燃煤氟中毒地区民用高氟煤的氟释放规律

实验室模拟实验和农户家中的现场测定表明,室内空气氟含量与民用煤的氟含量呈正相关趋势(R=0.612, p<0.01);但在民用炉燃烧温度条件下的煤氟释放率却与煤氟含量无关.在200～1200℃范围内,煤氟释放率随温度的变化曲线呈"S"型,即300℃时开始逐渐上升,700℃前较低,最高不超过31%,700℃至1000℃之间,则释放率迅速上升,随后较为缓慢,到1100℃至1200℃时,释放率接近100%,其整个释放曲线可用Logistic方程来拟合.总体上,煤氟释放与煤氟的存在状态和煤中的矿物及化学组成有关,贵州烟煤、无烟煤氟的燃烧释放要比陕南石煤更快,前者的释放率在1100℃时就接近100%,而后者则到1200℃时才释放完全.民用炉的燃烧温度最高为1000℃左右,这时贵州烟煤、无烟煤样品的平均氟释放率为86.9%,而陕南石煤样品的平均氟释放率为80.6%.

Regularity of Flourine Release from Fluorine-Rich Coal Combustion in the Fluorine Poisoning Area

Laboratory experiments and in situ measurements inside farmer's houses indicate that the fluorine concentration of indoor air was positively related with the fluorine content in the consumed coal (R = 0.612, P<0.01), but fluorine content in the coal had no effect on the release rate of coal fluorine under the usual combustion temperature of about 1000 degrees C. The release rate of coal fluorine varied versus combustion temperature ranging from 200 to 1200 degrees C, following a "S" curve pattern, increasing slowly under 300 to 700 degrees C, but quickly under 700 to 1000 degrees C, and then slowly again before finally reaching 100% under 1100 to 1200 degrees C, this curve can be fit by Logistic equation. The release rate of coal fluorine usually depends upon the existence status of fluorine and the chemical and mineral components of the coal. The fluorine in soft coal or anthracite from Guizhou is released more quickly than in bone coal from Southern Shanxi, with the former almost completely released under 1100 degrees C but the later almost completely released under 1200 degrees C. The combustion temperature of civil stoves is at most 1000 degrees C, under which averagely 86.9% of the fluorine in coal from Guizhou and 80.6% of that in bone coal from Southern Shanxi is released.