烹饪油烟污染与处理技术探讨

为了降低油烟对环境的污染,分析了油烟中的主要污染物成分及油烟对人体健康的几种危害。讨论了五种油烟净化技术:惯性分离法、过滤分离法、液体洗涤法、静电沉积法、复合技术。分析了液体洗涤油烟净化技术的原理、水循环利用时对洗涤废液进行的油水分离,提出了采用流场分析喷淋,以了解其流场的特性。结果表明,采用液体洗涤法去除油烟效率高,安全可靠。     

Valorisation of used cooking oil sludge by codigestion with swine manure

The addition of lipid wastes to the digestion of swine manure was studied as a means of increasing biogas production. Lipid waste was obtained from a biodiesel plant where used cooking oil is the feedstock. Digestion of this co-substrate was proposed as a way of valorising residual streams from the process of biodiesel production and to integrate the digestion process into the biorefinery concept.Batch digestion tests were performed at different co-digesting proportions obtaining as a result an increase in biogas production with the increase in the amount of co-substrate added to the mixture. Semi-continuous digestion was studied at a 7% (w/w) mass fraction of total solids. Co-digestion was successful at a hydraulic retention time (HRT) of 50 d but a decrease to 30 d resulted in a decrease in specific gas production and accumulation of volatile and long chain fatty acids. The CH₄ yield obtained was 326 ± 46 l/kg VS_feed at an HRT of 50 d, while this value was reduced to 274 ± 43 l/kg VS_feed when evaluated at an HRT of 30 d. However these values were higher than the one obtained under batch conditions (266 ± 40 l/kg VS_feed), thus indicating the need of acclimation to the co-substrate. Despite of operating at low organic loading rate (OLR), measurements from respirometry assays of digestate samples (at an HRT of 50 d) suggested that the effluent could not be directly applied to the soil as fertiliser and might have a negative effect over soil or crops.     

Urinary 8-oxo-7, 8-dihydro-2′-deoxyguanosine concentrations after frying of bacon,a pilot study

Cooking fumes contain compounds that may give rise to oxidative stress and mutations when inhaled. The aim of this study was to evaluate if cooking fumes from frying of bacon induce oxidative stress by measurement of urinary 8-oxo-7,8-dihydro-2 deoxyguanosine, a marker of oxidatively damaged DNA. Three non-smoking women fried bacon for 3 h. Urine samples were taken as early morning void at the same time on four days; the morning before frying, the morning after first frying, the morning after three days of frying and one week after first urine sample. 8-Oxo-7,8-dihydro-2 deoxyguanosine, 1-hydroxypyrene and 2-hydroxyphenanthrene, metabolites of polycyclic aromatic hydrocarbons, were measured by liquid chromatography-mass spectrometry/mass spectrometry (LC-MS/MS). 8-Oxo-7,8-dihydro-2 deoxyguanosine correlated weakly with concentrations of 1-hydroxypyrene (r = 0.31, p = 0.042), but it did not correlate with 2-hydroxyphenanthrene (r = ?0.074; p = 0.64). Average urinary 8-oxo-7,8-dihydro-2 deoxyguanosine concentrations increased from the day before frying (16.3 ± 4.2 nmol/L) to the third day of frying (26.2 ± 10.2 nmol/L), although not statistically significantly. Our pilot study shows that frying of bacon may result in increased oxidative stress which further emphasises the possible carcinogenic potential of cooking fumes.     

传统北京烤鸭烤制过程中大气污染物的排放特征

烤鸭是具有北京特色的传统美食之一,制作过程采用果木炭火烤制方式,与其它食物烹饪过程存在明显的差异,国内还未对这类餐饮源的排放特征进行过系统研究,为掌握这类餐饮源排放特征,从而为污染控制提供技术依据,选取北京市具有代表性的烤鸭店,研究了其烤鸭烤制过程中大气污染物的排放特征.结果表明,传统烤鸭烤制过程中排放的油烟、颗粒物、挥发性有机物(VOCs)和醛酮类化合物的基准排放浓度分别为(0.74±0.45)、(15.32±7.93)、(7.60±3.41)和(1.22±0.59)mg·m~(-3);颗粒物排放浓度要远高于油烟排放浓度,VOCs组分构成相对复杂,既包括烷烃、烯烃、芳香烃等VOCs也包括醛酮类、醇类、酯类等含氧VOCs和卤代烃,其中3-甲基呋喃、乙醇和乙酸甲酯的浓度最高;醛酮类化合物的主要组分有乙醛、甲醛和丙烯醛等,其中C1~C3物质占72.27%.     

北京餐饮源排放细粒子理化特征及其对有机颗粒物的贡献

调研了北京餐饮业发展现状,通过在线监测、采样分析等手段研究北京4家不同烹调方式的餐馆所排放颗粒物的质量浓度、粒径分布、形貌特征、化学组分,并初步估算餐饮源排放细粒子对北京细粒子中颗粒有机物的贡献.结果表明,餐馆的原料、烹饪过程、油烟去除装置以及客流量都会影响餐馆所排放颗粒物的物理、化学性质.样本餐馆营业期间排放颗粒物PM_{2 .5}质量浓度是当日环境大气PM_{2 .5}质量浓度的8～35倍,PM_{1 .0}在PM_{2 .5}的质量浓度中约占50%～85%.餐饮源排放颗粒物多以固态和液态颗粒物形貌存在,化学组分质量百分数由多到少依次是有机物、无机离子和元素碳,分别占到PM_{2 .5}质量浓度的70%左右、5%～11%和小于2%.初步估计结果表明,北京餐饮源排放细粒子对有机颗粒物的贡献和交通源的排放相当,成为北京细粒子有机颗粒物的主要来源之一.认识餐饮源排放颗粒物的理化性质,可以为改善北京空气质量和保证居民身体健康提供数据支持.     

模拟烹饪油烟的粒径分布与扩散

烹饪油烟颗粒物粒径分布与扩散特性研究有助于解析其对室内空气质量和居民健康的影响,采用电子低压撞击器(ELPI)实时监测了油烟机开启和关闭状态下,模拟烹饪油烟发生处和3 m外位置处,0.03~10μm范围内油烟颗粒数浓度和质量浓度随粒径分布.油烟颗粒主要以655 nm以下的细颗粒为主.油烟机能够显著降低室内油烟浓度,开启油烟机后,油烟发生处颗粒数浓度从2.8×106个·cm-3降低到2.3×105个·cm-3,PM2.5(空气动力学直径≤2.5μm的颗粒)质量浓度从85.9 mg·m-3降低到6.2 mg·m-3.油烟机对PM10的净化效率高于PM2.5.油烟迅速从发生处扩散到3 m外,无通风状态下,总颗粒数浓度衰减达65%,PM2.5质量浓度衰减达75%.计算流体动力学(CFD)模拟了油烟机对油烟PM2.5质量浓度场扩散分布影响.红外摄像仪监测了油烟温度场分布扩散,以扇形向外扩散,伴随着油烟温度梯度降低.     

Nanofiltration of concentrated and salted tuna cooking juices

Tuna cooking juice from a Tunisian tuna-processing unit has a high level of polluting load: chemical oxygen demand (COD) is comprised between 4 and 20 g L⁻¹, nitrogen kjedahl (NK) between 0.6 and 3 g L⁻¹ and dry matter between 120 and 160 g L⁻¹. The juice has thus to be treated before being rejected into the environment. This paper considers the nanofiltration (NF) of these concentrated organic/inorganic mixtures using an AFC 30 (NF) membrane. The work focusses on the effect of organic and inorganic matters on the permeate flux and rejections of these matters. For this purpose, mixtures of salt and organic pollution (COD), used as model solutions, were prepared by the dilution of a typical industrial tuna cooking juice. The permeate flux was found to decrease when salt and organic matter concentrations increase. The recovery rate in organic matter decreases with increasing salt or organic matter content and the recovery rate of salt decreases when the COD concentration increases.     

Evaluating the potential of biodiesel (via recycled cooking oil) use in Singapore,an urban city

Singapore has pledged to attain 7–11% Business-As-Usual carbon emissions reduction by 2020. About 19% of CO₂ contribution stemmed from road transport in 2005. Commercial vehicles, which uses mainly diesel, consumed 695 million litres diesel in 2012. An estimated 115,585 tonnes or 127 million litres cooking oils (derived from seeds/fruits) were consumed in 2010, in which the bulk of used cooking oil is re-incorporated into the food preparation process while only a small amount is being recycled into biodiesel or disposed into the sewerage. Nevertheless, the present research reveals that biodiesel derived from spent cooking oil has potential to be a viable fuel supplement. Surveys were carried out involving three market segments – suppliers, processors and end-users – to identify the barriers and obstacles in mass production of biodiesel. A key enabler of biodiesel as a fuel supplement towards a greener environment lies in government mandate/policies in promoting greater biodiesel usage.     

邯钢焦化厂1#～4#焦炉烟尘治理

介绍了邯钢焦化厂1^#～4^#焦炉采用布袋式除尘的烟尘治理方案,装煤和出焦除尘工艺流程及部分改进措施。     

实用高效的油烟净化技术及设备

随着餐饮业的快速发展 ,油烟的污染日益严重。探讨分析了目前油烟污染的净化处理现状 ,论述了新型高效的油烟净化技术机理 ,从而开发研制出经济实用的油烟净化设备 ,为我国控制油烟污染开辟了新途径