不同安装角度对重介质旋流器内流场的分析研究

由于影响重介质旋流器流场的几何参数较多,针对性地研究不同旋流器安装角度对重介质旋流器流场的影响,进而降低煤炭运输和处理灰分的生产成本,实现煤炭的清洁,从而提高煤炭的质量.     

镍基高温合金GH202高温氧化后的微观组织演变

研究了镍基高温合金GH202在800~1100 ℃高温氧化后晶粒、碳化物和强化相的演变过程。采用透射电子显微镜、扫描电子显微镜和电子背散射衍射对其微观结构进行了表征。结果表明：镍基高温合金的硬度随氧化温度的升高而降低，1100 ℃氧化100 h后，硬度降低了43.5%。800和900 ℃氧化后晶粒生长速度较慢，而经900 ℃氧化后晶界碳化物析出显著增加。在1000和1100 ℃氧化后，晶粒尺寸明显增大。氧化过程中晶界迁移是由晶界两侧自由能差决定，温度越高，晶界向曲率中心迁移越快，大量细小晶粒被吞并形成了大晶粒。大块状碳化物（MC）分解成大量的碳原子，与Cr原子结合形成少量的富Cr颗粒状M₂₃C₆。在900 ℃氧化150 h后，M₂₃C₆演化为富Ti的M₆C。随着氧化温度的升高，碳化物在γ相中回熔。在800、900和1000 ℃氧化后，γ′相逐渐长大，在1100 ℃氧化100 h后，完全溶解于γ相。     

Achieving fabrication of highly transparent Y2O3 ceramics via air pre-sintering by deionization treatment of suspension

An easy albeit quite effective deionization suspension treatment was adopted to alleviate the detrimental effects related to the hydrolysis of Y₂O₃ in an aqueous medium. Fabrication of highly transparent Y₂O₃ ceramics with a fine grain size via air pre-sintering and post–hot isostatic pressing (HIP) treatment without using any sintering additive was achieved using the treated suspensions. The hydrolysis issue of Y₂O₃ powder in an aqueous medium was effectively alleviated by using deionization treatment, and a well-dispersed suspension with a low concentration of dissolved Y³⁺ species was obtained. The dispersed suspensions were consolidated by the centrifugal casting method, and the green bodies derived from the suspension of 35.0 vol% solid loading showed an improved homogeneity with a relative density of 52.1%. Fully dense Y₂O₃ transparent ceramic with high transparency was obtained by pre-sintering consolidated green compacts at a low temperature of 1400°C for 16 h in air followed by a post-HIP treatment at 1550°C for 2 h under 200 MPa pressure. The sample had a fine average grain size of 690 nm. The in-line transmittance of the sample reached 83.3% and 81.8% at 1100 nm and 800 nm, respectively, very close to the theoretical values of Y₂O₃.     

超高清电视系统关键技术浅析

本文对国内外的电视技术发展现状进行了充分的研究和分析,并对超高清电视系统的相关图像技术参数进行了分析和介绍。     

气藏采收率影响因素研究与启示——以靖边气田A井区为例

以鄂尔多斯盆地靖边气田A井区为例，采用单因素相关分析和数值模拟方法，对比研究了井网控制程度、储层物性及地层废弃压力对气藏采收率影响及其主次关系。结果表明，井网控制程度是影响采收率的首要因素，井网控制程度每增加10%，采收率提高8.5%；渗透率是影响采收率的重要因素，渗透率每增加10%，采收率平均增加6%；废弃压力对采收率亦有较大影响，废弃压力每降低10%，采收率可提高1.6%。三者对采收率影响综合排序为：井网控制程度>储层物性>废弃压力。分析认为，渗透率是储层固有属性，很难从根本改变；而废弃压力受井口外输压力和增压开采成本制约，降低幅度有限。因此，优化井网及增加井网控制程度是提高气藏采收率的有效途径。研究成果具有实践意义，可为改进气田开发方式和提高气藏采收率提供参考。     

Effects of ultrasound-assisted enzymatic hydrolysis and monosaccharides on structural,antioxidant and flavour characteristics of Maillard reaction products from sweet potato protein hydrolysates

Effects of ultrasound (US)-assisted enzymatic hydrolysis and different monosaccharides (arabinose; xylose, XY; galactose and glucose) on peptide structure, antioxidant activities and flavour characteristics of Maillard reaction products (MRP) from sweet potato protein hydrolysates were investigated. US markedly enhanced the MR progress, and USXY showed the lowest pH value of 5.04, the highest browning intensity and fluorescence intensity (P < 0.05). FTIR results revealed significant peptide structure changes in USXY, USAR and USGA compared to other samples. USXY exhibited the highest Oxygen radical absorbance capacity (ORAC) value of 109.15 µg TE/mL, followed by USGA and USAR (94.07 and 93.41 µg TE/mL), respectively (P < 0.05). USXY and USAR showed different aroma features as compared to other MRP (P < 0.05). In addition, US enhanced umami, sweetness and sourness attributes and reduced bitterness of all MRP. USXY exhibited the highest umami intensity score (7.4), followed by USGA (7.3) and USAR (7.2), respectively. Partial least square regression analysis showed that the stronger umami taste was strongly correlated to aldehydes, thiophenes, MW 1000–3000 and 500–1000 Da peptides. Thus, US-assisted enzymatic hydrolysis and MR with xylose (XY) could be a promising way to produce natural flavouring with improved antioxidant activity.     

Agglomeration Mechanism of Complex Ti-Al Oxides in Liquid Ferrous Alloys Considering High-Temperature Interfacial Phenomenon

Metallurgical and Materials Transactions B - This work presents the agglomeration mechanism of complex Ti-Al oxides in the liquid ferrous alloy. Cluster characteristics were investigated using Al...