含率、大小气泡气含率、气泡直径和气泡尺寸分布等参数的影响。结果表明,平均气含率的模拟结果和实验值在10%的误差范围内吻合较好;温度的变化主要影响了塔内气泡的聚并和破碎,并用聚并破碎的机理解释了温度对其流体行为的影响。     

筛板结构对多级鼓泡塔中流体力学参数的影响

在外径0.3 m的多级鼓泡塔中采用双探针电导探头考察了筛板结构对鼓泡塔中筛板上下两处流体力学参数的影响,并与无筛板鼓泡塔中流体力学参数进行了对比。研究结果表明:带筛板的鼓泡塔中气含率径向分布规律和无筛板的鼓泡塔相类似,筛板上下二侧的平均气含率随表观气速的增加而增加;在鼓泡塔轴向位置上,筛板下侧的气含率普遍比筛板上侧气含率要高;筛板的孔分布方式对于气含率径向分布有着一定影响,但孔径大小对此影响较小。     

采用电阻层析成像技术测量气液加压鼓泡塔局部气泡参数

在内径0.3 m,高6.6 m的加压气液鼓泡塔反应器中,采用电阻层析成像技术(ERT)研究了空气-水体系中气泡群平均上升速度、局部气含率及其径向分布。在表观气速0.119~0.312 m s 1,压力0.5~2.0 MPa,考察了表观气速、压力对气泡群上升速度、局部气含率及其径向分布的影响。实验结果表明,鼓泡塔中局部气含率随着表观气速与压力的增大而增大,其径向分布呈现出中心高边壁低的分布特征,但整个截面的分布并非严格对称,在r/R=0~0.3,气含率变化较小,且极大值出现在该范围内;气泡群的局部上升速度随着表观气速的增大而增大,但是随着压力的增大而减小。     

浆态床鼓泡反应器中气含率的分布

为了解浆态床鼓泡反应器中气含率的分布规律,在浆态床鼓泡反应器冷模试验装置中,以空气-液体石蜡-氧化铝微球为试验介质对装置内部的气含率进行研究。利用压差法研究了表观气速、浆液固含量等操作条件对反应器床层总体气含率的影响,利用光纤探针法研究了浆态床反应器不同操作条件对局部气含率的影响,总结了反应器内部气含率的分布规律,并由此对工业浆态床鼓泡反应器的设计进行了研究。结果表明:浆态床反应器的总体气含率随表观气速的增大而增大,固体细颗粒的加入能适当降低总体气含率;在反应器底部,分布器对气体的均布作用明显,但表观气速的增大能够弱化分布器的作用;在反应器的中上部气含率不受分布器的影响,沿反应器径向呈现"中间高,边缘低"的分布趋势;在工业费托浆态床中,表观气速不宜低于0.12 m/s,内过滤系统适宜设置于反应器中上部靠近器壁的位置。     

浆态鼓泡床新型锐孔分布器气含率分布

在空气-水系统中,应用双头电导探针法,测量了采用新型锐孔分布器时浆态鼓泡床中气含率的轴向分布和径向分布规律,考察了表观气速、分隔板和液体循环等因索对床层气舍率分布的影响.结果表明,在实验范围内,气含率随轴向高度的增加而增加,表观气速较大时,主体区径向气含率分布比较均匀;气含率随表观气速的增加几乎成直线上升;加入分隔板,局部气含率增大且分布均匀.在主体区,对多组实验数据进行回归分析,得出了不同表观气速下气含率分布的关联式,关联式计算值与实验值吻合良好.     

电导探针法测量高固含体系循环液速和气含率

基于电导探针和示踪法,开发了一种利用电导探针同时测量环流反应器中高固含体系下循环液速和局部气含率的方法. 利用2个单针电导探头测量脉冲注入KCl饱和溶液后两路电导信号的先后响应,测得两路液体的停留时间分布曲线. 通过对单路信号进行幅值分析可以得到气含率,与压差法相比测量值误差小于5%;通过对过滤气泡信号后的液体的停留时间分布曲线进行相关处理可得到循环液速,测量值与超声多普勒(UDV)的测量结果一致. 实验研究了外环流反应器中操作条件对气含率和循环液速的影响. 结果表明,低表观气速下气含率沿径向分布较均匀,高于0.1 m/s后逐渐呈抛物线型分布,整体随表观气速增加而增大;循环液速随表观气速增加近似线性增大,随固含率增加而减小.     

Sapindaceae,cyanolipids, and bugs

Scentless plant bugs (Heteroptera: Rhopalidae) are so named because adults of the Serinethinae have vestigial metathoracic scent glands. Serinethines are seed predators of Sapindales, especially Sapindaceae that produce toxic cyanolipids. In two serinethine species whose ranges extend into the southern United States,Jadera haematoloma andJ. sanguinolenta, sequestration of host cyanolipids as glucosides renders these gregarious, aposematic insects unpalatable to a variety of predators. The blood glucoside profile and cyanogenesis ofJadera varies depending on the cyanolipid chemistry of hosts, and adults and larvae fed golden rain tree seeds (Koelreuteria paniculata) excrete the volatile lactone, 4-methyl-2(5H)-furanone, to which they are attracted.Jadera fed balloon vine seeds (Cardiospermum spp.) do not excrete the attractive lactone. Loss of the usual heteropteran defensive glands in serinethines may have coevolved with host specificity on toxic plants, and the orientation ofJadera to a volatile excretory product could be an adaptive response to save time.Mention of a commercial product does not consititute an endorsement by the USDA.     

2008～2009年世界塑料工业进展

收集了2008年7月～2009年6月世界塑料工业的相关资料,介绍了2008～2009年国外塑料工业的发展情况,提供了世界塑料产量、消费量及全球各类树脂的需求量及产能情况。按通用热塑性树脂(聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂)、工程塑料(尼龙、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚)、特种工程塑料(聚苯硫醚、液晶聚合物、聚醚醚酮)、通用热固性树脂(酚醛、聚氨酯、环氧树脂、不饱和聚酯树脂)不同品种的顺序,对树脂的产量、消费量、供需状况及合成工艺、产品应用开发、树脂品种的延伸及应用的进一步扩展等技术作了详细介绍。     

Direct observation of freeze-thaw instability of latex coatings via high pressure freezing and cryogenic SEM

Despite its industrial importance, the subject of freeze-thaw (F/T) stability of latex coatings has not been studied extensively. There is also a lack of fundamental understanding about the process and the mechanisms through which a coating becomes destabilized. High pressure (2100 bar) freezing fixes the state of water-suspended particles of polymer binder and inorganic pigments without the growth of ice crystals during freezing that produce artifacts in direct imaging scanning electron microscopy (SEM) of fracture surfaces of frozen coatings. We show that by incorporating copolymerizable functional monomers, it is possible to achieve F/T stability in polymer latexes and in low-VOC paints, as judged by the microstructures revealed by the cryogenic SEM technique. Particle coalescence as well as pigment segregation in F/T unstable systems are visualized. In order to achieve F/T stability in paints, latex particles must not flocculate and should provide protection to inorganic pigment and extender particles. Because of the unique capabilities of the cryogenic SEM, we are able to separate the effects of freezing and thawing, and study the influence of the rate of freezing and thawing on F/T stability. Destabilization can be caused by either freezing or thawing. A slow freezing process is more detrimental to F/T stability than a fast freezing process; the latter actually preserves suspension stability during freezing. Presented at the 82nd Annual Meeting of the Federation of Societies for Coatings Technology, October 27–29, 2004 in Chicago, IL. Tied for first place in The John A. Gordon Best Paper Competition.     

Insect antifeedant properties of anthranoids from the genusVismia

Vismiones and ferruginins, representatives of a new class of lypophilic anthranoids from the genusVismia were found to inhibit feeding in larvae of species ofSpodoptera, Heliothis, and inLocusta migratoria.     

Many Drugs of Abuse May Be Acutely Transformed to Dopamine,Norepinephrine and Epinephrine In Vivo

It is well established that a wide range of drugs of abuse acutely boost the signaling of the sympathetic nervous system and the hypothalamic–pituitary–adrenal (HPA) axis, where norepinephrine and epinephrine are major output molecules. This stimulatory effect is accompanied by such symptoms as elevated heart rate and blood pressure, more rapid breathing, increased body temperature and sweating, and pupillary dilation, as well as the intoxicating or euphoric subjective properties of the drug. While many drugs of abuse are thought to achieve their intoxicating effects by modulating the monoaminergic neurotransmitter systems (i.e., serotonin, norepinephrine, dopamine) by binding to these receptors or otherwise affecting their synaptic signaling, this paper puts forth the hypothesis that many of these drugs are actually acutely converted to catecholamines (dopamine, norepinephrine, epinephrine) in vivo, in addition to transformation to their known metabolites. In this manner, a range of stimulants, opioids, and psychedelics (as well as alcohol) may partially achieve their intoxicating properties, as well as side effects, due to this putative transformation to catecholamines. If this hypothesis is correct, it would alter our understanding of the basic biosynthetic pathways for generating these important signaling molecules, while also modifying our view of the neural substrates underlying substance abuse and dependence, including psychological stress-induced relapse. Importantly, there is a direct way to test the overarching hypothesis: administer (either centrally or peripherally) stable isotope versions of these drugs to model organisms such as rodents (or even to humans) and then use liquid chromatography-mass spectrometry to determine if the labeled drug is converted to labeled catecholamines in brain, blood plasma, or urine samples.     

Ethanol and (−)-α-Pinene: Attractant Kairomones for Bark and Ambrosia Beetles in the Southeastern US

In 2002–2004, we examined the flight responses of 49 species of native and exotic bark and ambrosia beetles (Coleoptera: Scolytidae and Platypodidae) to traps baited with ethanol and/or (−)-α-pinene in the southeastern US. Eight field trials were conducted in mature pine stands in Alabama, Florida, Georgia, North Carolina, and South Carolina. Funnel traps baited with ethanol lures (release rate, about 0.6 g/day at 25–28°C) were attractive to ten species of ambrosia beetles (Ambrosiodmus tachygraphus, Anisandrus sayi, Dryoxylon onoharaensum, Monarthrum mali, Xyleborinus saxesenii, Xyleborus affinis, Xyleborus ferrugineus, Xylosandrus compactus, Xylosandrus crassiusculus, and Xylosandrus germanus) and two species of bark beetles (Cryptocarenus heveae and Hypothenemus sp.). Traps baited with (−)-α-pinene lures (release rate, 2–6 g/day at 25–28°C) were attractive to five bark beetle species (Dendroctonus terebrans, Hylastes porculus, Hylastes salebrosus, Hylastes tenuis, and Ips grandicollis) and one platypodid ambrosia beetle species (Myoplatypus flavicornis). Ethanol enhanced responses of some species (Xyleborus pubescens, H. porculus, H. salebrosus, H. tenuis, and Pityophthorus cariniceps) to traps baited with (−)-α-pinene in some locations. (−)-α-Pinene interrupted the response of some ambrosia beetle species to traps baited with ethanol, but only the response of D. onoharaensum was interrupted consistently at most locations. Of 23 species of ambrosia beetles captured in our field trials, nine were exotic and accounted for 70–97% of total catches of ambrosia beetles. Our results provide support for the continued use of separate traps baited with ethanol alone and ethanol with (−)-α-pinene to detect and monitor common bark and ambrosia beetles from the southeastern region of the US.