Survival of Escherichia coli O157:H7 and Salmonella in apple cider and orange juice as affected by ozone and treatment temperature

Inactivation of Escherichia coli O157:H7 and Salmonella in apple cider and orange juice treated with ozone was evaluated. A five-strain mixture of E. coli O157:H7 or a five-serovar mixture of Salmonella was inoculated (7 log CFU/ml) into apple cider and orange juice. Ozone (0.9 g/h) was pumped into juices maintained at 4 degrees C, ambient temperature (approximately 20 degrees C), and 50 degrees C for up to 240 min, depending on organism, juice, and treatment temperature. Samples were withdrawn, diluted in 0.1% peptone water, and surface plated onto recovery media. Recovery of E. coli O157:H7 was compared on tryptic soy agar (TSA), sorbitol MacConkey agar, hemorrhagic coli agar, and modified eosin methylene blue agar; recovery of Salmonella was compared on TSA, bismuth sulfite agar, and xylose lysine tergitol 4 (XLT4) agar. After treatment at 50 degrees C, E. coli O157:H7 populations were undetectable (limit of 1.0 log CFU/ml; a minimum 6.0-log CFU/ml reduction) after 45 min in apple cider and 75 min in orange juice. At 50 degrees C, Salmonella was reduced by 4.8 log CFU/ml (apple cider) and was undetectable in orange juice after 15 min. E. coli O157:H7 at 4 degrees C was reduced by 4.8 log CFU/ml in apple cider and by 5.4 log CFU/ml in orange juice. Salmonella was reduced by 4.5 log CFU/ml (apple cider) and 4.2 log CFU/ml (orange juice) at 4 degrees C. Treatment at ambient temperature resulted in population reductions of less than 5.0 log CFU/ml. Recovery of E. coli O157:H7 and Salmonella on selective media was substantially lower than recovery on TSA, indicating development of sublethal injury. Ozone treatment of apple cider and orange juice at 4 degrees C or in combination with mild heating (50 degrees C) may provide an alternative to thermal pasteurization for reduction of E. coli O157:H7 and Salmonella in apple cider and orange juice.     

Modified immunoliposome sandwich assay for the detection of Escherichia coli O157:H7 in apple cider

Detection of Escherichia coli O157:H7 in fruit juices such as apple cider is necessary for diagnosis of infection and epidemiological investigations. However, inhibitors in the apple cider, such as endogenous polyphenols and acids, often decrease the sensitivity of PCR assays and immunoassays, thus routinely requiring laborious cell separation steps to increase the sensitivity. In the current study, polyethylene glycol (PEG)-derivatized liposomes encapsulating sulforhodamine B were tagged with anti-E. coli O157:H7 antibodies and used in an immunoliposome sandwich assay for the detection of E. coli O157:H7 in apple cider. Even without prior separation, this assay can detect E. coli O157:H7 in apple cider samples inoculated with as few as 1 CFU/ml after an 8-h enrichment period. The lower limit of detection in pure cultures without enrichment was 7 x 10(3) CFU/ml (280 CFU/40-microl sample). PEGylated immunoliposomes are suitable as an analytical reagent for the detection of E. coli O157:H7 in fruit juices containing polyphenols.     

The survival of Escherichia coli O157:H7 in the presence of Penicillium expansum and Glomerella cingulata in wounds on apple surfaces

The survival of Escherichia coli O157:H7 in the presence of one of two plant pathogens, Penicillium expansum and Glomerella cingulata, in wounds on apples was observed during 14 days storage at room temperature (RT) and at 4 degrees C. The aim of this work was to determine if changes in apple physiology caused by the proliferation of fungal decay organisms would foster the survival of E. coli O157:H7. Trials were performed where (A) plant pathogens (4 log10 spores) were added to apple wounds 4 days before the wounds were inoculated with E. coli O157:H7 (3 log10 CFU g(-1) apple) (both RT and 4 degrees C storage), (B) plant pathogens and E. coli O157:H7 were added on the same day (both RT and 4 degrees C storage), and (C) E. coli O157:H7 was added 2 days (RT storage) and 4 days (4 degrees C storage) before plant pathogens. In all trials E. coli O157:H7 levels generally declined to <1 log10 at 4 degrees C storage, and in the presence of P. expansum at 4 degrees C or RT. However, in the presence of G. cingulata at RT E. coli O157:H7 numbers increased from 3.18 to 4.03 log10 CFU g(-1) in the apple wound during trial A, from 3.26 to 6.31 log10 CFU g(-1) during trial B, and from 3.22 to 6.81 log10 CFU g(-1) during trial C. This effect is probably a consequence of the attendant rise in pH from 4.1 to approximately 6.8, observed with the proliferation of G. cingulata rot. Control apples (inoculated with E. coli O157:H7 only) were contaminated with opportunistic decay organisms at RT during trials A and B, leading to E. coli O157:H7 death. However, E. coli O157:H7 in control apples in trial C, where no contamination occurred, increased from 3.22 to 5.97 log10 CFU g(-1). The fact that E. coli O157:H7 can proliferate in areas of decay and/or injury on fruit highlights the hazards associated with the use of such fruit in the production of unpasteurized juice.     

Reduction of microbial pathogens during apple cider production using sodium hypochlorite, copper ion, and sonication

Sodium hypochlorite (100 ppm), copper ion water (1 ppm), and sonication (22 to 44 kHz and 44 to 48 kHz) were assessed individually and in combination for their ability to reduce populations of Escherichia coli O157:H7 and Listeria monocytogenes on apples and in apple cider. Commercial unpasteurized cider was inoculated to contain approximately 10(6) CFU/ml of either pathogen and then sonicated at 44 to 48 kHz, with aliquots removed at intervals of 30 to 60 s for up to 5 min and plated to determine numbers of survivors. Subsequently, whole apples were inoculated by dipping to contain approximately 10(6) CFU/g E. coli O157:H7 or L. monocytogenes, held overnight, and then submerged in 1 ppm copper ion water with or without 100 ppm sodium hypochlorite for 3 min with or without sonication at 22 to 44 kHz and examined for survivors. Treated apples were also juiced, with the resulting cider sonicated for 3 min. Populations of both pathogens decreased 1 to 2 log CFU/ml in inoculated cider following 3 min of sonication. Copper ion water alone did not significantly reduce populations of either pathogen on inoculated apples. However, when used in combination with sodium hypochlorite, pathogen levels decreased approximately 2.3 log CFU/g on apples. Sonication of this copper ion-sodium hypochlorite solution at 22 to 44 kHz did not further improve pathogen reduction on apples. Numbers of either pathogen in the juice fraction were approximately 1.2 log CFU/ml lower after being juiced, with sonication (44 to 48 kHz) of the expressed juice decreasing L. monocytogenes and E. coli O157:H7 populations an additional 2 log. Hence, a 5-log reduction was achievable for both pathogens with the use of copper ion water in combination with sodium hypochlorite followed by juicing and sonication at 44 to 48 kHz.     

Survival differences of Escherichia coli O157:H7 strains in apples of three varieties stored at various temperatures

Differences in survival and growth among five different Escherichia coli O157:H7 strains in three apple varieties were determined at various temperatures. Jonathan, Golden Delicious, and Red Delicious apples were wounded and inoculated with E coli O157:H7 strains C7929 (apple cider isolate), 301C (chicken isolate), 204P (pork isolate), 933 (beef isolate), and 43890 (human isolate) at an initial level of 6 to 7 log CFU/g. The inoculated apples were stored at a constant temperature of 37, 25, 8, or 4 degrees C or at 37 degrees C for 24 h and then at 4 degrees C, and bacterial counts were determined every week for 28 days. By day 28, for Jonathan apples at 25 degrees C, the apple isolate counts were significantly higher than the chicken and human isolate counts. At 4 degrees C for 28 days, the human isolate inoculated into Jonathan, Golden Delicious, and Red Delicious apples was present in significantly smaller numbers than the other strains. The apple isolate survived significantly better at 4 degrees C, yielding the highest number of viable cells. By days 21 and 28, for apples stored at 37 degrees C for the first 24 h and then at 4 degrees C, the counts of viable E. coli O157:H7 apple and human isolates were 6.8 and 5.8 log CFU/g at the site of the wound, whereas for apples kept at 4 degrees C for the duration of storage, the respective counts were 5.6 and 1.5 log CFU/g. Our study shows that E. coli O157:H7 strains responded differentially to their ability to survive in these three apple varieties at 25 or 4 degrees C and produced higher viable counts when apples were temperature abused at 37 degrees C for 24 h and then stored at 4 degrees C for 27 days.     

Modeling the survival of Escherichia coli O157:H7 in apple cider using probability distribution functions for quantitative risk assessment

Outbreaks of foodborne illness from apple cider have prompted research on the survival of Escherichia coli O157:H7 in this food. Published results vary widely, potentially due to differences in E. coli O157:H7 strains, enumeration media, and other experimental considerations. We developed probability distribution functions for the change in concentration of E. coli O157:H7 (log CFU/day) in cider using data from scientific publications for use in a quantitative risk assessment. Six storage conditions (refrigeration [4 to 5 degrees C]; temperature abuse [6 to 10 degrees C]; room temperature [20 to 25 degrees C]; refrigerated with 0.1% sodium benzoate, 0.1% potassium sorbate, or both) were modeled. E. coli survival rate data for all three unpreserved cider storage conditions were highly peaked, and these data were fit to logistic distributions: ideal refrigeration, logistic (-0.061, 0.13); temperature abuse, logistic (-0.0982, 0.23); room temperature, logistic (-0.1, 0.29) and uniform (-4.3, -1.8), to model the very small chance of extremely high log CFU reductions. There were fewer published studies on refrigerated, preserved cider, and these smaller data sets were modeled with beta (4.27, 2.37) x 2.2 - 1.6, normal (-0.2, 0.13), and gamma (1.45, 0.6) distributions, respectively. Simulations were run to show the effect of storage on E. coli O157:H7 during the shelf life of apple cider. Under every storage condition, with and without preservatives, there was an overall decline in E. coli O157:H7 populations in cider, although a small fraction of the time a slight increase was seen.     

Verifying apple cider plant sanitation and hazard analysis critical control point programs: choice of indicator bacteria and testing methods.

The objectives of this study were (i) to evaluate the survival of coliforms, Escherichia coli, and enterococci in refrigerated apple cider; (ii) to develop simple and inexpensive presumptive methods for detection of these bacteria; (iii) to perform a field survey to determine the prevalence of these bacteria on apples and in apple cider; and (iv) based on our results, to recommend the most useful of these three indicator groups for use in verifying apple cider processing plant sanitation and hazard analysis critical control point (HACCP) programs. Eight of 10 coliform strains (5 E. coli, 1 Enterobacter aerogenes, and 2 Klebsiella spp.) inoculated into preservative-free apple cider (pH 3.4, 13.3(o) Brix) survived well at 4 degrees C for 6 days (< or = 3.0 log10 CFU/ml decrease). Of 21 enterococci strains (Enterococcus faecalis, E. faecium, and E. durans), only 2 E. durans and 3 E. faecium strains survived well. Simple broth-based colorimetric methods were developed that detected the presence of approximately 10 cells of coliforms or enterococci. In three field studies, samples of unwashed apples (drops and picked), washed apples, and freshly pressed cider were presumptively analyzed for total coliforms, E. coli, and enterococci using qualitative and/or quantitative methods. Drop apples were more likely than picked apples to be contaminated with E. coli (26.7% vs. 0%) and enterococci (20% vs. 0%). Washing had little effect on coliform populations and in one field study was associated with increased numbers. Total coliform populations in cider ranged from < 1 CFU/ml to > 738 most probable number/ml, depending on the enumeration method used and the sample origin. E. coli was not recovered from washed apples or cider, but enterococci were present on 13% of washed apple samples. The qualitative coliform method successfully detected these bacteria on apples and in cider. Based on its exclusively fecal origin, good survival in apple cider, and association with drop apples, we conclude that E. coli is the most useful organism for verifying apple cider sanitation and HACCP programs.     

Inactivation of Escherichia coli O157:H7 and other naturally occurring microorganisms in apple cider by electron beam irradiation

Two Escherichia coli O157:H7 strains, SEA 13 B88 gfp 73ec and B6-914 gfp 90ec, together with two bacteria, three yeasts, and two molds that were randomly selected from a collection of microorganisms found on apples or in apple cider, were inoculated into apple cider and subjected to electron beam irradiation at several doses between 0.0 and 2.3 kGy at the Iowa State University Linear Accelerator Facility. The D-values for the E. coli O157:H7 strains ranged between 0.25 and 0.34 kGy; the D-values for most of the normal flora from apples ranged between 0.24 and 0.59 kGy. By taking into account possible variations in treatment conditions, it was calculated that irradiation at 2.47 kGy should achieve a 5-log reduction of E. coli O157:H7 in apple cider at the 95% confidence level. Naturally occurring yeasts might survive such irradiation treatment.     

Heat treatments to enhance the safety of mung bean seeds

Salmonella enterica serovars and Escherichia coli O157:H7 have been associated with contaminated seed sprout outbreaks. The majority of these outbreaks have been traced to sprout seeds contaminated with low levels of pathogens. E. coli O157:H7 strains can grow an average of 2.3 log CFU/g over 2 days during seed germination, and Salmonella can achieve an average growth of 3.7 log CFU/g. Therefore, it is important to find an effective method to reduce possible pathogenic bacterial populations on the seeds prior to sprouting. Our objective was to assess the effectiveness of various dry heat treatments on reducing E. coli O157:H7 and Salmonella populations on mung beans intended for sprout production and to determine the effect of these treatments on seed germination. Mung beans were inoculated with five-strain cocktails of E. coli O157:H7 and of Salmonella serovars harboring the green fluorescent protein gene and then air dried overnight. Heat treatments were performed by incubating the seeds at 55 degrees C for various periods of time. Heat-treated seeds were then assessed for the efficacy of the heat treatment and the effects of heat treatment on germination rates. After inoculation and drying, 6 log CFU/g E. coli O157:H7 and 4 log CFU/g Salmonella were detected on the seeds. Following heat treatment, pathogenic bacterial populations on the seeds were below detectable levels (<1 log CFU/g), but the germination rate of the seed was not affected. Thus, the risk of contamination and the presence of pathogens in the finished sprouts were greatly reduced via the seed heat treatment process.     

Comparative survival of Salmonella typhimurium DT 104, Listeria monocytogenes, and Escherichia coli O157:H7 in preservative-free apple cider and simulated gastric fluid

This study compared the survival of three-strain mixtures (ca. 10(7) CFU ml(-1) each) of Salmonella typhimurium DT104, Listeria monocytogenes, and Escherichia coli O157:H7 in pasteurized and unpasteurized preservative-free apple cider (pH 3.3-3.5) during storage at 4 and 10 degrees C for up to 21 days. S. typhimurium DT104 populations decreased by <4.5 log10 CFU ml(-1) during 14 days storage at 4 and 10 degrees C in pasteurized cider, and by > or =5.5 log10 CFU ml(-1) during 14 days in unpasteurized cider stored at these temperatures. However, after 7 days at 4 degrees C, the S. typhimurium DT104 populations had decreased by only about 2.5 log10 CFU ml(-1) in both pasteurized and unpasteurized cider. Listeria monocytogenes populations decreased below the plating detection limit (10 CFU ml(-1)) within 2 days under all conditions tested. Survival of E. coli O157:H7 was similar to that of S. typhimurium DT104 in pasteurized cider at both 4 and 10 degrees C over the 21-days storage period, but E. coli O157:H7 survived better (ca. 5.0 log10 CFU ml(-1) decrease) than S. typhimurium DT104 (> 7.0 log10 CFU ml(-1) decrease) after 14 days at 4 degrees C in unpasteurized cider. In related experiments, when incubated in simulated gastric fluid (pH 1.5) at 37 degrees C, S. typhimurium DT104 and L. monocytogenes were eliminated (5.5-6.0 log10 CFU ml(-1) decrease) within 5 and 30 min, respectively, whereas E. coli O157:H7 concentrations decreased only 1.60-2.80 log10 CFU ml(-1) within 2 h.     

Microbial levels in Michigan apple cider and their association with manufacturing practices

In recent decades, apple cider has been implicated in a series of outbreaks of foodborne illness. The objective of this study was to determine the presence and concentrations of pathogenic and indicator microorganisms in apple cider processed in Michigan and to evaluate the impact of thermal pasteurization, UV light radiation, and implementation of hazard analysis critical control point (HACCP) plans on these microbes. Cider samples were obtained from Michigan mills between 1997 and 2004 and analyzed for Escherichia coli O157:H7, Salmonella, generic E. coli, total coliforms, and aerobic bacteria. Neither E. coli O157:H7 nor Salmonella were detected in any tested cider samples, suggesting a very low frequency of pathogens in Michigan apple cider. The persistent and relatively high frequency of generic E. coli observed in samples obtained in all years indicates a continued risk of pathogen contamination in Michigan apple cider, especially when it is untreated. The use of thermal pasteurization or UV light radiation and reported implementation of HACCP plans were associated with lower frequency and counts of generic E. coli, total coliforms, and aerobic microorganisms. However, the relatively high counts of indicator organisms in some cider samples that were claimed to be treated according to these pathogen reduction measures indicates that some processors had inadequate practices, facilities, or equipment for pathogen reduction or did not consistently or adequately apply practices or pathogen-reduction equipment in an effective manner.     

High-pressure resistance variation of Escherichia coli O157:H7 strains and Salmonella serovars in tryptic soy broth, distilled water, and fruit juice

The effect of high pressure on the log reduction of six strains of Escherichia coli O157:H7 and five serovars of Salmonella enterica was investigated in tryptic soy broth, sterile distilled water, and commercially sterile orange juice (for Salmonella) and apple cider (for E. coli). Samples were subjected to high-pressure processing treatment at 300 and 550 MPa for 2 min at 6 degrees C. Samples were plated onto tryptic soy agar directly after pressurization and after being held for 24 h at 4 degrees C. At 300 MPa, little effect was seen on E. coli O157:H7 strains, while Salmonella serovars varied in resistance, showing reductions between 0.26 and 3.95 log CFU/ml. At 550 MPa, E. coli O157:H7 strains exhibited a range of reductions (0.28 to 4.39 log CFU/ml), while most Salmonella populations decreased beyond the detection limit (> 5-log CFU/ml reduction). The most resistant strains tested were E. coli E009 and Salmonella Agona. Generally, bacterial populations in fruit juices showed larger decreases than did populations in tryptic soy broth and distilled water. E. coli O157:H7 cultures held for 24 h at 4 degrees C after treatment at 550 MPa showed a significant log decrease as compared with cultures directly after treatment (P < or = 0.05), while Salmonella serovars did not show this significant decrease (P > 0.05). All Salmonella serovars tested in orange juice treated at 550 MPa for 2 min at 6 degrees C and held for 24 h showed a > 5-log decrease, while E. coli O157:H7 strains require a higher pressure, higher temperature, longer pressurization, or a chemical additive to achieve a 5-log decrease.     

Location of Escherichia coli O157:H7 on and in apples as affected by bruising, washing, and rubbing

Confocal scanning laser microscopy (CSLM) was used to determine the location of Escherichia coli O157:H7 cells on the surface and in tissue of bruised Red Delicious cv. apples. Undamaged and bruised apples were inoculated by immersing in a suspension of E. coli O157:H7 cells transformed with a plasmid that encodes for the production of a green fluorescent protein. Apples were then washed in 0.1% (wt/vol) peptone water and/or rubbed with a polyester cloth and examined to determine if these treatments removed or introduced cells into lenticels, cutin, and cracks on the skin surface. Optical slices of the apples obtained using CSLM were examined to determine the depth at which colonization or attachment of cells occurred. Populations of E. coli O157:H7 on the surface of apples were determined to assess the effectiveness of washing and rubbing in physically removing cells. The location of cells on or in undamaged and bruised areas of apples that were not washed or rubbed did not differ significantly. However, washing apples resulted in an approximate 2-log reduction in CFU of E. coli O157:H7 per cm2 of apple surface. On unwashed apples, cells were detected at depths up to 30 microm below the surface. No E. coli O157:H7 cells were detected at locations more than 6 microm below the surface of washed apples. Cells that remained on the surface of rubbed apples appeared to be sealed within naturally occurring cracks and crevices in waxy cutin platelets. These cells may be protected from disinfection and subsequently released when apples are eaten or pressed for cider production.     

Reduction in levels of Escherichia coli O157:H7 in apple cider by pulsed electric fields.

Many studies have demonstrated that high voltage pulsed electric field (PEF) treatment has lethal effects on microorganisms including Escherichia coli O157:H7; however, the survival of this pathogen through the PEF treatment is not fully understood. Fresh apple cider samples inoculated with E. coli O157:H7 strain EC920026 were treated with 10, 20, and 30 instant charge reversal pulses at electric field strengths of 60, 70, and 80 kV/cm, at 20, 30, and 42 degrees C. To accurately evaluate the lethality of apple cider processing steps, counts were determined on tryptic soy agar (TSA) and sorbitol MacConkey agar (SMA) to estimate the number of injured and uninjured E. coli O157:H7 cells after PEF treatment. Cell death increased significantly with increased temperatures and electric field strengths. A maximum of 5.35-log10 CFU/ml (P < 0.05) reduction in cell population was achieved in samples treated with 30 pulses and 80 kV/cm at 42 degrees C. Cell injury measured by the difference between TSA and SMA counts was found to be insignificant (P > 0.05). Under extreme conditions, a 5.91-log10 CFU/ml reduction in cell population was accomplished when treating samples with 10 pulses and 90 kV/cm at 42 degrees C. PEF treatment, when combined with the addition of cinnamon or nisin, triggered cell death, resulting in a reduction in E. coli O157:H7 count of 6 to 8 log10 CFU/ml. Overall, the combination of PEF and heat treatment was demonstrated to be an effective pasteurization technique by sufficiently reducing the number of viable E. coli O157:H7 cells in fresh apple cider to meet U.S. Federal Drug Administration recommendations.     

Use of hazard analysis critical control point and alternative treatments in the production of apple cider.

The purpose of this study was to evaluate the practices of Maryland cider producers and determine whether implementing hazard analysis critical control point (HACCP) would reduce the microbial contamination of cider. Cider producers (n = 11) were surveyed to determine existing manufacturing practices and sanitation. A training program was then conducted to inform operators of safety issues, including contamination with Escherichia coli O157:H7, and teach HACCP concepts and principles, sanitation procedures, and good manufacturing practice (GMP). Although all operators used a control strategy from one of the model HACCP plans provided, only one developed a written HACCP plan. None developed specific GMP, sanitation standard operating procedures, or sanitation monitoring records. Six operators changed or added production controls, including the exclusion of windfall apples, sanitizing apples chemically and by hot dip, and cider treatment with UV light or pasteurization. Facility inspections indicated improved sanitation and hazard control but identified ongoing problems. Microbiological evaluation of bottled cider before and after training, in-line apples, pomace, cider, and inoculated apples was conducted. E. coli O157:H7, Salmonella, or Staphylococcus aureus were not found in samples of in-line apple, pomace, and cider, or bottled cider. Generic E. coli was not isolated on in-coming apples but was found in 4 of 32 (13%) in-line samples and 3 of 17 (18%) bottled fresh cider samples, suggesting that E. coli was introduced during in-plant processing. To produce pathogen-free cider, operators must strictly conform to GMP and sanitation procedures in addition to HACCP controls. Controls aimed at preventing or eliminating pathogens on source apples are critical but alone may not be sufficient for product safety.     

Quantitative assessment of the microbial risk of leafy greens from farm to consumption: preliminary framework, data, and risk estimates

This project was undertaken to relate what is known about the behavior of Escherichia coli O157:H7 under laboratory conditions and integrate this information to what is known regarding the 2006 E. coli O157:H7 spinach outbreak in the context of a quantitative microbial risk assessment. The risk model explicitly assumes that all contamination arises from exposure in the field. Extracted data, models, and user inputs were entered into an Excel spreadsheet, and the modeling software @RISK was used to perform Monte Carlo simulations. The model predicts that cut leafy greens that are temperature abused will support the growth of E. coli O157:H7, and populations of the organism may increase by as much a 1 log CFU/day under optimal temperature conditions. When the risk model used a starting level of -1 log CFU/g, with 0.1% of incoming servings contaminated, the predicted numbers of cells per serving were within the range of best available estimates of pathogen levels during the outbreak. The model predicts that levels in the field of -1 log CFU/g and 0.1% prevalence could have resulted in an outbreak approximately the size of the 2006 E. coli O157:H7 outbreak. This quantitative microbial risk assessment model represents a preliminary framework that identifies available data and provides initial risk estimates for pathogenic E. coli in leafy greens. Data gaps include retail storage times, correlations between storage time and temperature, determining the importance of E. coli O157:H7 in leafy greens lag time models, and validation of the importance of cross-contamination during the washing process.     

Efficacy of ultraviolet light for reducing Escherichia coli O157:H7 in unpasteurized apple cider

This study examined the efficacy of UV light for reducing Escherichia coli O157:H7 in unpasteurized cider. Cider containing a mixture of acid-resistant E. coli O157:H7 (6.3 log CFU/ml) was treated using a thin-film UV disinfection unit at 254 nm. Dosages ranged from 9,402 to 61,005 microW-s/cm2. Treatment significantly reduced E. coli O157:H7 (P < or = 0.0001). Mean reduction for all treated samples was 3.81 log CFU/ml. Reduction was also affected by the level of background microflora in cider. Results indicate that UV light is effective for reducing this pathogen in cider. However, with the dosages used in this experiment, additional reduction measures are necessary to achieve the required 5-log reduction.     

Isolation and characterization of Escherichia coli recovered from Maryland apple cider and the cider production environment

Contaminated apple cider has been implicated in several Escherichia coli O157:H7 outbreaks. In an attempt to investigate sources and modes of entry of E. coli into apple cider, samples of fresh apple, pomace, and cider and equipment and mill floor swabs were analyzed for standard plate counts (SPC), total coliforms (TC), fecal coliforms (FC), and E. coli. E. coli was isolated from 14 (33%) of 42 samples of bottled fresh cider, from food equipment in 6 (67%) of 9 mills, and from apples, pomace, or cider in 7 (78%) of 9 mills. Seventy-five E. coli isolates were further characterized for Shiga toxin-producing E. coli (STEC)-associated virulence factors, antimicrobial susceptibility, and pulsed-field gel electrophoresis (PFGE) type. No E. coli O157:H7 or other STEC was identified. Serotyping and PFGE revealed 64 distinct profiles, suggesting that recovered E. coli arose from multiple independent sources. However, on one occasion, E. coli isolated from the source apple sample was closely related to the E. coli identified in the finished cider sample. E. coli isolates were further tested for antimicrobial susceptibility to 17 antimicrobial agents of human and veterinary importance. Fourteen (19%) of the 75 isolates were resistant to at least one of the antimicrobial agents tested, and 9 (12%) were resistant to at least two of these agents. Of the resistant isolates recovered, 64% were resistant to tetracycline and 57% were resistant to streptomycin. Overall, the level of E. coli contamination in source apple samples did not differ significantly from those in samples of pomace, cider at the press, and cider entering the bottling tank; therefore, source apples cannot be dismissed as a potential contributor of E. coli to the cider-making process.     

Influence of fruit variety, harvest technique, quality sorting, and storage on the native microflora of unpasteurized apple cider

Apple variety, harvest, quality sorting, and storage practices were assessed to determine their impact on the microflora of unpasteurized cider. Seven apple varieties were harvested from the tree or the ground. The apples were used fresh or were stored at 0 to 4 degrees C for < or = 5 months and were pressed with or without quality selection. Cider yield, pH, Brix value, and titratable acidity were measured. Apples, postpressing apple pomace, and cider samples were analyzed for aerobic bacteria, yeasts, and molds. Aerobic bacterial plate counts (APCs) of ciders from fresh ground-picked apples (4.89 log CFU/ml) were higher than those of ciders made from fresh, tree-picked apples (3.45 log CFU/ml). Quality sorting further reduced the average APC to 2.88 log CFU/ml. Differences among all three treatment groups were significant (P < 0.0001). Apple and pomace microbial concentrations revealed harvest and postharvest treatment-dependent differences similar to those found in cider. There were significant differences in APC among apple varieties (P = 0.0001). Lower counts were associated with varieties exhibiting higher Brix values and higher titratable acidity. Differences in APC for stored and fresh apples used for cider production were not significant (P > 0.05). Yeast and mold counts revealed relationships similar to those for APCs. The relationship between initial microbial load found on incoming fruit and final cider microbial population was curvilinear, with the weakest correlations for the lowest apple microflora concentrations. The lack of linearity suggests that processing equipment contributed to cider contamination. Tree-picked quality fruit should be used for unpasteurized cider production, and careful manufacturing practices at cider plants can impact both safety and quality of the final product.     

Simultaneous detection of Escherichia coli O157:H7, Salmonella, and Shigella in apple cider and produce by a multiplex PCR

With three pairs of primers, a multiplex PCR assay was established for the simultaneous detection of Escherichia coli 0157:H7, Salmonella, and Shigella. Under the optimized conditions, the assay yielded a 252-bp product from E. coli O157:H7, a 429-bp product from Salmonella Typhimurium, and a 620-bp product from Shigella flexneri, respectively. When the DNA extraction of multiple target organisms was included in the same reaction, two or three corresponding amplicons of different sizes were observed. In the specificity test, 10 E. coli O157:H7 strains and one E. coli O157:NM strain showed the expected 252-bp amplicon. Seven other E. coli strains yielded no signal. Additionally, the 429-bp amplicon was produced from 20 Salmonella strains covering 16 serotypes, whereas the 620-bp amplicon was generated from 11 Shigella strains covering 4 species. No nonspecific amplification was observed with DNA from 48 other bacterial strains. Following a 24-h enrichment, the developed assay could concurrently detect the three pathogens at initial inoculation levels of approximately 8 x 10(-1) CFU/g (or CFU/ml) in apple cider, cantaloupe, lettuce, tomato, and watermelon and 8 x 10(1) CFU/g in alfalfa sprouts. The whole procedure can be easily completed within 30 h. The multiplex PCR assay can potentially be a simple, rapid, and efficient tool for presumptive and simultaneous screening of apple cider and produce for contamination by E. coli O157:H7, Salmonella, and/or Shigella.