Heat resistance of Listeria species to liquid whole egg ultrapasteurization treatment

The lethality of ultrapasteurization treatments (70 °C/1.5 min.) applied at constant temperature (isothermal condition) and at a constantly raising temperature of 2 °C/min (non-isothermal condition) in liquid whole egg (LWE) against two strains of Listeria monocytogenes (STCC 5672 and 4032) and one of Listeria innocua has been investigated. Isothermal survival curves up to 71 °C were obtained, which followed first-order inactivation kinetics. The obtained D_t values indicated that L. innocua was significantly (p < 0.05) more heat resistant than L. monocytogenes strains. Non-significant (p > 0.05) differences were observed among z values (12.4 ± 0.4 °C, 13.1 ± 0.4 °C and 12.2 ± 0.7 °C for L. innocua and L. monocytogenes 5672 and 4032, respectively). Based on obtained D_t and z values, isothermal ultrapasteurization treatment (70 °C/1.5 min.) would provide 3.5-, 5.0-, and 6.5-Log₁₀ cycles of L. innocua and L. monocytogenes 5672 and 4032, respectively. Non-isothermal heating lag phase increased the thermotolerance of Listeria species in LWE. The simulated industrial pasteurization treatment for LWE (heating-up phase from 25 to 70 °C followed by 1.5 min. at 70 °C) would attain 5-Log₁₀ reductions of L. monocytogenes 5672 and 4032, and 3.7-Log₁₀ reductions of L. innocua. Therefore, the safety level of industrial ultrapasteurization concerning L. monocytogenes could be lower than that estimated with data obtained under isothermal conditions.     

Bactericidal activity of lauric arginate in milk and Queso Fresco cheese against Listeria monocytogenes cold growth

Lauric arginate (LAE) at concentrations of 200 ppm and 800 ppm was evaluated for its effectiveness in reducing cold growth of Listeria monocytogenes in whole milk, skim milk, and Queso Fresco cheese (QFC) at 4°C for 15 to 28 d. Use of 200 ppm of LAE reduced 4 log cfu/mL of L. monocytogenes to a nondetectable level within 30 min at 4°C in tryptic soy broth. In contrast, when 4 log cfu/mL of L. monocytogenes was inoculated in whole milk or skim milk, the reduction of L. monocytogenes was approximately 1 log cfu/mL after 24 h with 200 ppm of LAE. When 800 ppm of LAE was added to whole or skim milk, the initial 4 log cfu/mL of L. monocytogenes was nondetectable following 24 h, and no growth of L. monocytogenes was observed for 15 d at 4°C. With surface treatment of 200 or 800 ppm of LAE on vacuum-packaged QFC, the reductions of L. monocytogenes within 24 h at 4°C were 1.2 and 3.0 log cfu/g, respectively. In addition, the overall growth of L. monocytogenes in QFC was decreased by 0.3 to 2.6 and by 2.3 to 5.0 log cfu/g with 200 and 800 ppm of LAE, respectively, compared with untreated controls over 28 d at 4°C. Sensory tests revealed that consumers could not determine a difference between QFC samples that were treated with 0 and 200 ppm of LAE, the FDA-approved level of LAE use in foods. In addition, no differences existed between treatments with respect to flavor, texture, and overall acceptability of the QFC. Lauric arginate shows promise for potential use in QFC because it exerts initial bactericidal activity against L. monocytogenes at 4°C without affecting sensory quality.     

Optimisation of accelerated solvent extraction of antioxidant compounds from rosemary (Rosmarinus officinalis L.), marjoram (Origanum majorana L.) and oregano (Origanum vulgare L.) using response surface methodology

The present study optimised the accelerated solvent extraction (ASE) conditions (Dionex ASE® 200, USA) to maximise the antioxidant capacity of the extracts from three spices of Lamiaceae family; rosemary, oregano and marjoram. Optimised conditions with regard to extraction temperature (66–129 °C) and solvent concentration (32–88% methanol) were identified using response surface methodology (RSM). For all three spices results showed that 129 °C was the optimum temperature in order to obtain extracts with high antioxidant activity. Optimal methanol concentrations with respect to the antioxidant activity of rosemary and marjoram extracts were 56% and 57% respectively. Oregano showed a different response to the effect of methanol concentration and was optimally extracted at 33%. The antioxidant activity yields of the optimal ASE extracts were significantly (p < 0.05) higher than solid/liquid extracts. The predicted models were highly significant (p < 0.05) for both total phenol (TP) and ferric reducing antioxidant property (FRAP) values in all the spices with high regression coefficients (R²) ranging from 0.952 to 0.999.     

Antimicrobial activity of acid-hydrolyzed Citrus unshiu peel extract in milk

Citrus fruit (Citrus unshiu) peels were extracted with hot water and then acid-hydrolyzed using hydrochloric acid. Antimicrobial activities of acid-hydrolyzed Citrus unshiu peel extract were evaluated against pathogenic bacteria, including Bacillus cereus, Staphylococcus aureus, and Listeria monocytogenes. Antilisterial effect was also determined by adding extracts at 1, 2, and 4% to whole, low-fat, and skim milk. The cell numbers of B. cereus, Staph. aureus, and L. monocytogenes cultures treated with acid-hydrolyzed extract for 12 h at 35°C were reduced from about 8 log cfu/mL to <1 log cfu/mL. Bacillus cereus was more sensitive to acid-hydrolyzed Citrus unshiu peel extract than were the other bacteria. The addition of 4% acid-hydrolyzed Citrus unshiu extracts to all types of milk inhibited the growth of L. monocytogenes within 1 d of storage at 4°C. The results indicated that Citrus unshiu peel extracts, after acid hydrolysis, effectively inhibited the growth of pathogenic bacteria. These findings indicate that acid hydrolysis of Citrus unshiu peel facilitates its use as a natural antimicrobial agent for food products.     

Effect of high-pressure processing on reduction of Listeria monocytogenes in packaged Queso Fresco

The effect of high-hydrostatic-pressure processing (HPP) on the survival of a 5-strain rifampicin-resistant cocktail of Listeria monocytogenes in Queso Fresco (QF) was evaluated as a postpackaging intervention. Queso Fresco was made using pasteurized, homogenized milk, and was starter-free and not pressed. In phase 1, QF slices (12.7 × 7.6 × 1 cm), weighing from 52 to 66 g, were surface inoculated with L. monocytogenes (ca. 5.0 log₁₀ cfu/g) and individually double vacuum packaged. The slices were then warmed to either 20 or 40°C and HPP treated at 200, 400, and 600 MPa for hold times of 5, 10, 15, or 20 min. Treatment at 600 MPa was most effective in reducing L. monocytogenes to below the detection level of 0.91 log₁₀ cfu/g at all hold times and temperatures. High-hydrostatic-pressure processing at 40°C, 400 MPa, and hold time ≥15 min was effective but resulted in wheying-off and textural changes. In phase 2, L. monocytogenes was inoculated either on the slices (ca. 5.0 log₁₀ cfu/g; ON) or in the curds (ca. 7.0 log₁₀ cfu/g; IN) before the cheese block was formed and sliced. The slices were treated at 20°C and 600 MPa at hold times of 3, 10, and 20 min, and then stored at 4 and 10°C for 60 d. For both treatments, L. monocytogenes became less resistant to pressure as hold time increased, with greater percentages of injured cells at 3 and 10 min than at 20 min, at which the lethality of the process increased. For the IN treatment, with hold times of 3 and 10 min, growth of L. monocytogenes increased the first week of storage, but was delayed for 1 wk, with a hold time of 20 min. Longer lag times in growth of L. monocytogenes during storage at 4°C were observed for the ON treatment at hold times of 10 and 20 min, indicating that the IN treatment may have provided a more protective environment with less injury to the cells than the ON treatment. Similarly, HPP treatment for 10 min followed by storage at 4°C was the best method for suppressing the growth of the endogenous microflora with bacterial counts remaining below the level of detection for 2 out of the 3 QF samples for up to 84 d. Lag times in growth were not observed during storage of QF at 10°C. Although HPP reduced L. monocytogenes immediately after processing, a second preservation technique is necessary to control growth of L. monocytogenes during cold storage. However, the results also showed that HPP would be effective for slowing the growth of microorganisms that can shorten the shelf life of QF.     

Antibacterial effects of natural tenderizing enzymes on different strains of Escherichia coli O157:H7 and Listeria monocytogenes on beef

This study determined the efficacy of actinidin and papain on reducing Listeria monocytogenes and three mixed strains of Escherichia coli O157:H7 populations on beef. The average reduction of E. coli O157:H7 was greater than that of L. monocytogenes and higher concentrations of either protease yielded greater reduction in bacterial populations. For instance, actinidin at 700 mg/ml significantly (p ≤ 0.05) reduced the population of L. monocytogenes by 1.49 log cfu/ml meat rinse after 3 h at 25 & 35 °C, and by 1.45 log cfu/ml rinse after 24 h at 5 °C, while the same actinidin concentration significantly reduced the populations of three mixed strains of E. coli O157:H7 by 1.81 log cfu/ml rinse after 3 h at 25 & 35 °C, and 1.94 log cfu/ml rinse after 24 h at 5 °C. These findings suggest that, in addition to improving the sensory attributes of beef, proteolytic enzymes can enhance meat safety when stored at suitable temperatures.     

Loss of viability of Listeria monocytogenes in contaminated processed cheese during storage at 4, 12 and 22 °C

The behaviour of Listeria monocytogenes in a processed cheese product was evaluated over time by inoculating the product with three different L. monocytogenes strains (Scott A, CA and a strain isolated from processed cheese) at three different inoculation levels (ca. 6 × 10⁵, ca. 6 × 10³ and 10² CFU/g of cheese or less) and after storage of the contaminated products at 4, 12 or 22 °C. Growth of L. monocytogenes was not observed in any of the experimental trials (experiments involving different combinations of strain, inoculum level and storage temperature) throughout the storage period. L. monocytogenes populations decreased over time with a rate that was strain- and storage temperature-dependent. Nonetheless, for cheeses that had been inoculated with the higher inoculum and stored at 4 °C viable populations of L. monocytogenes could be detected for up to nine months post-inoculation. The L. monocytogenes survival curves obtained from the different trials were characterised by a post-inoculation phase during which the populations remained essentially unchanged (lag phase) followed by a phase of logarithmic decline. The duration of the lag phase and the rate of inactivation of L. monocytogenes in the different trials were estimated based on data from the linear descending portions of the survival curves. In addition, a non-linear Weibull-type equation was fitted to the data from each survival curve with satisfactory results. The results of the present study emphasize that, according to the definition laid down in the European Union Regulation 1441/2007, the processed cheese product tested in this work should be considered and classified as one that does not support the growth of L. monocytogenes under reasonable foreseeable conditions of distribution and storage. However, post-processing contamination of the product should be austerely avoided as the pathogen can survive in the product for extended periods of time, particularly under refrigerated storage (4 °C).     

A predictive model for heat inactivation of Listeria monocytogenes biofilm on buna-N rubber

The purpose of this study was to develop a predictive model for the heat inactivation of Listeria monocytogenes in monoculture (strains Scott A and 3990) and with competing bacteria (Pseudomonas sp. and Pantoea agglomerans) formed on buna-N rubber with and without the presence of food-derived soil. Biofilms were produced on rubber disks in dilute Tryptic Soy broth (dTSB) with incubation for 48 h at 25 °C. Duplicate biofilm samples were heat treated for 1, 3, 5, and 15 min at 70, 72, 75, 77 and 80 °C and tested for survivors using enrichment media. The experiment was repeated six times. A predictive model was developed and plots were generated showing the percent probability of L. monocytogenes inactivation in biofilms after heat treatment. For example, to achieve a 95% probability level of complete inactivation required heat treatment of 76 °C for 6 min. The predicted model was validated using a five-strain cocktail of L. monocytogenes. The validated prediction model indicates that with proper maintenance of the time/temperature controls L. monocytogenes in biofilms on rubber surfaces will be inactivated. This model can be used as a tool in the selection of hot water sanitation processes for rubber surfaces.     

Effect of functional edible films and high pressure processing on microbial and oxidative spoilage in cold-smoked sardine (Sardina pilchardus)

The present experiment was an attempt to improve the shelf-life of cold-smoked sardine (Sardina pilchardus) using, singly or in combination, high pressure (300 MPa/20 °C/15 min) and gelatin-based functional edible films enriched by adding an extract of oregano (Origanum vulgare) or rosemary (Rosmarinus officinalis) or by adding chitosan. The uncoated muscle itself exhibited a certain level of antioxidant power (as measured by the FRAP method) ensuing from the deposition of phenols during smoking. Coating the muscle with the films enriched with the oregano or rosemary extracts increased the phenol content and the antioxidant power of the muscle, particularly when used in association with high pressure, due to migration of antioxidant substances from the film. The edible films with the added plant extracts lowered lipid oxidation levels (as measured by the peroxide and TBARS indices) and also, to a lesser extent, reduced microbial growth (total counts), whereas the gelatin–chitosan-based edible films lowered microbial counts (total counts, sulphide-reducing bacteria). Neither luminescent bacteria nor Enterobacteriaceae were detected in any of the batches. The combination of high pressure and edible films yielded the best results in terms of both preventing oxidation and inhibiting microbial growth.     

A comparison between E-beam irradiation and high pressure treatment for cold-smoked salmon sanitation: microbiological aspects

The effectiveness of electron beam irradiation and high pressure treatment for the sanitation of cold-smoked salmon from two points of view, microbial safety and shelf-life extension, was compared. From the response of L. monocytogenes INIA H66a to irradiation, a D value of 0.51 kGy was calculated. For samples stored at 5 °C, 1.5 kGy would be sufficient to attain a Food Safety Objective (FSO) of 2 log₁₀cfu/g L. monocytogenes for a 35-day shelf-life, whereas 3 kGy would be needed in the case of a temperature abuse (5 °C + 8 °C). Pressurization at 450 MPa for 5 min was considered to be an insufficient treatment, since the FSO of 2 log₁₀cfu/g L. monocytogenes was only attained for a shelf-life of 21 days at 5 °C. However, treatment at 450 MPa for 10 min achieved this FSO for samples held during 35 days at 5 °C, or during 21 days under temperature abuse (5 °C + 8 °C) conditions. Irradiation at 2 kGy kept the microbial population of smoked salmon below 6 log₁₀cfu/g after 35 days at 5 °C, with negligible or very light changes in its odor. Pressurization at 450 MPa for 5 min also kept the microbial population below 6 log₁₀cfu/g after 35 days at 5 °C and did not alter odor, but affected negatively the visual aspect of smoked salmon.     

Fat content increases the lethality of ultra-high-pressure homogenization on Listeria monocytogenes in milk

Listeria monocytogenes CCUG 15526 was inoculated at a concentration of approximately 7.0 log₁₀ cfu/mL in milk samples with 0.3, 3.6, 10, and 15% fat contents. Milk samples with 0.3 and 3.6% fat content were also inoculated with a lower load of approximately 3.0 log₁₀ cfu/mL. Inoculated milk samples were subjected to a single cycle of ultra-high-pressure homogenization (UHPH) treatment at 200, 300, and 400 MPa. Microbiological analyses were performed 2 h after the UHPH treatments and after 5, 8, and 15 d of storage at 4°C. Maximum lethality values were observed in samples treated at 400 MPa with 15 and 10% fat (7.95 and 7.46 log₁₀ cfu/mL), respectively. However, in skimmed and 3.6% fat milk samples, complete inactivation was not achieved and, during the subsequent 15 d of storage at 4°C, L. monocytogenes was able to recover and replicate until achieving initial counts. In milk samples with 10 and 15% fat, L. monocytogenes recovered to the level of initial counts only in the milk samples treated at 200 MPa but not in the milk samples treated at 300 and 400 MPa. When the load of L. monocytogenes was approximately 3.0 log₁₀ cfu/mL in milk samples with 0.3 and 3.6% fat, complete inactivation was not achieved and L. monocytogenes was able to recover and grow during the subsequent cold storage. Fat content increased the maximum temperature reached during UHPH treatment; this could have contributed to the lethal effect achieved, but the amount of fat of the milk had a stronger effect than the temperature on obtaining a higher death rate of L. monocytogenes.     

Fate of Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella on fresh-cut celery

Illnesses from Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella have been associated with the consumption of numerous produce items. Little is known about the effect of consumer handling practices on the fate of these pathogens on celery. The objective of this study was to determine pathogen behavior at different temperatures under different storage conditions. Commercial fresh-cut celery was inoculated at ca. 3 log CFU/g onto either freshly cut or outer uncut surfaces and stored in either sealed polyethylene bags or closed containers. Samples were enumerated following storage for 0, 1, 3, 5, and 7 days when held at 4 °C or 12 °C, and after 0, 8, and 17 h, and 1, and 2 days when held at 22 °C. At 4 °C, all populations declined by 0.5–1.0 log CFU/g over 7 days. At 12 °C, E. coli O157:H7 and Salmonella populations did not change, while L. monocytogenes populations increased by ca. 0.5 log CFU/g over 7 days. At 22 °C, E. coli O157:H7, Salmonella, and L. monocytogenes populations increased by ca. 1, 2, or 0.3 log CFU/g, respectively, with the majority of growth occurring during the first 17 h. On occasion, populations on cut surfaces were significantly higher than those on uncut surfaces. Results indicate that populations are reduced under refrigeration, but survive and may grow at elevated temperatures.     

Use of Carnobacterium maltaromaticum cultures and hydroalcoholic extract of Lippia sidoides Cham. against Listeria monocytogenes in fish model systems

Minimally processed refrigerated ready-to-eat fishes may offer health risk of severe infection to susceptible individuals due to contamination by the psychrotolerant bacterium L. monocytogenes. In this work, inhibition of L. monocytogenes by a plant extract and lactic acid bacteria (LAB) was studied in model fish systems kept at 5 °C for 35 days. For that, fillets of tropical fish “surubim” (Pseudoplatystoma sp.) and hydroalcoholic extract of the plant Lippia sidoides Cham. (“alecrim pimenta”) were used. Fish peptone broth (FPB), “surubim” broth and “surubim” homogenate were inoculated with combinations of L. monocytogenes and bacteriocin-producing Carnobacterium maltaromaticum (C2 and A9b⁺) and non bacteriocin-producing C. maltaromaticum (A9b^-), in the presence or absence of extract of “alecrim pimenta” (EAP). In all model systems, monocultures of L. monocytogenes and carnobacteria reached final populations ≥ 10⁸ CFU/ml after 35 days, except for L. monocytogenes in “surubim” homogenate (10⁴ CFU/ml). In FPB, EAP alone and combined with cultures of LAB inhibited L. monocytogenes but carnobacteria without EAP were only weakly antilisterial. In “surubim” broth, EAP alone did not prevent L. monocytogenes growth but cultures of carnobacteria combined or not with EAP inhibited L. monocytogenes, with more pronounced effect being observed for C. maltaromaticum C2, which produced bacteriocin. In “surubim” homogenate, EAP alone and combined with cultures of C. maltaromaticum A9b⁻ and A9b⁺ were strongly inhibitory to L. monocytogenes, while C. maltaromaticum C2 with EAP caused transient inhibition of L. monocytogenes. No significant inhibition of L. monocytogenes was observed for carnobacteria in “surubim” homogenate without EAP. In conclusion, it was observed that the use of EAP and cultures of carnobacteria have potential to inhibit L. monocytogenes in fish systems and the applications should be carefully studied, considering the influence of food matrix.     

Assessment of factors influencing antimicrobial activity of carvacrol and cymene against Vibrio cholerae in food

Carvacrol and cymene, phenolic compounds naturally present in the essential oil of oregano and thyme, were examined for their antimicrobial activity against Vibrio cholerae (ATCC 14033, VC1, and VC7) inoculated in carrot juice. Carvacrol exhibited a dose dependent inhibitory effect on the bacteria. Although cymene did not have antimicrobial activity against the bacteria, it enhanced the inhibitory ability of carvacrol. At 25 °C, the lowest concentrations of carvacrol and cymene required for zero detectable viable count varied depending on bacterial strains; 5 and 5 ppm, respectively, for VC7; 5 and 7.5 ppm, respectively, for VC1; and 7.5 and 7.5 ppm, respectively, for ATCC 14033. This study also examined several factors influencing the antimicrobial activity of carvacrol and cymene against V. cholerae ATCC 14033, including temperature, bacterial cell number, and food substrate. Carvacrol and cymene inhibited the bacterium in carrot juice at 25 °C more efficiently than at 15 and 4 °C. The doses of both compounds required for zero detectable viable count increased as the number of the bacterial cells in the carrot juice increased. The fat content and the complexity of foods were shown to decrease the antimicrobial activity of the compounds.     

Production of wara, a West African soft cheese using lemon juice as a coagulant

As an important protein source for West African consumers, wara cheese made from the leave extract of Calotropis procera has extremely short shelf life of only 2-3 days [Adegoke, G. O., Nse, E. N., & Akanni, A. O. (1992). Effects of heat, processing time, and pH on the microflora, aflatoxin content, and storability of wara, a soft white cheese. Die Nahrung, 36(3), 259-264; Umoh, V. J., & Solomon, O. (2001). Safety assessment and critical control point of milk product and some cereal beverages in Northern Nigeria. In: Proceedings of USDA/USAID/NIGERIA international conference on food safety and security, August 1-3 (pp. 122-127). Ibadan, Nigeria: IITA; Belewu, M. A., Belewu, K. Y., & Nkwunonwo, C.C. (2005). Effect of biological and chemical preservatives on the shelflife of West African soft cheese. African Journal of Biotechnology, 4, 1076-1079; Adetunji, A. O., Alonge, D. O., & Chen, J. (Unpublished). Microbial quality of wara, a southwestern Nigerian soft cheese]. Lemon juice was used in this study as a substitute coagulant during wara manufacture in order to improve the microbial quality of wara. The cheese was manufactured from pasteurized milk inoculated with 10¹ or 10² CFU ml⁻¹ of Listeria monocytogenes. Samples of the milk or cheese were taken along the manufacturing steps and during a 5 d storage period at 15 and 28 °C in order to determine the populations of L. monocytogenes, total aerobes, Enterobacteriaceae, and psychrotrophs, as well as mold and yeast. On the 4th day of storage, portions of the un-inoculated control cheese from 28 °C were deep fried in vegetable oil, mimicking the practice of West African local cheese processors. The results showed that L. monocytogenes, at both inoculation levels, did not survive the manufacture of wara. In samples initially inoculated with 10¹ CFU ml⁻¹ of L. monocytogenes, the Enterobacteriaceae counts decreased from the initial 1.78 to 1.00 Log₁₀ CFU g⁻¹ with the addition of lemon juice, and became undetectable (<1.00 Log₁₀ CFU g⁻¹) at the curdling point as well as during the 5 d storage period at both temperatures. The total aerobic counts increased from the undetectable level on the 1st day of storage to 7.65 and 3.39 Log₁₀ CFU g⁻¹, respectively at 28 or 15 °C on the 5th day of storage. The psychrotrophic, as well as the yeast and mold counts increased from the undetectable levels on the 1st day of storage to 7.11 and 5.03 Log₁₀ CFU g⁻¹, respectively at 28 °C. At 15 °C however, the population of pyschrotrophs remained undetectable throughout the 5 d storage period whereas, the yeast and molds count increased to 3.08 Log₁₀ CFU g⁻¹ on day 3 before quickly decreasing to the undetectable levels on the 5th day of storage. A similar trend was observed in cheese made from the milk with an initial Listeria inoculation level of 10² CFU ml⁻¹. The results of this study showed that lemon juice significantly reduced the populations of the sampled microorganisms, especially the populations of Enterobacteriaceae.     

Efficacy of bacteriophage LISTEXP100 combined with chemical antimicrobials in reducing Listeria monocytogenes in cooked turkey and roast beef

The aim of this study was to verify the effectiveness of the commercially available anti-Listeria phage preparation LISTEX^™P100 in reducing Listeria monocytogenes on ready-to-eat (RTE) roast beef and cooked turkey in the presence or absence of the chemical antimicrobials potassium lactate (PL) and sodium diacetate (SD). Sliced RTE meat cores at 4 and 10 °C were inoculated with cold-adapted L. monocytogenes to result in a surface contamination level of 10³ CFU/cm². LISTEX^TMP100 was applied at 10⁷ PFU/cm² and samples taken at regular time intervals during the RTE product's shelf life to enumerate viable L. monocytogenes. LISTEX^™P100 was effective during incubation at 4 °C with initial reductions of L. monocytogenes of 2.1 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef without chemical antimicrobials (there was no significant difference to the initial L. monocytogenes reductions in the presence of LISTEX^TMP100 for cooked turkey containing PL and roast beef containing SD-PL). In the samples containing no chemical antimicrobials, the presence of phage resulted in lower L. monocytogenes numbers, relative to the untreated control, of about 2 log CFU/cm² over a 28-day storage period at 4 °C. An initial L. monocytogenes cell reduction of 1.5 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef containing no chemical antimicrobials was achieved by the phage at 10 °C (abusive temperature). At this temperature, the L. monocytogenes cell numbers of samples treated with LISTEX™ P100 remained below those of the untreated control only during the first 14 days of the experiment for roast beef samples with and without antimicrobials. On day 28, the L. monocytogenes numbers on samples containing chemical antimicrobials and treated with LISTEX^TMP100 stored at 4 and 10 °C were 4.5 log₁₀ CFU/cm² and 7.5 log₁₀ CFU/cm², respectively, for cooked turkey, and 1.2 log₁₀ CFU/cm² and 7.2 log₁₀ CFU/cm², respectively, for roast beef. In both cooked turkey samples with and without chemical antimicrobials stored at 10 °C, the phage-treated samples had significantly lower numbers of L. monocytogenes when compared to the untreated controls throughout the 28-day storage period (P < 0.0001). For roast beef and cooked turkey containing chemical antimicrobials treated with LISTEX^TMP100 and stored at 4 °C, no more than a 2 log CFU/cm² increase of L. monocytogenes was observed throughout the stated shelf life of the product. This study shows that LISTEX^™P100 causes an initial reduction of L. monocytogenes numbers and can serve as an additional hurdle to enhance the safety of RTE meats when used in combination with chemical antimicrobials.     

Potential production and preservation of dahi by Lactococcus lactis W8, a nisin-producing strain

Lactococcus lactis W8 produced nisin concomitantly while fermenting milk to “dahi”, a traditional Indian fermented milk. The activity of nisin was detected at 3 h of fermentation, which increased in parallel to growth of the organism and reached its maximum at 6 h. The activity remained essentially stable thereafter. At 7 h of fermentation of milk with the strain L. lactis W8 the pH of the medium dropped to 4.2, when the milk became converted to dahi. The produced dahi displayed antibacterial property against spoilage and pathogenic bacteria including Listeria monocytogenes. When L. monocytogenes was mixed with dahi at 5.2 log CFU/ml and stored at 4 °C, the number of L. monocytogenes gradually decreased and became undetectable at 10 h. L. lactis W8 appeared to be a suitable starter culture for production of dahi from milk and preservation of the dahi.     

Chemical and biological characteristics of Cuminum cyminum and Rosmarinus officinalis essential oils

Essential oils extracted by hydrodistillation from Cuminum cyminum and Rosmarinus officinalis were characterized by means of GC and GC–MS. C. cyminum and R. officinalis contained α-pinene (29.1%, 14.9%), 1,8-cineole (17.9%, 7.43%) and linalool (10.4%, 14.9%), respectively, as the major compounds. C. cyminum oil exhibited stronger antimicrobial activity than did R. officinalis oil against E. coli, S. aureus and L. monocytogenes. Complete death time on exposure to Cuminum cyminum L. and Rosmarinus officinalis L. oils were 20 and 25 min 180 and 240 min and 90 and 120 min for E. coli, S. aureus and L. monocytogenes, respectively. Radical-scavenging and antioxidant properties were tested by means of 1,1-diphenyl-2-picrylhydrazyl (DPPH) assay and the β-carotene bleaching test. These properties were compared to those of Thymus x-porlock essential oil, used as a reference ingredient. The radical scavenging performance of the rosemary oil was better than that of C. cyminum. Results from the antioxidant test were better than those provided by the radical-scavenging activity. C. cyminum and R. officinalis essential oils may be considered as potent agents in food preservation.     

The probability of growth of Listeria monocytogenes in cooked salmon and tryptic soy broth as affected by salt,smoke compound,and storage temperature

The objectives of this study were to examine and model the probability of growth of Listeria monocytogenes in cooked salmon containing salt and smoke (phenol) compound and stored at various temperatures. A growth probability model was developed, and the model was compared to a model developed from tryptic soy broth (TSB) to assess the possibility of using TSB as a substitute for salmon. A 6-strain mixture of L. monocytogenes was inoculated into minced cooked salmon and TSB containing 0–10% NaCl and 0–34 ppm phenol to levels of 10^2–3 cfu/g, and the samples were vacuum-packed and stored at 0-–25 °C for up to 42 days. A total 32 treatments, each with 16 samples, selected by central composite designs were tested. A logistic regression was used to model the probability of growth of L. monocytogenes as a function of concentrations of salt and phenol, and storage temperature. Resulted models showed that the probabilities of growth of L. monocytogenes in both salmon and TSB decreased when the salt and/or phenol concentrations increased, and at lower storage temperatures. In general, the growth probabilities of L. monocytogenes were affected more profoundly by salt and storage temperature than by phenol. The growth probabilities of L. monocytogenes estimated by the TSB model were higher than those by the salmon model at the same salt/phenol concentrations and storage temperatures. The growth probabilities predicted by the salmon and TSB models were comparable at higher storage temperatures, indicating the potential use of TSB as a model system to substitute salmon in studying the growth behavior of L. monocytogenes may only be suitable when the temperatures of interest are in higher storage temperatures (e.g., >12 °C). The model for salmon demonstrated the effects of salt, phenol, and storage temperature and their interactions on the growth probabilities of L. monocytogenes, and may be used to determine the growth probability of L. monocytogenes in smoked seafood.