巧克力风味牛奶的研制与开发

通过选用巧克力香精替代巧克力,以鲜牛奶为主要原料,选用L9(33)正交表,通过正交实验筛选最佳配方。结果表明,鲜牛奶85.0%,复合稳定剂0.16%,巧克力香精0.07%,食用色素0.106%,AK糖0.02%,可可粉0.4%,白砂糖2.0%(均为质量分数,下同)。产品经分析检测符合国家质量卫生标准,口感细腻,巧克力风味浓郁,奶香突出,色泽诱人,是一种很有发展前途的风味牛奶。     

Physicochemical properties of fermented Arabian mares' milk

Due to its numerous benefits, including health-promoting characteristics, there is increasing interest in finding product applications for mares' milk. In the present study, the physicochemical properties, turbidity and conductivity of Arabian mares' milk were studied during acidification by fermentation at 30 °C and compared with those of bovine milk. The data for the acidification rate were modelled using a logistic equation. Mares' milk showed a longer latency phase (284 min) and lower acidification rate (μ_max = 0.0052 dpH min^?1) compared with bovine milk (194 min and 0.0098 dpH min^?1 respectively). The general shape of the curves of the turbidity versus time and pH were similar in nature for the acidification of both milks. However, the characteristic points were different, due to the differences in casein micelle composition. Measurement of electrical conductivity during acidification showed that maximum demineralization of casein micelles started around pH 6.09 and 5.31, for mares' and bovine milk, respectively. In conclusion, the technological characteristics of mares' milk were very different from those of bovine milk, due to intrinsic physicochemical properties of both milks.     

Physicochemical and kinetic properties of purified sheep's milk xanthine oxidoreductase

Xanthine oxidoreductase (XOR) was purified for the first time from sheep's milk. The ultraviolet-visible absorption spectrum was essentially identical to those of the corresponding bovine, human, and goats' milk enzymes and showed an A280/A450 ratio of 5.35 +/- 0.24, indicating a high degree of purity. Like milk XOR from other species, sheep's milk enzyme showed a single band on SDS-PAGE corresponding to a subunit with approximate Mr 150,000. Xanthine oxidase activity of purified sheep's milk XOR (0.69 +/- 0.04 micromole urate min(-1) mg(-1)) was low relative to that of the bovine milk enzyme (1.83 +/- 0.02 micromole urate min(-1) mg(-1)), but higher than those of human or goats' milk XOR. As in the latter 2 cases, the low activity of sheep's milk XOR can be attributed to its relatively low molybdenum content (0.18 atoms per subunit), compared with that of the bovine milk enzyme (0.56 atoms Mo per subunit). Consistent with this, NADH oxidase activity of sheep's milk XOR was similar to that of enzymes purified from bovine, human, or goats' milk. The presence of desulpho-enzyme in sheep's milk XOR was demonstrated by resulfuration experiments, whereby xanthine oxidase activity was increased by approximately 75%.     

Physicochemical properties of whole soybean curd prepared by microbial transglutaminase

Whole soybean curd (WSC) was manufactured using micronized full-fat soybean (MFS) powder and microbial transglutaminase (TGase). The WSC prepared with 15% MFS had typical soybean curd texture with a hardness of 513 dyne/cm². It was confirmed that 7S and 11S protein fractions as major soy proteins disappeared in SDS-PAGE. Also, WSC prepared with 15% MFS and 10% TGase had excellent textural properties with a hardness of 645 dyne/cm² and springiness of 0.98. Addition of 0.5% gelatin in WSC prepared with 15% MFS and 5% TGase resulted in higher hardness (708 dyne/cm²) and springiness (0.98), as well as the highest values of G′ and G″. The surface properties of WSC were observed using a SEM, indicating the interrelationship of higher hardness and compact protein network filled with small cells. It was concluded that WSC prepared after heat treatment of 15% MFS at 95°C for 5 min, followed by an enzyme reaction with 10% TGase for 1 h, had more enhanced hardness and springiness than commercial WSC. Despite the addition of 5% TGase, WSC with improved textural properties can be manufactured by the fortification of 0.5% gelatin.     

Physicochemical properties of probiotic frozen yoghurt made from camel milk

The purpose of this research was to determine and compare the physicochemical properties of probiotic frozen yoghurts made from camel and cow milks. The results showed that the viscosity of frozen yoghurt made from camel milk was significantly higher (P < 0.05) than that from cow milk. Less fat was destabilised in frozen yoghurt made from camel milk. The frozen yoghurt made from camel milk required more time for melting than that from cow milk. Flavour scores of the frozen yoghurt made from camel milk constituents were significantly lower (P < 0.05) than those made from cow milk.     

Sugar reduction in probiotic chocolate-flavored milk: Impact on dynamic sensory profile and liking

Reducing the sugar content of processed products has been claimed to be one of the most efficient strategies for decreasing sugar intake. The present work aimed at studying the influence of sugar reduction on the dynamic sensory profile and consumers' liking of probiotic chocolate-flavored milks using a novel temporal methodology, and to evaluate two alternatives (vanilla flavor and thaumatin) to attenuate the sensory changes caused by sugar reduction. Probiotic chocolate-flavored milks were formulated with different reductions in added sugar (0, 20, 40 and 60%). Vanilla flavor and thaumatin were added to the sugar-reduced samples at two concentrations. Samples were evaluated by trained assessors using Temporal check-all-that-apply (TCATA). Additionally, consumers evaluated the dynamic sensory profile of a subset of the samples using TCATA and indicated their overall liking using a 9-point hedonic scale. Results from the present work showed that the main effect of sugar reduction on the dynamic sensory profile of the probiotic chocolate-flavored milks was related to changes in sweetness, bitterness and thickness. A reduction in added sugar of 20% led to changes in sweetness intensity, which were perceived by both trained assessors and consumers. However, consumers' liking was not significantly affected by sugar reduction up to 40%. The addition of vanilla flavor at suprathreshold concentrations was not efficient in increasing sweetness perception in chocolate-flavored milks with the lowest sugar reduction percentage, suggesting that it may not be a feasible alternative for reducing sugar in this product category. These results suggest that in many situations sugar content of food products could be decreased without a relevant impact on consumers' sensory and hedonic perception.     

Physicochemical,microbial, and sensory properties of nanopowdered eggshell-supplemented yogurt during storage

This study was carried out to investigate the possibility of adding nanopowdered eggshell (NPES) into yogurt to improve the functionality of yogurt and the effects of adding NPES on the physicochemical, microbial, and sensory properties of the products during storage. The pH and mean lactic acid bacteria counts of NPES-added (0.15–0.45%, wt/vol) yogurt ranged from 4.31 to 4.66 and from 6.56 × 10⁸ to 8.56 × 10⁸ cfu/mL, respectively, whereas these values ranged from 4.13 to 4.44 and 8.46 × 10⁸ to 1.39 × 10⁹, respectively, for the control samples during storage at 5°C for 16 d, which indicates a prolonged shelf-life with NPES-supplemented yogurt. Color analysis showed that the lightness (L*) and position between red and green (a*) values were not significantly influenced by the addition of NPES. However, the position between yellow and blue (b*) value significantly increased with the addition of the concentration (0.45%, wt/vol) of NPES at d 16 of storage. Sensory evaluation revealed that NPES-added yogurts showed a notably less sourness score and a higher astringency score than the control. An earthy flavor was higher in 0.45% NPES-supplemented yogurt compared with the control. Based on the results obtained from the current study, the concentration (0.15 to 0.30%, wt/vol) of NPES can be used to formulate NPES-supplemented yogurt without any significant adverse effects on the physicochemical, microbial, and sensory properties.     

Physicochemical and antioxidant properties of bovine caseinate hydrolysates obtained through microbial protease treatment

It is currently possible to obtain bioactive nutritional components through enzyme hydrolysis under well‐controlled and moderate conditions of pH and temperature. In this work, we aimed for the production and characterisation of bovine sodium caseinate (NaCAS) hydrolysates by means of an extracellular protease from Bacillus sp. P45. Antioxidant properties were evaluated through 2,2‐diphenyl‐1‐picrylhydrazyl and thiobarbituric acid reactive substances assays. A glucono‐δ‐lactone acid‐induced aggregation and gelation processes of the hydrolysates and their corresponding mixtures with NaCAS were also analysed. Hereby, we demonstrate that the presence of hydrolysates affects the kinetics of NaCAS aggregation processes but does not significantly alters the final state of the acid aggregates obtained.     

Physicochemical, microbial, and sensory properties of yogurt supplemented with nanopowdered chitosan during storage

This study was carried out to determine the possibility of adding nanopowdered chitosan (NPC) into cholesterol-reduced yogurt to improve the functionality of yogurt and the effects of adding NPC on the physicochemical, microbial, and sensory properties of the products during storage. The pH values and mean lactic acid bacteria counts of NPC-added (0.3 to ∼0.7%, wt/vol) and cholesterol-reduced yogurt ranged from 4.19 to 4.41 and from 4.75 × 10⁸ to 9.70 × 10⁸ cfu/mL, respectively, when stored at 4°C for 20 d, thereby indicating a possibility of prolonging the shelf life of yogurt. In color, the a* and b* values for cholesterol-reduced yogurt were not significantly influenced by the addition of NPC (0.1 to ∼0.7%, wt/vol); however, the L* values significantly decreased with the addition of the greatest concentration (0.7%, wt/vol) of NPC at 0-d storage. The sensory test revealed that the astringency scores significantly increased at 0-d storage when the greatest concentration (0.7%, wt/vol) of NPC was added into cholesterol-reduced yogurt. Based on the data obtained from the current study, it is concluded that concentrations (0.3 to ∼0.5%, vol/vol) of NPC could be used to produce an NPC-added and cholesterol-reduced yogurt without significantly adverse effects on the physicochemical, microbial, and sensory properties.     

Immunomodulatory properties of the milk whey products obtained by enzymatic and microbial hydrolysis

The objective of this study was to investigate the in vitro immunomodulatory effect of milk whey through enzymatic hydrolysis, microbial fermentation and two‐stage hydrolytic reactions (enzymatic and microbial reactions) by analysing cytokine profiles. Results indicated that the milk whey sample fermented by Lactobacillus kefiranofaciens M1 and two‐stage hydrolytic reactions (hydrolysed by Alcalase and then fermented by L. kefiranofaciens M1) could significantly induce the production of tumour necrosis factor (TNF)‐α and IL‐12 compared with the milk whey control and enzymatic treatments. Further characterisation of the immunomodulatory factor by membrane filtration and mutanolysin hydrolysation, the stimulatory activity for IL‐12 and TNF‐α production was found to be reduced and to be correlated positively with the cell wall components in L. kefiranofaciens M1. In addition, Th2‐polarised splenocytes revealed that L. kefiranofaciens M1 had both IL‐12 inducing and IL‐4 repressing activities. These results suggested that L. kefiranofaciens M1 could direct the Th1/Th2 balance toward Th1.     

Physicochemical and sensory properties of milk supplemented with lactase microcapsules coated with enteric coating materials

In this paper, we report the physicochemical and sensory properties of milk supplemented with a powder of microencapsulated lactase. The core material was lactase (β-galactosidase), the primary coating material was medium-chain triglyceride (MCT), and the secondary (enteric) coating material was either hydroxypropyl methylcellulose phthalate (HPMCP) or shellac, comparing both against market milk as a control. The physicochemical properties of both types of microcapsules were analyzed, including the particle size, zeta potential, and in vitro release behavior. To survey the stability of the microcapsules in milk during storage, we studied the residual lactose content and pH. Furthermore, to determine the properties of milk supplemented with the microcapsules, changes in color and sensory properties were evaluated during storage. The particle sizes (volume-weighted mean; D[4,3]) of the microcapsules coated with HPMCP or shellac were 2,836 and 7,834 nm, respectively, and the zeta potential of the capsules coated with shellac was higher than the zeta potential of those coated with HPMCP. The pH levels of milk supplemented with the lactase microcapsules were similar to those of the control (unsupplemented market milk); however, for milk supplemented with HPMCP-coated microcapsules, the pH was slightly lower. The core material, lactase, was released from the microcapsules during 12-d storage, and 18.82 and 35.09% of lactose was hydrolyzed in the samples for HPMCP- and shellac-coated microcapsules, respectively. The sensory characteristics of milk containing microcapsules coated with HPMCP did not show significant differences from the control, in terms of sweetness or off-taste, until 8 d of storage. However, shellac-coated microcapsules showed significant difference in sweetness and off-taste at d 8 and 6 of storage, respectively. The color of milk containing HPMCP-coated microcapsules did not show a significant difference during storage. However, that containing shellac-coated microcapsules was somewhat higher in color values than others. In particular, it showed significance from 0 to 4 d storage in L* and C* values. In conclusion, a powder of lactase microcapsules coated with HPMCP can be suitable as a supplement for milk.     

Physicochemical and functional properties of goat milk whey protein and casein obtained during different lactation stages

During lactation, goat milk contains colostrum, transitional milk, mature milk, and end milk. The protein present in goat milk during different lactation periods has different characteristics. This study aimed to characterize the protein profile of goat milk samples obtained at different lactation stages and to identify changes in the physicochemical and functional properties of whey protein and casein from goat milk collected at 1, 3, 15, 100, and 200 d after calving. The results demonstrated that the lactation period had a great influence on the physicochemical and functional properties of goat milk whey protein and casein, especially the protein properties of colostrum on the first day after delivery. The denaturation temperature, hydrophobicity, and turbidity of whey protein were significantly higher on the first day postpartum than at other lactation periods. Correspondingly, the colostrum whey protein also had better functional properties, such as emulsification, oil holding capacity, and foaming properties on the first day postpartum than at other lactation periods. For casein, the turbidity, particle size, water holding capacity, and foaming properties on the first day after delivery were significantly higher than those at other lactation periods, whereas the denaturation temperature, oil holding capacity, and emulsification followed the opposite trend. For both whey protein and casein, the 2 indicators of emulsifying properties, namely, emulsifying activity index and the emulsion stability, also followed an opposite trend relative to lactation stage, whereas the changes in foaming capacity with the lactation period were completely consistent with the change of foaming stability. These findings could provide useful information for the use of goat milk whey protein and casein obtained during different lactation stages in the dairy industry.     

Short communication: Physicochemical features and microbial community of milk kefir using a potential probiotic Saccharomyces cerevisiae KU200284

The aim of this study was to analyze the β-glucan contents, physicochemical features, and microbial communities in milk kefir prepared using Saccharomyces cerevisiae KU200284 isolated from cucumber jangajji, a fermented vegetable commonly eaten in Korean. Three types of milk kefir were manufactured, with (1) activated kefir grain, (2) activated kefir grain with commercial S. cerevisiae BOF, and (3) activated kefir grain with S. cerevisiae KU200284. β-Glucan contents of milk kefir using kefir grain and kefir grain with S. cerevisiae strains BOF and KU200284 were 8.29, 8.59, and 8.57%, respectively. The pH, titratable acidity, viscosity, Brix level, and alcohol contents of milk kefir using kefir grain with S. cerevisiae strains were acceptable compared with milk kefir using only kefir grain. In milk kefir produced using kefir grains and S. cerevisiae strains, 16S rRNA reads showed representative strains of Lactobacillus kefiranofaciens (>72% relative abundance) and Acetobacter fabarum (>16% relative abundance). In particular, milk kefir using kefir grain with S. cerevisiae KU200284 had the highest relative abundance of L. kefiranofaciens. In addition, the internal transcribed sequence (ITS) rRNA reads in tested milk kefir showed representative strains of Kluyveromyces marxianus (>52% relative abundance) and Saccharomyces cerevisiae (>16% relative abundance). In contrast, milk kefir using S. cerevisiae strains had higher relative abundance of S. cerevisiae (>37%). The β-glucan production, physicochemical properties, and microbial community profiling indicate that S. cerevisiae KU200284 could be used in functional dairy products as a starter culture.     

Characterisation of microbial diversity and chemical properties of Cheddar cheese prepared from heat-treated milk

Cheese made with low temperature/long time-treated milk and thermised milk (LC and TC, respectively) showed diverse bacterial community patterns, while cheese made with high temperature/short time-treated milk (HC) showed the lowest microbial diversity. Although the proportion of subdominant species was <1%, significant differences in community patterns were observed. In particular, the proportions of Lactobacillus casei and Lactobacillus delbrueckii in LC and TC were significantly greater than those in HC. Moreover, chemical analysis revealed the highest proteolytic and lipolytic activities in TC. Based on these results, the characteristics of Cheddar cheese were influenced by bacterial communities in low abundance, which were affected by the type of heating applied to the cheese milks. Furthermore, the diversity of these bacterial communities is highly correlated with the heat treatment of milk, and different treatment methods can be used to alter the chemical metabolism of lactose, fat, and protein during ripening.     

Physicochemical, microbiological and coagulating properties of ewe's milk produced on the Calabrian Mount Poro plateau

Three hundred individual ewe's milks and six bulk milks were analysed over two seasons. The results show that in spring but not in winter the milks examined conform substantially to the standards laid down by Italian legislation. Nevertheless, the data acquired constitute a good starting point from which the quality of ewe's milk produced on the Calabrian Mount Poro plateau should be improved, by performing selection of sheep for mastitis resistance based on somatic cell count, improving the hygiene standards at the dairy, using selected autochthonous lactic starter cultures and, only if strictly necessary, thermal treatment of the milk.     

Physicochemical,textural and sensory properties of white soft cheese made from buffalo and cow milk mixtures

The physicochemical, textural and sensory properties of white soft cheeses made from three different buffalo and cow milk mixtures (100:0, 70:30 and 30:70) during 3‐month storage were studied. The increase in buffalo milk concentration resulted in increasing total cheese yield, dry matter (DM) and fat retention and fat in DM content. However, it caused reductions in moisture content, salt intake, hardness, chewiness, elasticity, sensory hardness and sensory cohesiveness of the samples. The percentage of water‐soluble nitrogen to total nitrogen increased during storage resulting in decreased fracturability, hardness (textural and sensory), cohesiveness (textural and sensory), springiness, chewiness and elasticity. The panellists evaluated the white soft cheese made with buffalo milk as the most acceptable.     

Physicochemical properties of soy protein isolate gels emulsified with various oils using a microbial transglutaminase

Soy protein isolate (SPI) gels emulsified with oils including soybean, olive, palm, and eicosapentaenoic acid (EPA) were prepared by a microbial transglutaminase (MTGase). The hardness of 10% SPI gel was greatly increased by adding higher amount of oils. The emulsion gels prepared with 10% SPI and 30% olive oil showed the highest hardness of 1,711 g. In the gelation with various oil content (5–30%), the higher concentration of oils indicated the drastic increase of elastic modulus G′ and viscous modulus G″ during initial gelation for 7 min. The G′ value of SPI emulsion gel showed the 150 (soybean oil 30%), 147 (olive oil 30%), 121 (palm oil 30%), and 61 Pa (EPA 25%), respectively. In the color value of SPI emulsion gel, addition of higher concentration of oils resulted in the increase of L value (brightness), indicating 99.14 (L value) at 30% palm oil. The micro-structure of SPI emulsion gel entrapped with various oils showed the homogeneous network with small porosity compared with that of SPI gel without oil. In particular, SPI emulsion gel with 10% palm oil showed the compact structure distributed evenly with small porosity. Conclusively, the functional and rheological properties of SPI emulsion gel produced by catalytic action of MTGase could be modulated by the type and content of oils fortified.