VCM悬浮聚合分散剂体系研究(PVC-SG3型树脂的中试)

悬浮法VCM聚合所用分散剂品种较多，按其应用主要分为两大类，即：聚乙烯醇类和纤维素醚类。我们通过试验，在聚合过程中采用单一的PVA三元复合分散剂体系，所试制的PVC树脂各项常规指标和塑化性能均优于HPMC分散体系的树脂。     

氯乙烯SET-DT悬浮聚合动力学和成粒过程的相互关系

以碘仿为引发剂、连二亚硫酸钠/碳酸氢钠为催化体系、聚乙烯醇(PVA)和/或纤维素衍生物(MC)为分散体系,进行氯乙烯单电子转移-蜕化链转移(SET-DT)活性自由基悬浮聚合,采用在线示踪气相色谱法和激光粒度分析系统研究分散剂种类和浓度、搅拌转速等对聚合动力学和单体液滴/聚合物颗粒粒径分布的影响。发现在相同搅拌转速下,以MC为分散剂的氯乙烯聚合速率最大,以PVA为分散剂时反应速率最小;分散剂种类固定时,聚合速率随分散剂浓度增大而增大。SET-DT悬浮聚合过程中,水相连二亚硫酸钠分解产生的自由基向单体液滴的扩散速率与液滴粒径分布和皮膜结构有关,因此聚合成粒过程影响聚合动力学。尽管不同条件下的聚合均经历液-液分散、液滴黏并、树脂颗粒稳定(转化率>30%)等成粒阶段,但各阶段的液滴/颗粒平均尺寸随分散体系和搅拌转速的变化而变化,引起聚合速率变化;采用MC为分散剂得到的PVC树脂皮膜少,有利于水相产生的自由基向单体相的扩散,聚合速率大。     

无外加表面活性剂的苯乙烯悬浮聚合

针对传统悬浮聚合制备聚苯乙烯颗粒粒径分布宽、有效粒子收率低的问题,采用过硫酸铵/磷酸钙复合分散剂体系,在无外加表面活性剂情况进行苯乙烯悬浮聚合,制备了聚苯乙烯珠粒。通过对聚合稳定性、聚苯乙烯珠粒粒径及分布的测定与分析,考察了磷酸钙、过硫酸铵的用量及比例对悬浮聚合的影响,并分析了过硫酸胺对悬浮聚合的分散稳定机理。结果表明,当过硫酸铵和磷酸钙的用量分别为单体质量的0.01%和1.00%时,悬浮聚合体系稳定,得到的粒子透明性好,平均粒径为1.35 mm,粒径分布窄;通过改变过硫酸铵和磷酸钙的用量,可以调节聚苯乙烯珠粒的平均粒径。     

悬浮法PVC的颗粒形态及改进方法

概述了悬浮法PVC的颗粒形态，并详细介绍了改进悬浮法PVC颗粒形态的方法：选择适宜的分散体系[如Mg(OH)2无机分散体系、离子敏感性分散剂、PVA复合分散剂、TiO2分散剂等]及合适的引发剂(如使用引发剂乳液、加入有机钴等)；采用倒加料法及后加分散剂的聚合进料工艺。     

在无机分散剂存在下苯乙烯悬浮聚合宏观成粒的特征

以苯乙烯悬浮聚合为体系,考察羟基磷酸钙(HAP)或HAP与聚乙烯醇(PVA)复合为分散剂体系时,各种因素如分散剂浓度、油水比、搅拌速度等与瞬时液滴大小及分布之间的关系,并分析讨论瞬时液滴分散、合并的过程特征.结果表明,悬浮苯乙烯液滴聚合宏观成粒的特征与分散剂的分散机理无关,仅体现液滴分散、合并的过程特点.当采用分批加分散剂时,实验观察到瞬时液滴大小分布呈由单峰过渡到双峰,再发展成单峰分布的特征,从而找出了以分批加分散剂方式制备窄分布聚合物颗粒的理论依据.     

羟基磷酸钙的制备及其对甲基丙烯酸甲酯悬浮聚合的影响

利用Ca(OH)2和H3PO4中和反应制备悬浮聚合分散剂超细羟基磷酸钙(HAP). 通过正交实验法,研究了反应温度、Ca(OH)2浓度、H3PO4滴加速度、表面活性剂十二烷基苯磺酸钠(SDBS)的加入量等各因素对反应产物羟基磷酸钙结晶形态与尺寸的影响. 分别将不同条件下制备的HAP与聚乙烯醇(PVA)组成复合分散体系,通过甲基丙烯酸甲酯(MMA)的悬浮聚合反应,比较了各组的聚合效果. 应用红外光谱及透射电镜对HAP进行了表征,分析了HAP的结晶形态及尺寸对聚甲基丙烯酸甲酯(PMMA)的粒径及其分布的影响. 结果表明,本实验制备的长′宽为140 nm×35 nm的针状结晶HAP与PVA的复合分散体系对MMA悬浮聚合效果最好,可制备出综合性能较好、粒径d32达1.41 mm的PMMA光学小球.     

胶原蛋白/PVA/碳纳米管复合纤维的结构与性能

在胶原蛋白与聚乙烯醇(PVA)复合后的溶液中加入少量质量分数为0.05%~0.25%的碳纳米管,通过湿法纺丝制得PVA/胶原蛋白/碳纳米管复合纤维,研究了复合纤维的结构和性能。结果表明:碳纳米管与PVA和胶原蛋白有较好的相容性,在复合纤维中分散比较均匀。添加质量分数为0.25%碳纳米管时,复合纤维结晶度提高了37.62%,水中软化点提高了5℃,回潮率从11.50%下降到10.83%;加入质量分数为0.05%的碳纳米管时,复合纤维的断裂强度提高57.07%。     

疏水作用色谱用球状交联聚乙烯醇的制备

采用悬浮聚合法成功地制备了PVA白球。本文对水溶液中PVA含量、甲醛用量、表面活性剂、油水体积比、搅拌速度及反应温度等影响因素进行了研究和探索。实验得到了最佳工艺条件为：50ml15％PVA分散在300ml的油相中,以3.0g油酸钠和5．0molSpan－80作表面活性剂,用10ml甲醛溶液作交联剂,在88℃和400r/min的条件下进行悬浮聚合,制备得到了缩醛化度为30％的球状PVA颗粒,其中粒径0．30－0．45mm（40－60目）者约占80％。     

疏水作用色谱用球状交联聚乙烯醇的制备

采用悬浮聚合法成功地制备了PVA白球 ,对水溶液中PVA含量、甲醛用量、表面活性剂配伍和用量、油水体积比、搅拌速度及反应温度等影响因素进行了研究和探索。优惠工艺条件为 :5 0ml 15 %PVA分散在 3 0 0ml的油相中 ,以 3 .0 g油酸钠和 5 .0mlspan -80作表面活性剂 ,用 10ml甲醛溶液作交联剂 ,在 88℃和 40 0r/min的条件下进行悬浮聚合。制备得到了缩醛化度为 3 0 %的球状PVA颗粒 ,其中粒径为 0 2 4～ 0 .3 5mm的约占 80 %。     

悬浮聚合制备丙烯酸粉末涂料

先用偶联剂对钛白粉进行有机化处理，将钛白粉分散于丙烯酸酯单体，然后进行悬浮聚合制备了丙烯酸粉末涂料。讨论了聚乙烯醇（PVA）和十二烷基苯磺酸钠（SDBS）对合成工艺和产物的影响。试验结果表明：采用PVA作分散剂，SDBS作协助分散剂，分散体系稳定，粒径小。通过电镜观察粒子的形态结构看出；采用悬浮聚合制得的粒子呈规整的球形结构，传统的熔融混炼粉碎法制得的粒子形状不规整。     

Insect antifeedant properties of anthranoids from the genusVismia

Vismiones and ferruginins, representatives of a new class of lypophilic anthranoids from the genusVismia were found to inhibit feeding in larvae of species ofSpodoptera, Heliothis, and inLocusta migratoria.     

Methyl 2,4,6-decatrienoates Attract Stink Bugs and Tachinid Parasitoids

Halyomorpha halys (Stål) (Pentatomidae), called the brown marmorated stink bug (BMSB), is a newly invasive species in the eastern USA that is rapidly spreading from the original point of establishment in Allentown, PA. In its native range, the BMSB is reportedly attracted to methyl (E,E,Z)-2,4,6-decatrienoate, the male-produced pheromone of another pentatomid common in eastern Asia, Plautia stali Scott. In North America, Thyanta spp. are the only pentatomids known to produce methyl 2,4,6-decatrienoate [the (E,Z,Z)-isomer] as part of their pheromones. Methyl 2,4,6-decatrienoates were field-tested in Maryland to monitor the spread of the BMSB and to explore the possibility that Thyanta spp. are an alternate host for parasitic tachinid flies that use stink bug pheromones as host-finding kairomones. Here we report the first captures of adult and nymph BMSBs in traps baited with methyl (E,E,Z)-2,4,6-decatrienoate in central Maryland and present data verifying that the tachinid, Euclytia flava (Townsend), exploits methyl (E,Z,Z)-2,4,6-decatrienoate as a kairomone. We also report the unexpected finding that various isomers of methyl 2,4,6-decatrienoate attract Acrosternum hilare (Say), although this bug apparently does not produce methyl decatrienoates. Other stink bugs and tachinids native to North America were also attracted to methyl 2,4,6-decatrienoates. These data indicate there are Heteroptera in North America in addition to Thyanta spp. that probably use methyl 2,4,6-decatrienoates as pheromones. The evidence that some pentatomids exploit the pheromones of other true bugs as kairomones to find food or to congregate as a passive defense against tachinid parasitism is discussed.     

2005～2006年国外塑料工业进展

收集了2005年7月～2006年6月国外塑料工业的相关资料，介绍了2005—2006年国外塑料工业的发展情况。提供了世界塑料产量、消费量及全球各类树脂生产量以及各国塑料制品的进出口情况。作为对比，介绍了中国塑料的生产情况。按通用热塑性树脂（聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂）、工程塑料（聚酰胺、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚）、通用热固性树脂（酚醛、聚氨酯、不饱和树脂、环氧树脂）、特种工程塑料（聚苯硫醚、液晶聚合物、聚醚醚酮）的品种顺序，对树脂的产量、消费量、供需状况及合成工艺、产品开发、树脂品种的延伸及应用的扩展作了详细的介绍。     

2007～2008年世界塑料工业进展

收集了2007年7月～2008年6月世界塑料工业的相关资料,介绍了2007～2008年国外塑料工业的发展情况,提供了世界塑料产量、消费量及全球各类树脂的需求量及产能情况.按通用热塑性树脂(聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂)、工程塑料(尼龙、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚)、特种工程塑料(聚苯·硫醚、液晶聚合物、聚醚醚酮)、通用热固性树脂(酚醛、聚氨酯、不饱和聚酯树脂、环氧树脂)不同品种的顺序,对树脂的产量、消费量、供需状况及合成工艺、产品应用开发、树脂品种的延伸及应用的进一步扩展等技术作了详细介绍.     

Inorganic/organic nanocomposite coatings: The next step in coating performance

Inorganic/organic hybrid materials have considerable promise and are beginning to become a major area of research for many coating usages, including abrasion and corrosion resistance. Our primary approach is to prepare the inorganic phase in situ within the film formation process of the organic phase. The inorganic phase is introduced via sol-gel chemistry into a thermosetting organic phase. By this method, the size, periodicity, spatial positioning, and density of the inorganic phase can be controlled. An important aspect of the inorganic/organic hybrid materials is the coupling agent. The initial task of the coupling agent is to provide uniform mixing of the oligomeric organic phase with the sol-gel precursors, which are otherwise immiscible. UV-curable inorganic/organic hybrid systems have the advantages of a rapid cure and the ability to be used on heat sensitive substrates such as molded plastics. Also, it is possible to have better control of the growth of the inorganic phase using UV curing. It is our ultimate goal to completely separate the curing of inorganic and organic phases to gain complete control over the morphology, and hence optimization of “all” the coating properties. Thus far, it has been found that concomitant UV curing of the inorganic and organic phases using titanium sol-gel precursors afforded nanocomposite coatings which completely block the substrate from UV light while maintaining a transparent to visible light. Also, it has been found that the morphology of the inorganic phase is highly dependent on the concentration and reactivity of the coupling agent. Presented at the 82nd Annual Meeting of the Federation of Societies for Coatings Technology, October 27–29, 2004, in Chicago, IL.     

Ethanol and (−)-α-Pinene: Attractant Kairomones for Some Large Wood-Boring Beetles in Southeastern USA

Ethanol and α-pinene were tested as attractants for large wood-boring pine beetles in Alabama, Florida, Georgia, North Carolina, and South Carolina in 2002–2004. Multiple-funnel traps baited with (−)-α-pinene (released at about 2 g/d at 25–28°C) were attractive to the following Cerambycidae: Acanthocinus nodosus, A. obsoletus, Arhopalus rusticus nubilus, Asemum striatum, Monochamus titillator, Prionus pocularis, Xylotrechus integer, and X. sagittatus sagittatus. Buprestis lineata (Buprestidae), Alaus myops (Elateridae), and Hylobius pales and Pachylobius picivorus (Curculionidae) were also attracted to traps baited with (−)-α-pinene. In many locations, ethanol synergized attraction of the cerambycids Acanthocinus nodosus, A. obsoletus, Arhopalus r. nubilus, Monochamus titillator, and Xylotrechus s. sagittatus (but not Asemum striatum, Prionus pocularis, or Xylotrechus integer) to traps baited with (−)-α-pinene. Similarly, attraction of Alaus myops, Hylobius pales, and Pachylobius picivorus (but not Buprestis lineata) to traps baited with (−)-α-pinene was synergized by ethanol. These results provide support for the use of traps baited with ethanol and (−)-α-pinene to detect and monitor common large wood-boring beetles from the southeastern region of the USA at ports-of-entry in other countries, as well as forested areas in the USA.