Fe81Ga19合金晶体生长取向与磁致伸缩性能

通过区熔定向凝固法,生长出[001]易磁化方向与晶体轴向之间存在不同取向差的Fe₈₁Ga₁₉合金单晶体和Fe₈₁Ga₁₉合金多晶体.极图测试结果显示,Fe₈₁Ga₁₉合金单晶体的[001]方向与轴向取向差分别为12°,5°和3°.采用电阻应变片法测定相应磁致伸缩应变,与外加磁场方向平行的轴向磁致伸缩应变分别为254×10^-6,271×10^{-6< 关键词： 磁致伸缩 81Ga₁₉合金')" href="#">Fe₈₁Ga₁₉合金 晶体取向}     

离轴磁场退火后Tb0.3Dy0.7Fe1.95〈110〉取向晶体的磁致伸缩"跳跃"效应

将〈110〉取向Tb_0.3Dy_0.7Fe_1.95合金棒放在与轴向成35°夹角的外磁场中退火处理,研究其在0—30 MPa预压应力σpre作用下的磁致伸缩效应.结果表明,σpre=0条件下的饱和磁致伸缩值λs由退火前的1023×10^-6提高到1650×10^-6;σpre 关键词： 磁致伸缩 磁场退火 磁致伸缩"跳跃"效应     

Magnetic anisotropy of Sm2Fe14B single crystal

Magnetization measurements have been made on a Sm₂Fe₁₄B single crystal in magnetic fields up to 140 kOe. The easy direction of the magnetization lies along [100] in the tetragonal structure P4₂/mnm. Magnetic anisotropy energies at 290K along [110] and [001] have been estimated to be 5.8×10⁶ and 1.1×10⁸ erg/cm³, respectively, both becoming much larger at lower temperature. No evidence of the spin canting of Nd₂Fe₁₄B type is observed even at 4.2K.     

Elastic Modulus of Fe72.5Ga27.5 Magnetostrictive Alloy

The elastic modulus of Fe72.5Ga27.5 magnetostrictive alloy is determined by testing ac impedance resonance frequency and first-principle calculations. The observed elastic modulus is 90.2 GPa for a directionally solidified sample and 103.4 GPa for a water-quenched sample tested in a dc magnetic field of 32. 7mT without compressive pre-stress. The bulk modulus by first-principles calculation is 179.3GPa which is basically consistent with the experimental result. The elastic modulus first increases and then decreases with increasing dc magnetic field, attributed to magnetostriction occurrence in the Fe72.5Ga27.5 alloy. The elastic modulus increases with increasing compressive pre-stress, resulting from the initial magnetic states change under the applied compressive pre-stress. The elastic modulus increases match well with the improved magnetostriction after quenching.     

Co50Ni22Ga28:Fex单晶在室温和100℃高温的超弹性研究

制备了四元铁磁性Heusler合金Co₅₀Ni₂₂Ga_{28：Fex（x＝0，1.5，2，2.5），发现材料具有很好的机械性能，在加压、 弯曲和扭曲时都展现出很好的超弹性.室温时，在压力作用下，Co50Ni22< /sub>Ga28：Fe2单晶样品在［001］和［110］方向分别具有约4%和 6.7%的完全可恢复应变.Co50Ni22Ga28：Fe1.5单晶样品在室温下沿［001］和［110］方向的应力与应变σ-ε曲线的平台部分较缓， 但升温到100℃时，σ-ε曲线中表示超弹性应变的平台变平.Co50Ni22Ga28 ：Fe2.5成分的单晶在［001］方向可得到5.5%的超弹性应 变.同时以上材料都显示出了明显的弹性各向异性. 关键词： 铁磁性Heusler合金 超弹性 50Ni22Ga28：Fex')" href="#">Co50Ni22Ga28：Fex}     

Large magnetostriction and structural characteristics of Fe83Ga17 wires

The columnar-grained structure induced by directional solidification was beneficial to improve the deformability of Fe₈₃Ga₁₇ alloy. Fe₈₃Ga₁₇ wires with diameter of 0.5∼0.9 mm were prepared successfully by hot rotary swaging and warm drawing from the directional solidified rods. The magnetostriction and microstructure of the as-drawn and the annealed Fe₈₃Ga₁₇ wires with diameter of 0.6 mm were investigated. Results demonstrated that the magnetostriction of Fe₈₃Ga₁₇ wires depended on the microstructure and the fiber texture, which were controlled by heat treatment process. The maximum magnetostriction of 160 ppm was detected in the annealed wire, which has the ideal <100> fiber texture. The phase mixture of A2 containing heterogeneous modified-DO₃ phase has beneficial effect on magnetostriction.     

Magnetoelasticity and elasticity of Fe85Ga15 single crystals under coupled magnetomechanical loading

The effect of coupled magnetomechanical loading on magnetostriction and compressive strain of Fe-Ga alloys has been investigated. A shift from negative to positive magnetostriction was observed with increase in compressive stress on a Fe₈₅Ga₁₅ single crystal. Non-linear behavior of the compressive strain in different magnetic fields was observed during the compressive loading and unloading process. These phenomena can clearly be explained by a model based on the magnetic-domain-switching process. The Young's modulus can also be obtained from the measured stress-strain curves.     

Structure and magnetic properties of melt-spun Tb0.27Dy0.73Fex ribbons

The structure and magnetic properties of the melt-spun ribbons of Tb_0.27Dy_0.73Fe_x alloy are investigated as a function of various wheel speeds during melt-quenching using a single-roll technique. It is found that Tb_0.27Dy_0.73Fe_x alloy is difficult to be fabricated as amorphous state by using the melt-quenching method. X-ray diffractions show that all these ribbons for x=1.7−2.0 are the MgCu₂-type phase at the wheel speed of 45 m s⁻¹. For Tb_0.27Dy_0.73Fe_x alloy, the high wheel speed is beneficial to eliminate the RFe₃ phase and form the perfect MgCu₂-type phase. Compared with the bulk of Tb_0.27Dy_0.73Fe_1.95, these ribbons exhibit higher intrinsic coercivity value and their saturation magnetizations increase as well. The magnetostriction of Tb_0.27Dy_0.73Fe_1.95 composite with 4% epoxy resin is 640×10⁻⁶ at 900 kA m⁻¹.     

过渡族元素掺杂BaTiO3-Tb1-xDyxFe2-y层状复合材料中的磁电效应

用溶胶-凝胶法制备1.0%mol Mn,Cr,Co掺杂 BaTiO₃(BTO)粉体,在1350℃下烧结成多晶陶瓷样品.X射线衍射和差示扫描量热分析表明,室温下掺杂BaTiO₃具有四方钙钛矿结构;居里点和相变潜热随Cr,Mn,Co掺杂逐渐降低.将掺杂BaTiO₃与Tb_1-xDy_xFe_2-y(TDF)胶合制成双层磁电复合材料,并研究了Cr:BTO-TDF,Mn∶BTO-TDF,Co:BTO-TDF层状复合材料中的磁电效应.实验表明,在340×80 A·m^-1偏置磁场下, Cr:BTO-TDF的横向磁电电压系数达到最大值586 mV·cm^-1·(80 A·m^-1)^-1.在400×80 A·m^-1偏置磁场下,Mn∶BTO-TDF和Co:BTO-TDF的横向磁电电压系数的最大值分别为480 mV·cm^-1·(80 A·m^-1)^-1和445mV·cm^-1·(80 A·m^-1)^-1.研究表明掺杂BaTiO₃-TDF层状复合材料中具有较强的磁电耦合.作为无铅压电材料,掺杂BaTiO₃制备的磁电效应器件颇具应用前景. 关键词： 磁电效应 双层复合材料 3')" href="#">掺杂BaTiO₃ 1-xDy_xFe_2-y')" href="#">Tb_1-xDy_xFe_2-y     

钴离子注入对二氧化钛晶体的结构和光学性能的影响

采用离子注入法制备了钴离子掺杂的金红石相TiO₂样品;离子注入能量、注量分别为40 keV(1×10¹⁶cm^-2),80 keV(5×10¹⁵,1×10¹⁶,5×10¹⁶,1×10¹⁷cm^-2),120 keV(1×10¹⁶cm^-2). 通过XRD,XPS和UV-Vis等手段对掺杂前后样品的结构和光学性能进行了表征,分析了掺杂元素在金红石TiO₂中的存在形式. XRD测试表明随着注入能量的增加晶体的损伤程度增加. UV-Vis测试表明掺杂后所有样品在可见光区的吸收增强; 并且随着注量的增加,注量为5×10¹⁵cm^-2到5×10¹⁶cm^-2范围内注入样品的光学带隙逐渐变小. 关键词： 钴 二氧化钛 离子注入 掺杂     

Spectral properties of Nd-doped Sr3Ga2Ge4O14 crystal

Neodymium doped strontium gallogermanate crystals were grown successfully by the Bridgman technique. The linear thermal expansion coefficients for the c- and a-axes were measured as 5.8 × 10⁻⁶ °C⁻¹ and 6.5 × 10⁻⁶ °C⁻¹. Absorption spectra, and fluorescence spectra, as well as fluorescence decay curves of Nd³⁺-doped Sr₃Ga₂Ge₄O₁₄ crystal, have been recorded at room temperature and used to calculate the absorption and stimulated emission cross-sections. Based on the Judd-Ofelt theory, three intensity parameters were obtained. The luminescent quantum efficiency of the ⁴F_3/2 level was determined to be approximately 73.8% for this material. Compared with other Nd³⁺-doped laser crystals, Nd³⁺-doped Sr₃Ga₂Ge₄O₁₄ crystal displays special laser properties due to its disorder structure.     

(La1-xPrx)2/3Sr1/3MnO3系列的磁致伸缩效应研究

用溶胶-凝胶方法制备了一系列的(La_1-xPr_x)_2/3Sr_{1/3MnO3多晶样品,研究了其电磁性能及磁致伸缩效应,发现样品低温下的磁致伸缩主要以线伸缩为主,且在低场下达到饱和,在Pr含量为0.3时达到最大值,约为-90×10^-6.随Pr掺杂含量的逐渐减小,磁致伸缩的饱和场也逐渐减小. 关键词：}     

γ-LiAlO2晶体生长、改性和热学性质研究

采用快速提拉法生长出了透明、完整的γ-LiAlO₂晶体，但是晶体的高熔点和易 挥发性限制了γ-LiAlO₂晶体质量.采用气相传输平衡法（vapor transport equilibra tion technique,VTE）工艺对晶体改性，半高宽（FWHM）值从1169arcsec降至442arcsec，继续升高VTE处理温度至1300℃，FWHM值反而升高至552arcsec.快速提拉法生长出来晶体，100］方向和［001］方向的热膨胀系数分别为172398×10^-6/K，107 664×10^-6/K.经过三步VTE处理后［100］和［001］方向热膨胀系数降至16 6539×10^-6/K和101784×10^-6/K. 关键词： 2')" href="#">γ-LiAlO₂ 气相传输平衡法 热膨胀系数     

Martensitic transformation and magnetic properties of ferromagnetic shape memory Fe66Pd30Rh4 alloys

This study mainly shows that in the Fe₆₆Pd₃₀Rh₄ (at%) alloys, the L1₀ phase plays an important role in magnetostriction due to the interplay of L1₀ martensitic twins with magnetic domains. The L1₀ martensitic twin structure exhibits a strong magnetocrystalline anisotropy energy constant (K_u=1.27-2.84×10⁶ (ergs/cm³)) along the tetragonal c axis direction. In addition, the L1₀ tetragonal martensitic twin structure shows both a perfect shape memory and a reversible shape memory effect; therefore, it is expected to be applicable in magneto-mechanical applications (such as microactuators or springs). However, in this study, we discover that solution treatment (ST) and aging heat treatments of Fe₆₆Pd₃₀Rh₄ ferromagnetic shape memory alloys influence the behavior of the martensitic transition, which is associated with the change in magnetic properties. The process of a thermoelastic L1₀+L1_m twin phase decomposition→non-thermoelastic L1₀+L1_m+α_bct structure in Fe₆₆Pd₃₀Rh₄ alloys during solution treatment and aging at 400-550 °C for various times is studied by scanning electron microscopy (SEM), transmission electron microscopy (TEM), and X-ray diffraction (XRD). The relation of phase separation morphology to the magnetic property change is examined with a superconducting quantum interference device (SQUID) magnetometer, and magnetostriction measurement is performed with a strain gage method and magnetostrictive meter setup. The results indicate that the process of martensitic transformation during aging leads to an increase in coercivity and a decrease in magnetostriction, simultaneously.     

High magnetostriction at low fields of (Tb1−xDyx)0.2Pr0.8(Fe0.4Co0.6)1.88C0.05 intermetallic compounds

The structure and magnetostriction of the (Tb_1−xDy_x)_0.2Pr_0.8(Fe_0.4Co_0.6)_1.88C_0.05 intermetallic compounds (0≤x≤1) were studied by X-ray diffraction and magnetic measurements. The formation of an approximate single Laves phase with a MgCu2-type cubic structure was observed in this series of compounds. It was found that the Curie temperature and the saturation magnetization of the compounds would decrease with increase in the Dy content up to x=1. The magnetostriction λ_a (λ_a=λ_‖-λ_⊥) gently rises when x≤0.6, and follows with a precipitous fall when x exceeds 0.6, with the highest value of λ_a being reached in the compounds with x=0.6. The magnetostriction of all the samples was observed to approach their own saturation in the magnetic fields higher than 4 kOe. This indicates that the addition of a small amount of Dy could effectively improve the low-field magnetostriction of the Tb_0.2Pr_0.8(Fe_0.4Co_0.6)_1.88C_0.05 compounds, which could become a kind of promising magnetostrictive material.     

Magnetostriction relative to pretransition in Ni50.5Mn24.5Ga25 single crystal

The strain behaviors as well as the structural and magnetic changes relative to the pretransition in the Ni_50.5Mn_24.5Ga₂₅ single crystals have been characterized by various methods, such as pretransition strain, magnetostriction, magnetization measurements, and TEM observations. A large magnetostriction up to 505 ppm measured in the [001] direction of the sample is obtained at the pretransition temperature with only a low magnetic field of about 1 kOe applied along the [010] direction. We found that not only the pretransition strain pronounces a more large change, but also the magnetostriction at a certain temperature exhibits a more large magnitude for field applied along the [010] direction than with field along the [001] direction. It is concluded that the magnetoelastic interaction is responsible for the premartensitic transition, and the magnetoelastic interaction in the [010] direction is stronger than that in the [001] direction.     

甲醇分子在金红石TiO2(110)和锐钛矿TiO2(001)表面吸附和反应的活性位点

通过高分辨的扫描隧道显微术研究并比较了金红石型TiO₂(110)-(1×1)和锐钛矿型TiO₂(001)-(1×4)两种表面的活性位点． 在金红石型TiO₂(110)-(1×1)表面, 观察到氧空位缺陷是O₂和CO₂分子的活性吸附位点,而五配位的Ti原子是水分子和甲醇分子的光催化反应活性位点．在锐钛矿型TiO₂(001)-(1×4)表面,观察到完全氧化的表面,Ti原子更可能是六配位的,H₂O和O₂分子均不易在这些Ti原子上吸附．经还原后表面出现富Ti的缺陷位点, 这些缺陷位点对H₂O和O₂分子表现出明显的活性． 锐钛矿型TiO₂(001)-(1×4)表面的吸附和反应活性并不具有很高的活性,某种程度上其表现出的活性似乎低于金红石型TiO₂(110)-(1×1)表面．     

Giant forced volume magnetostriction in polycrystalline Tb0.3Dy0.7Fe1.95 alloys under magnetomechanical loading

The axial and transversal linear magnetostrictions (λ_∥ and λ_⊥) in [1 1 0] oriented polycrystalline Tb_0.3Dy_0.7Fe_1.95 alloys were measured simultaneously under uniaxial magnetomechanical loading to get the forced volume magnetostriction (ω=λ_∥+2λ_⊥). Despite the almost zero ω observed in Terfenol-D single crystals, it reaches up to 1000×10⁻⁶ in polycrystalline Tb_0.3Dy_0.7Fe_1.95 alloys near the saturation magnetic field under a stress above 50 MPa.     

Magnetic properties of c-axis oriented Sr0.8La0.2Fe11.8Co0.2O19 ferrite film prepared by chemical solution deposition

A Sr_0.8La_0.2Fe_11.8Co_0.2O₁₉ ferrite film has been prepared on a (0 0 1) sapphire substrate by chemical solution deposition. Structural characteristics indicate that the film is c-axis oriented and single-phase with space group P6₃/mmc. The grains are regular columnar with diameter between 50 and 100 nm as determined by atomic force microscopy. The sample possesses high saturation magnetization (130 emu/cm³), high coercivity (6.9 kOe), and large squareness ratio (0.9) at room temperature, which makes it a promising recording material.     

Orientation dependence of electrical properties of 0.96Na<Subscript>0.5</Subscript>Bi<Subscript>0.5</Subscript>TiO<Subscript>3</Subscript>-0.04BaTiO<Subscript>3</Subscript> lead-free piezoelectric single crystal

In this paper, a single crystal of 0.96Na_0.5Bi_0.5TiO₃-0.04BaTiO₃ with dimensions of Φ 30×10 mm was grown by the top-seeded-solution growth method. X-ray powder diffraction results show that the as-grown crystal possesses the rhombohedral perovskite-type structure. The dielectric, piezoelectric and electrical conductivity properties were systematically investigated with 〈001〉, 〈110〉 and 〈111〉 oriented crystal samples. The room-temperature dielectric constants for the 〈001〉, 〈110〉 and 〈111〉 oriented crystal samples are found to be 650, 740 and 400 at 1 kHz. The (T _m, ε _m) values of the dielectric temperature spectra are almost independent of the crystal orientations; they are (306°C, 3718), (305°C, 3613) and (307°C, 3600) at 1 kHz for the 〈001〉, 〈110〉 and 〈111〉 oriented crystal. The optimum poling conditions were obtained by investigating the piezoelectric constants d ₃₃ as a function of poling temperature and poling electric field. For the 〈001〉 and 〈110〉 crystal samples, the maximum d ₃₃ values of 146 and 117 pC/N are obtained when a poling electric field of 3.5 kV/mm and a poling temperature of 80°C were applied during the poling process. The as-grown 0.96Na_0.5Bi_0.5TiO₃-0.04BaTiO₃ crystal possesses a relatively large dc electrical conductivity, especially at higher temperature, having a value of 1.98×10⁻¹¹ Ω⁻¹⋅m⁻¹ and 3.95×10⁻⁹ Ω⁻¹⋅m⁻¹ at 25°C and 150°C for the 〈001〉 oriented crystal sample.