共查询到19条相似文献,搜索用时 812 毫秒
1.
2.
3.
4.
磷石膏作为一种化学石膏,应用方面存在障碍的主要原因在于其含有的杂质,如磷、氟及其他杂质等对其应用性能具有不同的影响。现有的研究认为磷石膏必须经过除杂才能应用忽略了杂质在某些应用领域的可利用性。在介绍磷石膏各成分对其应用性能的影响作用基础上,探讨了杂质的可能利用方面,为实际应用磷石膏时如何选用杂质处理方式提供一定参考理论。 相似文献
5.
6.
7.
8.
9.
10.
11.
磷石膏净化及石膏煅烧工艺综述 总被引:5,自引:1,他引:5
马行美 《硫磷设计与粉体工程》2003,(5):17-19
湿法磷酸生产副产的磷石膏数量大,对环境污染较严重,综合利用前均须进行处理。介绍了化学石膏主要品种的特性,杂质对石膏制品的影响,以及杂质在磷石膏粒度分布中的范围,综述了磷石膏净化及石膏煅烧工艺,认为慢烧工艺和速烧工艺各有优缺点,但煅烧后的建筑石膏粉都能满足生产石膏制品的质量要求。 相似文献
12.
13.
磷石膏是磷化工产业过程中产生的固体废弃物,其主要成分为CaSO4 ·2H2O,具有产量大、组分复杂等特征,阻碍了其在胶凝材料中的应用。本研究利用氧化钙的碱性来去除磷石膏中的酸性杂质,探究氧化钙改性磷石膏的机理,对磷石膏水泥基胶凝材料的物理性能进行考察,结合SEM分析胶凝材料水化产物情况。结果表明:氧化钙能够消除磷石膏中的酸性杂质,减弱其对二水石膏晶体定向生长的抑制作用;掺入氧化钙后胶凝材料的安定性合格,初凝时间和终凝时间均下降;氧化钙的掺入有利于水泥基胶凝材料强度的发展,最佳的氧化钙掺量为2%;SEM结果显示,氧化钙消除了杂质的抑制作用,水化作用增强,层状的二水石膏晶体出现,有利于胶凝材料强度的发展。 相似文献
14.
15.
Treating waste phosphogypsum for cement and plaster manufacture 总被引:3,自引:0,他引:3
Manjit Singh 《Cement and Concrete Research》2002,32(7):1033-1038
In the investigation reported in this paper, treatment of phosphogypsum with aqueous citric acid solution was attempted to purify phosphogypsum and improve its quality to make it fit for manufacture of cement and gypsum plaster for the first time. The treatment of gypsum converts phosphatic and fluoride impurities into water-removable citrates, aluminates and ferrates. The findings of chemical and physical tests and differential thermal analysis of the phosphogypsum with and without citric acid treatment established improvement of the treatment for purifying phosphogypsum. The purified phosphogypsum was found to have lesser amount of impurities of phosphates, fluorides and organic matter than the impure material. The Portland and Portland slag cements produced with purified phosphogypsum were found to have strength properties similar to those produced from mineral gypsum, whereas gypsum plaster produced conformed to the relevant Indian Standards. 相似文献
16.
阐述我国磷石膏的产排量与特点,以及磷石膏在石膏条板、纸面石膏板、水泥缓凝剂、石膏砌块、石膏砖、装饰材料、储能材料等方面的应用;介绍了石膏模盒技术及工业副产石膏在石膏模盒生产中的应用情况;对提高磷石膏综合利用率提出了应用建议。 相似文献
17.
Effect of phosphatic and fluoride impurities of phosphogypsum on the properties of selenite plaster 总被引:2,自引:0,他引:2
Manjit Singh 《Cement and Concrete Research》2003,33(9):1363-1369
The effect of phosphatic and fluoride impurities present in waste phosphogypsum on the setting time, strength development and morphology of selenite gypsum plaster have been studied. The results showed that soluble phosphates retard the setting and strength development of plaster while soluble fluorides decrease the setting time and reduce the density and strength. The gypsum crystals in the set plaster are modified from to euhedral to subhedral prismatic, rhombic, tabular and lath-shaped crystals of variable sizes interspersed with subhedral to anhedral needles. It is concluded that the formation of prismatic, rhombic and lathelike crystals retards the normal setting and strength development of selenite gypsum plaster. 相似文献
18.
钙芒硝石膏是工业上采用溶浸法生产元明粉的副产尾矿,与脱硫石膏和磷石膏等工业副产石膏相比其杂质含量高、纯度低、利用价值低。采用酸浸-重结晶工艺对钙芒硝石膏进行提纯,通过酸浸去除钙芒硝石膏中的酸溶性杂质,并将二水硫酸钙(DH)脱水转化为无水硫酸钙(AH),然后控制水化条件,使AH水化为大尺寸的DH晶体,并与小尺寸的酸不溶性杂质分离开来,得到高纯度的二水石膏。研究了硫酸浓度、水化激发剂、液固质量比、反应时间等对石膏提纯的影响。研究结果表明:常压下,在硫酸酸洗液质量分数为35%、反应温度为80 ℃、石膏与硫酸溶液固液质量比为1∶5、酸洗时间为2 h时能有效去除钙芒硝石膏中的酸溶性杂质;在水化硫酸质量分数为5%、硫酸钾质量分数为1.74%、反应温度为25 ℃、固液质量比为1∶6、陈化时间为18 h时能有效去除钙芒硝石膏中酸不溶性杂质,提纯后的石膏纯度可达97%以上。 相似文献
19.
我国磷石膏资源化利用现状及发展前景综述(待续) 总被引:2,自引:0,他引:2
介绍了磷石膏的基本性质、杂质类型砭其资源化利用中对预处理工艺的影响。论述了磷石膏在生产建筑用石膏、水泥、水泥缓凝剂、墙体材料等,以砭改良土壤、用作肥料等工农业资源化利用的现状及前景。我国磷石膏资源化利用的现状不容乐观,亟待加强政策扶持和产业联合,加快磷石膏综合利用步伐,减少环境污染。 相似文献