Aliquat 336萃取醋酸的平衡特性

选择Aliquat 336为萃取剂 ,氯仿、正辛醇和煤油为稀释剂 ,醋酸稀溶液为分离溶质 ,研究了稀释剂种类、反应剂浓度、水相 pH值、溶质在水相的浓度等因素对醋酸萃取分配系数的影响 ,分析了Aliquat 336萃取醋酸的机理 ,并在此基础上建立了描述萃取平衡的数学模型 .结果表明 :萃取结果基本符合反应剂与稀释剂的简单加和 ;稀释剂对萃取效果的影响显著 ,随Aliquat 336浓度的增大 ,氯仿和煤油为稀释剂时的萃取能力较正辛醇增加得快 ;随 pH值的变化D存在一个最大值 ,该值只与反应剂在有机相中的浓度有关 .Aliquat 336萃取醋酸存在阴离子交换和化学缔合两种机制 ,表观的阴离子交换反应平衡常数K₁在有稀释剂的条件下比纯反应剂时有所增大 ,其中氯仿的影响相对较大 ,表观的化学缔合反应平衡常数K₂ 在有稀释剂的条件下表现为 ,惰性稀释剂煤油对K₂ 的影响不明显 ,氯仿具有强化的作用 ,而正辛醇具有削弱Aliquat 336与醋酸化学缔合的能力 .     

三烷基胺(7301)络合萃取对氨基苯磺酸稀溶液

利用三烷基胺 (730 1 )为络合剂 ,在较宽的 pH值条件下实验测定了对氨基苯磺酸稀溶液的萃取相平衡分配系数 ;分析了络合剂浓度、稀释剂种类以及溶液 pH值对络合萃取相平衡分配系数的影响 ;讨论了络合剂萃取对氨基苯磺酸偶极离子的质子转移过程 ,提出了平衡分配系数D值的表达式 .     

三烷基氧磷萃取对氨基苯酚的性能

以三烷基氧磷(TRPO)为反应萃取剂,研究了稀释剂种类、溶液pH值等因素对对氨基苯酚稀溶液反应萃取分配系数(D)的影响,提出了同时考虑反应萃取和物理萃取作用的分配系数的表达式.结果表明：TRPO对对氨基苯酚的萃取主要通过与其中性分子的氢键缔合和溶剂化效应实现,D值的变化与中性分子的摩尔分数有关;稀释剂的极性对对氨基苯酚的萃取影响较小;除20%TRPO/正庚烷体系外,拟合实验数据得到的表观萃取平衡常数变化较小;体系的物理萃取分配常数则随TRPO浓度的增大而增大,且符合稀释剂和TRPO的物理萃取能力的简单加和;酸性、碱性和中性的反应萃取剂都可有效地萃取对氨基苯酚,萃取能力为二(2-乙基己基)磷酸＞ TRPO ＞ 三烷基胺,相应的操作pH值为2～3、4～5和6.5～7.5,应用时可根据体系的pH值范围选用相应的萃取剂,而不必调节溶液的pH值.     

草酸与乙醛酸的萃取分离

以草酸和乙醛酸的稀溶液为分离对象 ,采用三辛胺 (TOA)为萃取反应剂、正辛醇为稀释剂 ,研究了单溶质、双溶质有机酸的萃取分离特性 ,测定了溶液pH值、萃取反应剂的浓度等因素对双溶质有机酸萃取的影响 ,提出了萃取的化学反应发生在有机相中的假定 ,建立了TOA萃取草酸的数学模型 .实验结果表明 ,草酸与TOA的萃合物有 1∶1和 1∶2两种形式 .在本实验的条件范围内 ,草酸的分配系数较乙醛酸大 ,且随溶液pH值的增大而下降 ,草酸对乙醛酸的分离系数随pH值的增大而减小 .随萃取反应剂浓度的增大 ,两酸的分配系数皆随之增大 ,分离系数也随之增大 ,而且对于高浓度的萃取反应剂在较高的溶液pH值下草酸仍具有较大的分离系数 .采用单溶质萃取反应平衡常数及纯稀释剂中双溶质的分配系数预测双溶质萃取的结果 ,预测值与实验值相当接近     

三烷基氧磷络合萃取邻氨基苯酚的研究

络合萃取技术对极性有机物稀溶液的分离具有高效性和高选择性,然而对同时具有Lewis酸性和Lewis碱性两种官能团化合物的络合萃取研究得相对较少。为了探讨该技术对两性有机化合物萃取规律,今以三烷基氧磷（TRPO）为萃取剂,邻氨基苯酚为萃取溶质,研究了稀释剂种类、溶液pH值以及溶质浓度等因素对邻氨基苯酚稀溶液萃取平衡分配比的影响;根据可逆络合萃取的基本理论,提出了同时考虑萃取剂络合萃取作用和稀释剂物理萃取作用的分配比的表达式。并通过参数寻优求出邻氨基苯酚的物理萃取分配常数m和表观化学反应萃取平衡常数K。结果表明,邻氨基苯酚主要通过氢键缔合与OAP的中性分子发生络合反应而萃入有机相,其在惰性稀释剂煤油中的分配比大于其在极性稀释剂正辛醇中的分配比。     

S-苄基异硫脲盐酸盐对苯酚的络合萃取研究

以S—苄基异硫脲盐酸盐为络为剂，正辛醇、四氯化碳、苯为稀释剂，测定了萃取剂对苯酚溶液的相平衡分配系数，讨论了稀释剂种类、萃取剂浓度和水相pH值对分配系数的影响。     

不同pH值下酚类的络合萃取

络合萃取法分离极性有机物稀溶液具有高效性和高选择性。在已有工作基础上,利用三正辛胺(TDA)、磷酸三丁酯(TBP)为络合剂,正辛醇、甲墓异丁基酮(MIBK)或煤油为稀释剂,在较宽的pH值条件下实验测定了酚类稀溶液的萃取相平衡分配系数;讨论了络合剂种类、络合剂浓度、稀释剂种类以及被萃取溶质种类对络合萃取相平衡分配系数的影响;提出了同时考虑络合萃取作用和物理萃取作用的平衡分配系数的表达式。     

溶剂萃取法处理苯酚稀溶液及其废水的研究

为探索工业含酚废水处理的适宜萃取剂,选用具有物理萃取和络合萃取作用的两类萃取剂正辛醇、甲基异丁基甲酮(MIBK)和磷酸三丁酯(TBP)(以煤油为稀释剂)进行了苯酚稀溶液萃取性能的实验研究。测定了不同溶液pH值、初始苯酚浓度和TBP浓度条件下的萃取平衡数据,分析了各萃取剂萃取平衡的规律及机理。结果表明,虽然各萃取剂的萃取机理不同,但在酸性和中性范围内都可获得较大的萃取平衡分配系数,所以,这三种萃取剂的适宜pH值操作条件为酸性和中性,且在稀溶液的范围内溶剂的萃取能力为TBP > MIBK >正辛醇,而在极稀的苯酚浓度条件下(<20mgL-1),则为正辛醇> TBP > MIBK。同时,正辛醇、TBP处理工业含酚废水的错流萃取实验表明,若考虑通过单一的萃取方法使得废水中苯酚的浓度达到国家排放标准(0.5mgL-1),正辛醇为适宜的萃取剂。     

β-萘酚稀溶液的络合萃取

利用磷酸三丁酯(TBP)、三烷基胺(7301)为络合剂,分别采用苯、甲苯、正辛醇、煤油作为稀释剂对(-萘酚稀溶液进行络合萃取.实验结果表明,采用磷酸三丁酯-甲苯混合溶剂对( -萘酚稀溶液进行萃取,具有相当高的分配系数.同时考察了有机相中络合剂浓度、β -萘酚溶液初始浓度、溶液pH值以及温度对络合萃取相平衡分配系数的影响,建立了分配系数与稀释剂物理参数间的经验方程.     

EDTA辅助离子液体Aliquat 336萃取废水中Cu(Ⅱ)的研究

研究了络合剂EDTA辅助室温疏水性离子液体Aliquat 336(三辛基甲基氯化铵)对模拟废水中Cu(Ⅱ)的萃取性能。结果表明,当Aliquat 336与水溶液的体积比(VILs∶Vaq)为1∶5,Cu(Ⅱ)初始质量浓度为600 mg/L,pH值为4时,加入等浓度的EDTA可以使水中Cu(Ⅱ)的萃取率从未用EDTA时的5.0%提高到88.7%,说明络合剂EDTA的存在能够显著提高Aliquat 336对模拟废水中Cu(Ⅱ)的萃取率。最优萃取条件为:EDTA与Cu(Ⅱ)的浓度比为1.0,VILs∶Vaq为1∶5,pH值为4,温度为25℃,该条件下废水中Cu(Ⅱ)的去除率达到88.7%。Aliquat 336可多次循环回用,循环回用4次后其萃取率仍可达80%以上。     

三烷基胺萃取氨基磺酸及其废水的特性研究

p-Amino benzene sulfonic acid (PABSA) is selected as the solute with amphoteric functional group, Lewis acid and Lewis base, to be separated from its dilute solutions. An aliphatic, straight chain amine, Alamine 336, is used as the extractant, and kerosene, 1-octanol, chloroform, butyl acetate and benzene as the diluent. The effects of pH value of solution, extractant concentration, salt and types of diluent on the distribution coefficient, D, are studied. There is a peak of D value with pH value of solution, the polar diluents are favorable for extracting PABSA, and the salt in aqueous phase reduces values of D apparently. The extraction equilibrium is described using the mass action law, and the calculated data according to the proposed model agree with the experimental data well. Further, the extraction behavior for other amino benzene sulfonic acids, 1-amino-8-naphtol-3,6-disulfonic acid (H acid) and 4,4′-diaminostilbene-2,2′-disulfonic acid (DSD acid), is investigated in a wide pH value region. Finally. H acid and DSD acid are successfully removed from wastewater by the extraction with Alamine 336.     

二(2-乙基己基)磷酸萃取氨基苯甲酸的相平衡分配系数

络合萃取法分离极性有机物稀溶液具有高效性和高选择性,本文以二（２－乙基已基）磷酸（Ｄ２ＥＨＰＡ）为络合剂;正辛烷或正辛醇为稀释剂,在不同的ＰＨ值条件下实验测定了氨基苯甲酸稀溶液的萃取相分配系数,讨论了影响因素,分析了萃合物的组成。提出了平衡分配系数的关系式。     

Predispersed solvent extraction of negatively complexed copper from water using colloidal liquid aphron containing a quaternary ammonium salt

Negatively complexed copper ion by complexing agent like EDTA (Ethylenediaminetetraacteic acid) was removed by predispered solvent extraction (PDSE) using colloidal liquid aphrons (CLAs) made out of Trioctylmetylammonium chloride (Aliquat 336) diluted with nonpolar kerosene. PDSE was found to have higher mass transfer rate than conventional solvent extraction under experimental conditions without mechanical mixing. The effect of type of water-soluble surfactants, phase volume ratio (PVR), concentration of anionic Sodium Dodecyl Benzene Sulfonate (SDBS) on PDSE was investigated. In addition, the effect of anionic SDBS on back extraction in PDSE was also studied. Under experimental conditions with enough mechanical mixing, the amount of copper transferred to Aliquat 336 core from the pregnant phase was compared in both PDSE by using anionic SDBS and conventional solvent extraction. It is concluded that PDSE using Aliquat 336 CLA can be used for treatment of negatively complexed copper without the influence of surfactant. To optimize CLAs-based process, stability of CLAs containing a quaternary ammonium salt Aliquat 336 diluted with kerosene in the continuous phase was investigated by measuring the volume released to surface. To destabilize CLAs, H⁺, OIL were added. Stability of CLAs was estimated by comparing the half-life obtained. Break-up of destabilization follows pseudo-first-order reaction kinetics at low ionic strength. But, pseudo-first-order model cannot be applied to a region of high ionic strength.     

Purification and Concentration of Xylose and Glucose from Neutralized Bagasse Hydrolysates Using 3,5‐Dimethylphenylboronic Acid and Modified Aliquat 336 as Coextractants

Abstract

Experimental trials of the extraction of xylose, glucose, and fructose from aqueous solutions were conducted using 3,5‐dimethylphenylboronic acid (DMPBA) and modified Aliquat^® 336 (MA) as combined extractants dissolved in Exxal^®10 diluent. MA was produced by contacting an Aliquat 336/Exxal 10 solution with a concentrated caustic soda solution so that the quaternary ammonium ions of Aliquat 336 would ion pair with hydroxide ions. The DMPBA/MA/Exxal 10 organic solution containing equimolar amounts of MA and DMPBA was contacted with a neutral aqueous solution containing one of glucose, xylose, or fructose and the extraction isotherms were determined. The molar ratio of DMPBA:sugar in a fully loaded organic solution was 2:1. The use of the MA instead of Aliquat 336 enabled significant proportions of the sugars to be extracted from aqueous solutions over a wide pH range (～2–11). Loaded organic solutions were stripped using aqueous hydrochloric acid solutions. Complete recovery of the sugar was possible by ensuring sufficient acidity was available in the strip solution. Solutions of MA in Exxal 10 were also found to extract sugar, although to a lesser extent than when DMPBA was included. Extraction of xylose and glucose from solutions derived from the acid hydrolysis of bagasse was performed. By varying the volumetric ratio of strip to organic phases, strip solutions with xylose concentrations up to 4× that of the original hydrolysate were produced while reducing the concentration of the undesirable acid soluble lignin by up to 90%. Hence, this process has the potential to produce high concentration monosaccharide solutions suitable for direct fermentation.     

对氨基酚稀溶液的络合萃取

络合萃取法分离极性有机物稀溶液具有高效性和高选择性。本文在原有工作的基础上，利用三正辛胺、磷酸三丁酯或Ｐ２０４为络合剂，正辛醇或煤油为稀释剂，在不同的ＰＨ值条件下实验测定了对氨基酚稀溶液的萑取相平稳分析系数。