| Ag-G-MoS2复合材料在不同气氛下的摩擦磨损性能研究 |
| |
| 引用本文： | 陈凡燕,凤仪,杨茜婷,张学斌.Ag-G-MoS2复合材料在不同气氛下的摩擦磨损性能研究[J].中国机械工程,2012(5):537-542. |
| |
| 作者姓名： | 陈凡燕 凤仪 杨茜婷 张学斌 |
| |
| 作者单位： | 合肥工业大学 |
| |
| 基金项目： | 国家自然科学基金资助重大项目(91026018);国家自然科学基金资助项目(60979017);高等学校博士学科点专项科研基金资助项目(20110111110015);安徽省自然科学基金资助项目(11040606M50) |
| |
| 摘 要： | 采用粉末冶金方法制备银-二硫化钼-石墨复合材料,考察了不同成分的复合材料在大气与气氛中的摩擦磨损性能,分析讨论了成分改变对材料摩擦磨损性能的影响。实验表明:随着二硫化钼与石墨含量比的增大,复合材料在大气中的减摩性能逐渐减弱,耐磨性由于受到材料力学性能与摩擦机理的共同作用,变化不大,在N2气氛中的复合材料的减摩性增强,硬度增大,磨损率下降。对比结果表明,银-石墨(体积分数为20%)-二硫化钼(体积分数为10%)在不同气氛下的摩擦磨损性能较好且稳定。
|
| 关 键 词： | 银-二硫化钼-石墨复合材料 摩擦因数 磨损率 气氛 |
Friction and Wear Properties of Ag-G-MoS2 Composites in Different Ambiences |
| |
| Chen Fanyan Feng Yi Yang Xiting Zhang Xuebin.Friction and Wear Properties of Ag-G-MoS2 Composites in Different Ambiences[J].China Mechanical Engineering,2012(5):537-542. |
| |
| Authors: | Chen Fanyan Feng Yi Yang Xiting Zhang Xuebin |
| |
| Affiliation: | Chen Fanyan Feng Yi Yang Xiting Zhang Xuebin Hefei University of Technology,Hefei,230009 |
| |
| Abstract: | Ag-G-MoS2 composites with varied content were produced by means of powder metallurgy method.Their tribological performance in air and N2 conditions was investigated,and the effects of the content on the tribological properties were analyzed and discussed for the composites.The results show that: in air condition,with the increase of the content proportion of MoS2 and G,the antifriction of composites gets weaker,and the wear resistance which is decided by both mechanical properties and friction mechanisms doesn’t change too much;in N2 atmosphere,when the content proportion of MoS2 and G increases,antifriction of composites gets reinforced,and the wear loss rate gets smaller with the decrease of hardness.In conclusion,the friction and wear property of Ag-G(20%)-MoS2(10%) is good and stable. |
| |
| Keywords: | Ag-G-MoS2 composite friction coefficient wear loss rate ambiences |
| 本文献已被 CNKI 等数据库收录！ |
|
