Multiplex TaqMan® detection of pathogenic and multi-drug resistant Salmonella

Overuse of antibiotics in the medical and animal industries is one of the major causes for the development of multi-drug-resistant (MDR) food pathogens that are often difficult to treat. In the past few years, higher incidences of outbreaks caused by MDR Salmonella have been increasingly documented. The objective of this study was to develop a rapid multiplex real-time polymerase chain reaction (PCR) assay for simultaneous detection of pathogenic and MDR Salmonella spp. A multiplex TaqMan®real-time PCR was designed by targeting the invasin virulence gene (invA), and four commonly found antibiotic resistance genes, viz. ampicillin, chloramphenicol, streptomycin and tetracycline. To avoid false negative results and to increase the reliability of the assay, an internal amplification control (IAC) was added which was detected using a locked nucleic acid (LNA) probe. In serially diluted (5 ng–50 fg) DNA samples, the assay was able to detect 100 genomic equivalents of Salmonella, while in a multiplex format, the sensitivity was 1000 genomic equivalents. The assay performed equally well on artificially contaminated samples of beef trim, ground beef of different fat contents (73:27, 80:20, 85:15 and 93:7), chicken rinse, ground chicken, ground turkey, egg, spinach and tomato. While the detection limit for un-enriched inoculated food samples was 10⁴ CFU/g, this was improved to 10 CFU/g after a 12-h enrichment in buffered peptone water, with 100% reproducibility. The multiplex real-time assay developed in this study can be used as a valuable tool to detect MDR virulent Salmonella, thus enhancing the safety of food.     

Development and validation of a rapid real-time PCR based method for the specific detection of Salmonella on fresh meat

In this study, a combined enrichment/real-time PCR method for the rapid detection of Salmonella on fresh meat carcasses, was designed, developed and validated in-house following requirements outlined in ISO 16140:2003. The method included an 18 h non-selective enrichment in buffered peptone water (BPW) and a 6 h selective enrichment in Rappaport Vasilliadis Soya (RVS) broth, based on the traditional culture method, ISO 6579:2002. The real-time PCR assay included an internal amplification control (IAC), was 100% specific and was sensitive to one cell equivalent. The alternative method was validated against the traditional culture method and relative accuracy of 94.9%, sensitivity of 94.7% and specificity of 100% were determined using 150 fresh meat carcass swabs. This alternative method had a detection limit of 1–10 CFU/100 cm² for fresh meat carcass swabs and was performed in 26 h. Following further inter-laboratory studies, this alternative method could be suitable for implementation in testing laboratories for the analysis of carcass swabs.     

Real-time PCR targeting OmpA gene for detection of Cronobacter spp. in powdered infant formula

Cronobacter spp. (formerly Enterobacter sakazakii), a pathogen commonly found in powdered infant formula (PIF), is a rare cause of invasive infection with a high mortality rate in neonates. In the present study, a realtime PCR assay was conducted to identify the pathogens in PIF using a TaqMan probe targeting the outer membrane protein A gene (ompA) of Cronobacter spp. The specificity of the PCR assay was tested against 25 strains of Cronobacter spp. and 38 non-Cronobacter bacterial species. The detection limits of this method are 1.0×10² copy/μL in standard plasmid, 1.1 CFU/100 g in PIF through 38 h of enrichment, and 2.8×10² CFU/mL in phosphate-buffered saline (pH 7.0). Based on the detection limits, real-time PCR is more sensitive than simplex and duplex PCR. These methods were successfully applied to actual samples, indicating that this real-time PCR assay can be used for the detection of Cronobacter spp. in PIF.     

Development of multiplex loop-mediated isothermal amplification-RFLP (mLAMP-RFLP) to detect Salmonella spp. and Shigella spp. in milk

A multiplex loop-mediated isothermal amplification-RFLP (mLAMP-RFLP) was developed and validated for simultaneous detection of Salmonella strains and Shigella strains in milk. In this system, two sets of LAMP primers were designed to specifically target invA of Salmonella spp. and ipaH of Shigella spp. Under isothermal conditions at 63 °C, ladder pattern of DNA bands could be amplified within 60 min in the presence of genomic DNAs of Salmonella strains and Shigella strains, which could be distinguished between Salmonella spp. and Shigella spp. simultaneously based on the different ladder pattern of DNA bands and subsequent restriction enzyme analysis. The overall analysis time was approximately 20 h including the enrichment of the bacterial cells, which greatly saved detection time. The sensitivity of mLAMP was found to be 100 fg DNA/tube with genomic DNAs of Salmonella strains and Shigella strains, comparatively, multiplex PCR was 1 pg DNA/tube. The mLAMP allowed the detection of milk sample artificially contaminated by Salmonella strains and Shigella strains at initial inoculation levels of approximate 5 CFU/10 mL. In conclusion, the mLAMP described here can potentially facilitate simultaneous monitoring of Salmonella and Shigella in a large number of food samples, which could be used as a primary screening method and as a supplement to classical detection method.     

Effect of sample preparation and bacterial concentration on Salmonella enterica detection in poultry meat using culture methods and PCR assaying of preenrichment broths

We evaluated the sensitivity of a PCR assay in the detection of Salmonella enterica at the broth preenrichment step of poultry meat. A total of 162 retail poultry meat samples, which were prepared by manual massaging, stomacher or no homogenization were compared for Salmonella recovery. Using these homogenization methods, the PCR assay at the broth preenrichment step detected Salmonella in, respectively, 48.9%, 62.2% and 50.0% of meat and giblet samples detected as Salmonella-positive using the culture method. In ground chicken, however, Salmonella was detected in 21.7% of samples treated by stomacher homogenization, compared to 40.7% and 48% of untreated and hand-massaged samples, respectively. These results suggest that stomaching of ground chicken causes excessive effusion of food constituents, which affects PCR results. Using the most probable number (MPN) technique, Salmonella was detected at under 1.0 CFU/g in 12 ground chicken samples and under 10³ CFU/ml of broth in seven of the 12 broth-enriched samples, which considered the minimum concentration detectable by PCR assay. These results show that Salmonella detection using routine PCR assays is difficult in poultry meat, and in particular ground chicken, due to low amounts of Salmonella and the presence of inhibitors.     

A multiplex magnetic capture hybridisation and multiplex Real-Time PCR protocol for pathogen detection in seafood

Seafood could become a source of bacterial pathogens by exposure to contaminated water or through processing practices, thus representing a public health hazard. Conventional culture-based analytical methods take several days to be completed, while the molecular rapid identification of bacterial pathogens is crucial for effective disease control. The developed application consist of a multiplex magnetic capture hybridisation (mMCH) assay for the simultaneous isolation of Salmonella spp. and Listeria monocytogenes DNA from seafood, using paramagnetic amino-modified nanoparticles with capture oligonucleotides, and a triplex Real-Time PCR with an Internal Amplification Control (IAC), in accordance with ISO 22174. The detection probability was 100% with 10 genome equivalents of each target species co-amplified in the same reaction. The complete molecular procedure was tested on raw and smoked salmon fillets artificially contaminated with known amounts of one or both target bacteria (1–10³ cfu/g), directly or after culture enrichment, and compared for equivalence with the standard methods. Results revealed a complete agreement between the two approaches, with a sensitivity of 1 cfu/g, in enriched samples, and higher sensitivity (10²–10³ cfu/g) of the molecular method in samples examined before culture enrichment. The proposed procedure was also able to identify a natural contamination by L. monocytogenes in smoked salmon with a considerable shortening of time.     

Two novel analytical methods based on polyclonal and monoclonal antibodies for the rapid detection of Cronobacter spp.: Development and application in powdered infant formula

Cronobacter spp. are opportunistic pathogens, and infections are associated with a high mortality rate. In the current study, monoclonal antibodies (mAbs) and polyclonal antibodies (pAbs) were generated using heat-inactivated C. sakazakii strain ATCC29544 as the immunogen. Following assay optimization, an indirect enzyme-linked immunosorbent assay (ELISA) based on pAbs and a sandwich ELISA based on mAbs and pAbs were established for the detection of Cronobacter spp. The indirect ELISA detected all species of Cronobacter assayed, and the limit of detection (LOD) was established as 10⁵ cfu/mL. In contrast, the sandwich ELISA was specific for C. sakazakii and had greater sensitivity than the indirect ELISA (LOD of 2 × 10⁴ cfu/mL). Following 10 h of enrichment, Cronobacter spp. were detected using either of the two analytical methods in samples inoculated with 1 cfu/100 g powdered infant formula (PIF). The results from this study demonstrated that both of these novel ELISAs were specific, sensitive, and rapid assays for the screening of pathogenic Cronobacter spp. in PIF.     

Direct application of supercritical carbon dioxide for the reduction of Cronobacter spp. (Enterobacter sakazakii) in end products of dehydrated powdered infant formula

The objective of this study was to develop a viable new method for inactivation of Cronobacter spp. that could be applied directly to dehydrated powdered infant formula (PIF) using supercritical carbon dioxide (SC-CO₂). Samples inoculated with Cronobacter spp. were subjected to SC-CO₂ treatment under various conditions (temperature: 63, 68, and 73°C; pressure: 15, 20, and 25 MPa; time: 10, 20, and 30 min). The survival of Cronobacter spp. was assayed, as were any changes in the quality of the treated PIF. Inactivation of Cronobacter spp. by SC-CO₂ was enhanced as temperature and pressure conditions increased (>6.32 log₁₀ cfu/g). In a validation assay using low-level inoculation (3.21 log₁₀ cfu/g), treatment at 73°C and 15 MPa for 30 min, 20 MPa for 20 and 30 min, or 25 MPa for 20 and 30 min reduced Cronobacter spp. to undetectable levels, with no recovery of cell viability. There was no significant change in water activity, pH, and color of the treated PIF. Overall, the optimum conditions for elimination of Cronobacter spp. were determined to be 73°C and 20 MPa for 20 min. These parameters for effective SC-CO₂ treatment are feasibly applicable to end product of dehydrated PIF. The results of our study may contribute to the development of an efficient method for improving the microbiological safety of PIF.     

Detection of Cronobacter species in powdered infant formula by probe-magnetic separation PCR

Cronobacter species are opportunistic foodborne pathogens associated with serious infections in preterm neonates and infants. Based on the epidemiological research, infant formula products are considered to be the main source of infections from this organism. Therefore, accurate methods are required for detection of Cronobacter species. In this study, the specific probe and primers for detection of this organism were designed and verified. The probe-magnetic beads were prepared for sequence capture, followed by PCR assay to detect the target gene. This probe-magnetic separation PCR assay could detect as few as 10³ cfu/mL of Cronobacter in artificially contaminated infant formulas in less than 4 h. The combination of magnetic beads and PCR showed the potential for the detection of Cronobacter in infant formulas and may have applications in the dairy industry.     

Detection of Salmonella in Shellfish Using SYBR Green™ I-Based Real-Time Multiplexed PCR Assay Targeting invA and spvB

A SYBR Green? I-based real-time multiplexed PCR assay was developed targeting invA and spvB for the detection of Salmonella strains in shellfish after both hns and invA genes were identified in all Salmonella strains. Simultaneously, the 16S rRNA gene was used as a PCR internal amplification control (IAC). All 89 Salmonella strains tested in this study exhibited amplification of invA, whereas only 21 (23.6 %) were PCR positive for spvB. The sensitivity of detection of all three targeted genes was 1 ng, which is equivalent to approximately 10⁵ colony-forming unit (CFU) of Salmonella enterica. The analysis showed specific PCR products that were identified by reproducible melt temperature profiles (invA, 84.27?±?1.7 °C; spvB, 88.76?±?1.0 °C; and 16S rRNA gene, 87.16?±?0.8 °C).The sensitivity of detection was 10 pg purified DNA (invA) or 10⁵?CFU in 1 mL pure culture of S. enterica ATCC 14028. The above molecular detection method for Salmonella strains was successfully applied to the oyster homogenates (food matrix). An initial inoculum of 10⁶ and 10²?CFU Salmonella in 1 ml seeded oyster tissue homogenate was detected by multiplexed PCR for all three genes after 5 and 24 h of enrichment, respectively. Natural oysters isolated from Gulf of Mexico during the winter months exhibited negative PCR amplification results suggesting the absence of Salmonella. In contrast to conventional PCR, real-time multiplex PCR assay developed in this study is rapid and sensitive and will help Interstate Shellfish Sanitation Conference undertake appropriate measures to monitor Salmonella in oysters, thereby preventing disease outbreaks and consequently protecting consumer health.     

Rapid detection of Listeria monocytogenes in food using culture enrichment combined with real-time PCR

A rapid method for the detection of Listeria monocytogenes in foods combining culture enrichment and real-time PCR was compared to the ISO 11290-1 standard method. The culture enrichment component of the rapid method is based on the ISO standard and includes 24 h incubation in half-Fraser broth, 4 h incubation in Fraser broth followed by DNA extraction and real-time PCR detection of the ssrA gene of L. monocytogenes. An internal amplification control, which is co-amplified with the same primers as the L. monocytogenes DNA, was also included in the assay. The method has a limit of detection of 1–5 CFU/25 g food sample and can be performed in 2 working days compared to up to 7 days for the ISO standard. A variety of food samples from retail outlets and food processing plants (n = 175) and controls (n = 31) were tested using rapid and conventional methods. The rapid method was 99.44% specific, 96.15% sensitive and 99.03% accurate when compared to the standard method. This method has the potential to be used as an alternative to the standard method for food quality assurance providing rapid detection of L. monocytogenes in food.     

Simultaneous detection of mastitis pathogens, Staphylococcus aureus, Streptococcus uberis, and Streptococcus agalactiae by multiplex real-time polymerase chain reaction

The objective of this study was to develop a multiplex real-time polymerase chain reaction (PCR) method for simultaneous detection of Staphylococcus aureus, Streptococcus agalactiae, and Streptococcus uberis directly from milk. A genetic marker specific for Staph. aureus was used for primers and dual-labeled probe design. The target for Strep. agalactiae primers and dual-labeled probe was selected from the cfb gene encoding the Christie-Atkins-Munch-Petersen factor. The plasminogen activator gene was the target for primers and dual-labeled probe design for Strep. uberis. Quarter milk samples (n = 192) were analyzed by the multiplex real-time PCR assay and conventional microbiological methods. An additional 57 quarter milk samples were analyzed in a separate real-time PCR assay for Strep. agalactiae only. Using an overnight enrichment step, the real-time PCR technique correctly identified 96.4% of all quarter milk samples; 91.7% of Staph. aureus, 98.2% of Strep. agalactiae, and 100% of Strep. uberis. Results of conventional microbiological methods were used to determine the sensitivity and specificity of the multiplex real-time PCR procedure. The sensitivity of the procedure to correctly identify Staph. aureus, Strep. agalactiae, and Strep. uberis directly from milk was 95.5%, and the specificity was 99.6%. Results of this study indicate that the multiplex real-time PCR procedure has the potential to be a valuable diagnostic technique for simultaneous identification of Staph. aureus, Strep. agalactiae, and Strep. uberis directly from quarter milk samples.     

Development and evaluation of DNA and RNA real-time assays for food analysis using the hilA gene of Salmonella enterica subspecies enterica

The objective of this study was the development of DNA and RNA real-time PCR methods for detection of food-borne Salmonella sp. as rapid alternatives to the traditional cultural method (ISO 6579, 2004) in fresh meat carcasses and processed meat samples. These PCR methods were based on the hilA sequence, with primers and hybridisation probes designed against this gene target. The primers and probes were evaluated for their efficiency and dynamic range and subsequently the specificity of the assay was tested using 106 Salmonella enterica subspecies enterica strains and 30 non-salmonellae strains. An internal amplification control (IAC) was also developed for incorporation. The optimum copy number of IAC was determined to be 500 copies per reaction. A complementary enrichment protocol was adapted from the existing standard ISO 6579:2004 and consisted of enrichment in Buffered Peptone Water (BPW) 22 ± 2 h and a second selective enrichment for 6 h in Rappaport Vassiliadis with Soya (RVS). The DNA and RNA-based real-time PCR protocols, were applied to meat samples inoculated with Salmonella enterica subspecies enterica strains, including swabs from meat carcasses and minced beef samples which were heat treated or frozen. The developed methods have the potential as useful alternatives to the standard ISO 6579:2004 method for the detection of Salmonella enterica subspecies enterica on carcass swabs and raw meat using hilA as a target. The DNA assay is a useful tool for the screening of meat samples in the abattoir within 3 days of slaughter or in a food production process and the RNA-based assay has the potential to detect viable Salmonella enterica subspecies enterica in ready-to-eat products.     

Inactivation of Salmonella spp. on tomatoes by plant molecules

The efficacy of carvacrol (CAR), trans-cinnamaldehyde (TC), eugenol (EUG) and β-resorcylic acid (BR) as a wash treatment for reducing Salmonella spp. on tomatoes was investigated. Plum tomatoes inoculated with a six-serotype mixture of Salmonella (10⁸ CFU) were subjected to washing in sterile deionized water (control) or deionized water containing chlorine (100 ppm), CAR (0.25 and 0.75%), TC (0.5 and 0.75%), EUG (0.25 and 0.75%), or BR (0.75 and 1.0%) for 15 sec, 1 min, and 3 min. The plant molecules were more effective (P < 0.05) in reducing Salmonella on tomatoes compared to washing in water and chlorine. Both concentrations of CAR and TC, and 0.75% EUG decreased Salmonella counts on tomatoes by ~ 6.0 log CFU/ml at 1 min. Both concentrations of BR decreased the pathogen on tomatoes to undetectable levels at 3 min of exposure. Washing of tomatoes in deionized water and chlorine for 3 min reduced Salmonella by ca. 2.0 and 4.0 log CFU/ml, respectively. No Salmonella was detected in the wash water containing the plant molecules or chlorine, whereas a substantial population of the pathogen survived in the control wash water. Moreover, none of the dipping treatments had any effect on the red color of tomatoes (P > 0.05). Results indicate that CAR, TC, EUG and BR could effectively be used to kill Salmonella on tomatoes, but additional studies on sensory and quality characteristics of tomatoes treated with plant molecules are warranted.     

Survival of Salmonella Newport in oysters

Salmonella enterica is the leading cause of laboratory-confirmed foodborne illness in the United States and raw shellfish consumption is a commonly implicated source of gastrointestinal pathogens. A 2005 epidemiological study done in our laboratory by Brands et al., showed that oysters in the United States are contaminated with Salmonella, and in particular, a specific strain of the Newport serovar. This work sought to further investigate the host-microbe interactions between Salmonella Newport and oysters. A procedure was developed to reliably and repeatedly expose oysters to enteric bacteria and quantify the subsequent levels of bacterial survival. The results show that 10 days after an exposure to Salmonella Newport, an average concentration of 3.7 × 10³ CFU/g remains within the oyster meat, and even after 60 days there still can be more than 10² CFU/g remaining. However, the strain of Newport that predominated in the market survey done by Brands et al. does not survive within oysters or the estuarine environment better than any other strains of Salmonella we tested. Using this same methodology, we compared Salmonella Newport's ability to survive within oysters to a non-pathogenic strain of E. coli and found that after 10 days the concentration of Salmonella was 200-times greater than that of E. coli. We also compared those same strains of Salmonella and E. coli in a depuration process to determine if a constant 120 L/h flux of clean seawater could significantly reduce the concentration of bacteria within oysters and found that after 3 days the oysters retained over 10⁴ CFU/g of Salmonella while the oysters exposed to the non-pathogenic strain of E. coli contained 100-times less bacteria. Overall, the results of this study demonstrate that any of the clinically relevant serovars of Salmonella can survive within oysters for significant periods of time after just one exposure event. Based on the drastic differences in survivability between Salmonella and a non-pathogenic relative, the results of this study also suggest that unidentified virulence factors may play a role in Salmonella's interactions with oysters.     

Rapid detection of Salmonella in milk by combined immunomagnetic separation-polymerase chain reaction assay

During the past few years, milk has presented a risk of Salmonella contamination; it has been implicated as the cause in several outbreaks of salmonellosis. Because conventional detection methods require 5 to 7 d for completion and involve several subcultivation stages followed by biochemical and serological tests, rapid and sensitive methods have been sought, mainly at the DNA level. Therefore, a study including milk samples was conducted to evaluate the performance of a combination of 2 techniques—immunomagnetic separation and polymerase chain reaction (PCR)—for the detection of Salmonella. The 16-, 14-, 12-, 10-, and 8-h nonselective pre-enrichment steps before immunomagnetic separation and the high-pure DNA preparation method before PCR were used in a combined assay. Milk samples, which were found to be Salmonella-negative by a reference method, were first inoculated with Salmonella Enteritidis. Next, the shortest pre-enrichment time that is required for detection of 1 or 10 cfu of Salmonella/mL by combined immunomagnetic separation-PCR assay was found by using 16-, 14-, 12-, 10-, and 8-h incubation periods. The detection limit using a 16-, 14-, or 12-h nonselective pre-enrichment was 1 to 10 cfu/mL. However, the sensitivity decreased to 10¹ and 10² cfu/mL, respectively, when 10- and 8-h pre-enrichments were used. This assay, in conjunction with a 12-h pre-enrichment, proved to be rapid (overall 16 h) and sensitive (1-10 cfu/mL) for the detection of Salmonella in milk samples and promising for routine use in the detection of Salmonella in milk.     

Multiple-locus variable number of tandem repeat analysis (MLVA) of Listeria monocytogenes directly in food samples

Listeria monocytogenes is the etiologic agent of listeriosis responsible for severe and fatal infections in humans. Listeria contamination occurs quite often in a wide range of foods due to its ubiquitous nature. Isolates need to be characterized to a strain level for accurate diagnosis of Listeria infection, epidemiological studies, investigation of outbreaks and effective prevention and control of food-borne listeriosis. The purpose of this research was to evaluate the multiple-locus variable number of tandem repeat analysis (MLVA) for sub-typing L. monocytogenes isolates in pure cultures and in food matrices. Two multiplex PCR assays were formulated to amplify six specific loci using fluorescently-labeled primers; and the amplicons were analyzed by capillary electrophoresis. The MLVA method resulted in 34 unique DNA fingerprint patterns from 46 L. monocytogenes isolates of 10 serotypes which had 29 or 30 PFGE patterns with a single restriction enzyme and 34 AFLP patterns. The MLVA patterns of the 46 isolates remained unchanged in the presence of pre-enriched food matrices including sausage, ham, chicken, milk and lettuce. The MLVA method successfully typed L. monocytogenes strains spiked in cheese, roast beef, egg salad and vegetable samples after 48 h enrichment at the initial inoculation levels of 1-5 CFU per 25 g of food or higher. The limits of detection (typing) of the MLVA method were 10³-10⁴ CFU/mL of pre-enriched food broth when evaluated using post-spiked sausage, ham, chicken, milk and lettuce samples. The MLVA method was simple, highly discriminatory, and easy to perform with portable (numerical) results. To our knowledge, this is the first report that describes the application of the MLVA method directly to food samples and demonstrates the possibility to obtain rapid and accurate subtyping results before an isolate is obtained.     

Spoilage characteristics of Brochothrix thermosphacta and campestris in chilled vacuum packaged lamb,and their detection and identification by real time PCR

The spoilage potential of Brochothrix campestris and Brochothrix thermosphacta was investigated in vacuum-packed lamb. Striploins (n = 338) were inoculated and stored for twelve weeks at temperatures − 1.5, 0, 2 and 7 °C. Growth around 5–6 log₁₀ CFU/cm² was recorded after six weeks at 0, 2 and 7 °C, and ~ 3 log₁₀ CFU/cm² after nine weeks at − 1.5 °C. B. campestris was shown to cause spoilage by nine weeks at temperatures above 0 °C by the presence of green drip and unacceptable odours. Molecular based assays for the detection and differentiation of B. thermosphacta and B. campestris were developed and validated. A TaqMan assay was designed to target a unique single-nucleotide polymorphism in the Brochothrix 16 s rRNA gene with a sensitivity of < 7 CFU per reaction. Secondly a specific PCR was designed for B. campestris targeting the structural genes, brcA and brcB. These testing regimes offer a rapid and cost effective method for the detection and screening of Brochothrix species in meat products and processing environments.     

Actual distribution of Cronobacter spp. in industrial batches of powdered infant formula and consequences for performance of sampling strategies

The actual spatial distribution of microorganisms within a batch of food influences the results of sampling for microbiological testing when this distribution is non-homogeneous. In the case of pathogens being non-homogeneously distributed, it markedly influences public health risk. This study investigated the spatial distribution of Cronobacter spp. in powdered infant formula (PIF) on industrial batch-scale for both a recalled batch as well a reference batch. Additionally, local spatial occurrence of clusters of Cronobacter cells was assessed, as well as the performance of typical sampling strategies to determine the presence of the microorganisms. The concentration of Cronobacter spp. was assessed in the course of the filling time of each batch, by taking samples of 333 g using the most probable number (MPN) enrichment technique. The occurrence of clusters of Cronobacter spp. cells was investigated by plate counting.From the recalled batch, 415 MPN samples were drawn. The expected heterogeneous distribution of Cronobacter spp. could be quantified from these samples, which showed no detectable level (detection limit of −2.52 log CFU/g) in 58% of samples, whilst in the remainder concentrations were found to be between −2.52 and 2.75 log CFU/g. The estimated average concentration in the recalled batch was −2.78 log CFU/g and a standard deviation of 1.10 log CFU/g. The estimated average concentration in the reference batch was −4.41 log CFU/g, with 99% of the 93 samples being below the detection limit. In the recalled batch, clusters of cells occurred sporadically in 8 out of 2290 samples of 1 g taken. The two largest clusters contained 123 (2.09 log CFU/g) and 560 (2.75 log CFU/g) cells. Various sampling strategies were evaluated for the recalled batch. Taking more and smaller samples and keeping the total sampling weight constant, considerably improved the performance of the sampling plans to detect such a type of contaminated batch. Compared to random sampling, stratified random sampling improved the probability to detect the heterogeneous contamination.     

Isolation and molecular identification of Cronobacter spp. from powdered infant formula (PIF) in Bangladesh

Cronobacter spp. formerly known as Enterobacter sakazakii is an occasional contaminant of powdered infant formula (PIF). This pathogen has been associated with out-breaks of a rare form of infant meningitis, necrotizing enterocolitis (NEC), bacteremia and neonate deaths. The organism is ranked by the International Commission for Microbiological Specifications for Foods (ICMSF) as a ‘Severe hazard for restricted populations, life threatening or substantial chronic sequelae or long duration’. Present study aimed to isolate Cronobacter spp. from PIF and clinical samples, such as blood, stool and CSF collected from 93 neonates and child patients, age ranged from 0 to 24 months. We did not detect Cronobacter spp. in any of these samples. Later 32 PIF samples collected from retail markets in Bangladesh were tested for the presence of Cronobacter spp. Of these only one was found to be contaminated with Cronobacter sp. This is the first case of Cronobacter contaminated PIF found in Bangladesh to be reported. The organism was successfully identified based on its typical culture characteristics, producing blue-green colonies on chromogenic DFI agar and also by a standardized conventional PCR assay targeting the alpha glucosidase and 16 S rRNA gene sequence of Cronobacter sp. The 16 S rRNA gene was partially sequenced to provide for the phylogenetic analysis of this isolate (DA01) and found to cluster with some other Cronobacter isolates in the phylogram.