重轨钢非铝脱氧工艺研究

介绍了攀钢重轨钢非铝脱氧工艺，在满足钢中脆性夹杂物控制的前提下，采取“预脱氧＋终脱氧”的工艺，达到钢液脱氧良好，钢轨内部质量大幅提高，钢轨T[O],[Al]及氧化物夹杂评级完全满足200km/h高速铁路钢轨标准的要求。     

无取向电工钢中酸溶铝含量对夹杂物的影响

 为提高无取向电工钢成品性能及优化生产,采用SEM-EDS等分析方法分别对比分析了无取向电工钢生产时,不同酸溶铝含量的生产工艺对钢中夹杂物的影响。研究表明,当钢中酸溶铝含量w(Als)为0.2%～0.4%时,精炼过程所生成的夹杂物为高熔点的Al2O3和球状的MgO-Al2O3类夹杂物;当钢中w(Als)小于0.005%时,精炼过程所生成的夹杂物主要为塑性硅铝锰酸盐类夹杂;各工位夹杂物平均数量呈递减的趋势,且w(Als)为02%～0.4%的高碱度渣系控制生成的夹杂物总量低于后者。     

酸溶铝和铌含量对取向硅钢夹杂物特征的影响

摘 要：为了掌握Als（酸溶铝）和Nb含量对取向硅钢中夹杂物特征的影响,借助场发射扫描电镜(FE-SEM)结合能谱仪(EDS)和图像分析软件研究了钢中夹杂物类型、数量、尺寸及尺寸分布,结合钢液凝固过程中溶质元素的微观偏析模型,重点分析了Als和Nb含量影响钢中AlN和NbN析出的机制。结果表明,钢中的夹杂物以NbN、AlN和AlN-NbN为主,夹杂物尺寸分布由Als和Nb含量综合影响。Als含量的增加使含氧复合夹杂物中Al2O3含量增加,SiO2含量降低,促进了钢中硅酸盐类氧化物夹杂的去除,但大大增加了AlN和AlN-NbN夹杂的偏析析出。Nb含量的增加使夹杂物的平均尺寸变小,促进了钢中NbN在凝固前沿的提前析出和以氧化物为核心析出。Als主要影响钢中的氧化物和氮化物夹杂,Nb通过影响与Als结合的O和N的活度影响钢中氧化物和氮化物夹杂的析出特性。     

重轨钢无铝脱氧工艺的研究

钢中铝夹杂对重轨钢性能有较大影响,其中铝脱氧钢中Al2O3夹杂是钢轨产生疲劳断裂的主要原因,减少重轨钢中Al2O3夹杂是很有必要的.因此,重轨钢的冶炼采用无铝脱氧工艺.针对重轨钢无铝脱氧的特点,对冶炼过程钢中铝含量控制、钢包炉扩散脱氧工艺、真空碳脱氧工艺和钙处理夹杂物控制进行研究.并把该技术应用到实际生产.结果表明,采用无铝脱氧工艺,通过控制炉渣组成、RH碳脱氧技术及钙处理工艺可把钢中w([O])降到20×10-6以下,满足洁净重轨钢的要求.     

帘线钢中酸溶铝含量的变化及其对夹杂物的影响

 研究了采用LD－RH－LF－CC工艺流程生产帘线钢时,钢中酸溶铝含量的变化情况。研究发现,精炼过程中酸溶铝含量略有下降,但连铸过程中酸溶铝含量急剧下降。夹杂物中Al2O3含量随着酸溶铝含量的上升而逐渐增大。SiO2含量降低时夹杂物熔点提高。采用低碱度、低Al2O3含量的顶渣精炼工艺,严格控制钢中w(［Als］)在0.0005%～0.001%范围内,促进夹杂物上浮,有利于钢中氧化物夹杂的数量减少、尺寸细小和塑性化。     

帘线钢夹杂物塑性化控制的实验室研究

根据热力学计算,渣系的碱度0.5~1.2,w(Al2O3)10%~25%时夹杂物控制在塑性区域。实验室实验表明,夹杂物中w(CaO+MgO)/w(SiO2)比值和w(Al2O3)随钢中w(Als)增加而增加,钢中w(Als)应低于6×10-6;当精炼渣碱度为0.8~1.0,w(Al2O3)为0%~10%时,在实验室能实现对钢中夹杂物的塑性化控制。     

Als对U71Mn材质钢轨相关性能的影响

研究了杭钢生产U71Mn材质钢轨的过程中，Als的含量对钢轨强度、钢轨伸长率以及钢轨硬度的影响。研究结果表明，ms对钢轨强度Rm的影响波动较大，总的规律是随着Ms含量的增大，钢轨强度Pun趋势线微幅上升；Als对钢轨伸长率的影响则是明显的起到提高作用；Als对钢轨硬度的影响随着Als含量的增加，呈下降趋势。     

高洁净度钢轨钢的夹杂物控制技术

针对国内生产350 km/h高洁净度钢轨存在非金属夹杂物控制的核心问题,开展了相关研究.通过采用适宜的钢包底部吹氩模式和钢包渣组成,显著提高了钢中非金属夹杂物的去除率,T[O]去除率提高近40%;对硫化物夹杂的变性处理有效地控制了钢轨钢中夹杂组成和形态.这些技术在350 km/h高洁净度钢轨钢生产中的应用,不仅使钢轨的T[O]降到10.17×10-6,而且A类和B、C、D类非金属夹杂物评级分别≤2.0级和1.0级,实现了350km/h高洁净度钢轨钢的批量生产.     

150 t BOF-LF-VD-CC流程无铝脱氧工艺高速轨钢冶炼过程的夹杂物行为

时速350 km高速钢轨要求钢中全氧含量T[O]≤20×10^-6,非金属夹杂物B、C、D类≤1.0级。国内在重轨钢冶炼中,通常采用无铝脱氧工艺,即采用SiCaBa合金强化脱氧,形成了低熔点的Mn-Al-Si-Ba-Ca多元型氧化物夹杂,该类夹杂物在精炼中全部排出钢液。研究了铁水预处理脱硫-150 t顶底复吹转炉-LF-VD-280 mm ×380 mm连铸流程冶炼钢轨钢U71MnG时的夹杂物行为,包括无铝脱氧工艺钢轨钢中氧化物夹杂的组成及特征,转炉终点[C]对钢水氧活度的影响以及LF精炼渣碱度和VD后期软吹氩搅拌对钢氧含量和夹杂物的影响。结果得出,钢轨头部的≤20μm氧化物夹杂为精炼时二次脱氧产物,通过控制转炉终点[C]＞0.15%,控制精炼渣碱度(CaO)/(SiO₂)=2.5~3,∑(FeO+MnO)≤1.0%可有效降低钢轨钢中氧化物的数量和尺寸。     

超深冲冷轧薄板钢的酸溶铝控制

采用转炉复合吹炼、铝线加铝机加铝和连续铸铜过程大包保护浇注工艺生产超深冲冷轧薄板钢,能够稳定地提高该钢的酸溶铝(Als)命中合格率,同时能收到纯净钢液、降低钢中氮含量和减少Al_2O_3夹杂的效果。     

Introduction to the special section on cognitive processes and psychotherapy.

Theoretical models featuring cognitive processes have played a fundamental role in advancing knowledge of psychopathology and its treatment and have emphasized the importance of cognition in psychotherapy. Recognition of the importance of cognition in psychotherapy has led to a number of questions that are addressed by the articles in this special section of the Journal of Consulting and Clinical Psychology. Cognitive therapy is well represented in the articles in this special section, but therapeutic procedures that do not represent typical cognitive therapy are also examined. The articles in this special section focus on homework in the modification of cognition, cognition in the treatment of anxiety in adults and in children, change in depressive cognitions in children, cognition and rapid change in the treatment of depression, and the role of cognition in the treatment and prevention of depression that is recurrent. Examination of these types of questions holds the possibility of advances in existing treatments and the possibility of innovations in new treatments. (PsycINFO Database Record (c) 2010 APA, all rights reserved)     

球团链箅机回转窑工艺中氯和硫元素迁移规律

摘要：对链箅机回转窑工艺中各段球团样品进行实验分析,研究了氯元素和硫元素在链箅机回转窑工艺中的迁移规律,明晰了烟气中HCl的生成机制。结果表明,球团原料中的氯元素主要是以NaCl的形式存在,氯元素有一部分在链箅机抽风干燥段会转变成HCl气体并进入烟气,一部分在链箅机预热Ⅱ段之后以NaCl的形式汽化进入烟气,剩余的氯元素仍以NaCl的形式存在于成品球团矿中。烟气中的HCl气体是在抽风干燥段,由富含SO2的烟气与含水球团料层中的NaCl发生反应生成的,烟气中SO2转变成Na2SO4重新固定于料层中。在预热Ⅰ段和预热Ⅱ段,烟气中的SO2与原料中碳酸钙分解生成的游离CaO反应生成CaSO4,也会重新固定烟气中的SO2。     

基于风险管控的矿区污染修复技术与模式综述

矿区环境的污染防治与生态修复是促进我国“十四五”生态文明建设的重要内容之一，促进风险管控与修复技术集成是治理矿山污染的必然趋势。回顾了近年来我国矿区污染的主要修复类与管控类技术，总结了风险管控模式下矿区污染场地一般修复思路，并在此基础上归纳概括了4种我国矿区的修复管控模式与实施案例，包括基于污染物时空分布、迁移转化规律、场地利用方式及风险等级的矿区修复管控模式。以期为未来我国建立涵盖风险标准体系与技术体系的场地治理模式提供参考与支撑。     

转炉双渣操作炉渣中磷微区分布规律

对转炉双渣操作时的前期渣和终点渣中微观区域里磷的微观富集规律进行了研究,发现微区碱度Rm为2.0～2.5的微区中磷的富集程度最高;前期渣和终点渣中钙质量分数分别为16%～20%、33%～37%的微区中磷质量分数较高;微区磷富集与硅质量分数关系密切,终点渣微区中硅质量分数为9%～12%、前期渣微区中硅质量分数为13%～14%时,磷质量分数最高;微区铁质量分数对磷富集的影响明确,铁质量分数为5%～9%时磷质量分数最大;镁质量分数低的微区中磷质量分数较高。     

冷却速率对KR脱硫渣中硫析出行为的影响

KR脱硫渣中主要成分(CaO)为转炉冶炼的优质造渣原料,通过氧化性气氛将渣中硫脱除后可将其用于转炉冶炼.但由于炉渣冷却制度不同,渣中硫的析出行为和赋存状态会发生变化,对炉渣氧化脱硫效果产生影响.基于此,以合成渣的形式探究冷速对KR脱硫渣中硫析出行为的影响,旨在明确KR脱硫渣中硫赋存状态及析出行为与冷却速率的关系,为后续...     

Tension and Compression Stability and Second-Order Analyses of Three-Dimensional Multicolumn Systems: Effects of Shear Deformations

The stability and second-order analyses of three-dimensional (3D) multicolumn systems including the effects of shear deformations along the span of each column are presented in a condensed manner. This formulation is an extension to an algorithm presented recently by the writer in 2002 and 2003 by which the critical load of each column, the total critical load, and the second-order response of a 3D multicolumn system with semirigid connections can be determined directly. The proposed solution includes not only the combined effects of flexural deformations and shear distortions along the columns in their two principal transverse axes, but also the effect of the shear forces along each member induced by the applied end axial force as the columns deform and deflect (as suggested by Haringx in 1947 and explained by Timoshenko and Gere in 1961) in their two principal transverse axes. The extended characteristic transcendental equations (corresponding to multicolumn systems with sidesway and twist uninhibited, partially inhibited, and totally inhibited) that are derived and discussed in this publication find great applications in the stability and second-order analyses of 3D multicolumn systems made of materials with relatively low shear stiffness such as orthotropic composite materials (fiber reinforced plastic) and multilayer elastomeric bearings used for seismic isolation of buildings. The phenomenon of buckling under axial tension in members with relatively low shear stiffness (observed by Kelly in 2003 in multilayer elastomeric bearings, and recently discussed by the writer in 2005) is captured by the proposed method. Tension buckling must not be ignored in the stability analysis of multicolumn systems made of columns in which the shear stiffness GAs is of the same order of magnitude as π2EI/h2.     

O. Chanute, C.E.

Octave Chanute was one of the leading civil engineers in the United States in the period between 1850 and 1890. His work on eastern and western railroads was unsurpassed. He began his bridge building career in 1856 and designed his last major bridge in 1888. Starting in 1890, he began his study in the work that others conducted in the area of manned flight and designed and tested many of his own gliders. He later assisted the Wright Brothers in their experiments in Dayton and at Kitty Hawk.     

Educational Partnership to Establish Engineering/Construction Management Graduate Programs in Algeria

This paper describes a partnership between the University of Missouri–Rolla and the Université Abou-Bekr Belka?d de Tlemcen in Algeria in order to support the development of programs of instruction and faculty training in Algeria in the areas of engineering and construction management in order to create a self-sustaining educational infrastructure in Algeria. Specifically, the partnership aims to provide educational and technical assistance to Algeria in order for them to develop: (1) new graduate programs in engineering and construction management and (2) modern teaching methodologies including Internet and distance learning. Objectives of the partnership were to provide engineering and construction management skills and expertise in order to achieve international standards in the management area. The desired impact is summarized in terms of the ability to identify operations problems and implement solutions for improved strategic competitiveness, make sound decisions, plan, and control the key resources of an organization—money and people, critically analyze, evaluate, improve, or adapt existing technical and managerial systems, design and develop new technical and managerial systems, and coordinate different projects with a better harmony and cost effectiveness. The long-term expected outcomes of the partnership are Algerian faculty with strong backgrounds in engineering and construction management, a self-sustained learning environment for Algerian institutions, including engineering management and construction management graduate programs, continuing education, and short courses, and Internet-based multimedia teaching material for collaboration between the Algerian institutions and local industry.     

某铀矿区水稻土—地表水铀含量对稻米铀含量的影响

以水稻土—地表水铀含量为视角,从水稻土剖面铀含量分布规律、水稻土与下伏岩体稀土元素特征、不同河流不同河段水稻土—地表水—稻米铀含量特征、水稻土与稻米铀含量关系4个方面研究721铀矿区稻米铀含量成因。结果表明,水稻土剖面铀含量从表层至半风化花岗质基岩层呈明显降低的特征,说明水稻土铀含量高的原因不是土壤母质铀含量高;岩石与水稻土稀土元素标准化模式均表现为向右倾斜型,均属轻稀土富集型,轻稀土分馏明显,表明水稻土为还原环境,吸附作用较强;不同河流不同河段水稻土—地表水—稻米铀含量平均值的特性均为上游最低、中游最高、下游次之。铀矿区地表水环境符合铀元素在水稻土中被平衡吸附的动力学条件,有利于铀元素在矿区内河流中游地区的水稻土中沉淀富集;正在采矿区水稻土与稻米铀含量具有高度的空间耦合性,呈指数正相关关系,相关系数0.749。矿区内河流沿岸稻米铀含量的分布特征是由铀元素的迁移途径决定的"采矿活动(铀尾矿露天堆放)→地表水→水稻土"。     

Do positive thinking and meaning mediate the positive affect—Life satisfaction relationship?

The authors tested whether positive cognitions mediated the relationships between positive affect and both meaning in life and life satisfaction, and whether meaning in life partially mediated the relationship between positive cognitions and life satisfaction, among 232 students and community-dwelling adults. Also tested was an alternative model in which positive affect mediated the relationships between positive cognitions and both meaning in life and life satisfaction, and in which meaning in life partially mediated the relationship between positive affect and life satisfaction. Supporting hypotheses and the literature, positive cognitions mediated the relationship between positive affect and meaning in life, and meaning in life partially mediated the relationship between positive cognitions and life satisfaction. Together, positive affect and positive cognitions accounted for 48% of the variance in meaning in life, and the model accounted for 62% of the variance in life satisfaction. (PsycINFO Database Record (c) 2011 APA, all rights reserved)