氢化可的松母液错流萃取行为研究

将氢化可的松母液解析为氢化可的松、表氢化可的松和６α－羟基ＲＳ三种组分，模拟了母液的表观分配系数。拟合结果与实验值符合较好，平均相对误差＜５．５％。     

联合制碱母液精制研究(下)

Brief review of the evolutive course of preparation and refining of mother liquor in Hou's soda-manufacturing Process and the historical root of inferior quality of the product from Hou's Process to that of Ammonium Soda Process. By determination in production, the technical causes of carrying of "escaping crystal" in flooding liquid from the salting out crystallizer and necessity of replacing the existing mother liquor Ⅱ vat by mother liquor Ⅱ settling tank. Theoretical and engineering basis of refining of mother liquor in Hou's Process is emphasized. Main results from field test of purification and filtration at low temperature of mother liquor Ⅱ prepared from three kinds of salt as raw material are introduced. Principle opinions of application on production are put forward.     

亚硫酸盐法制浆废液的接枝共聚改性研究

首次报道了亚硫酸盐法制浆废液与丙烯酸类单体的接枝共聚改性反应。提出影响改性反应的主要因素是过氧化氢引发剂的用量,研究表明合适的引发剂用量为废液固体物干重的2.5%～3.0%。同时,随着接枝共聚反应中单体用量的提高,改性产物的粘度逐步提高。由于所生成基团的亲水性不同,在相同单体用量下,丙烯酰胺(AM)单体改性产物的粘度要高于丙烯酸(AA)单体改性产物。二元接枝共聚改性研究表明,随着AM单体用量比例的提高,产物的粘度也逐步上升。     

Chemical Composition Determination at the Bottom Region of a Recovery Boiler Furnace by Direct Minimization of Gibbs Free Energy

An optimization strategy has been applied to describe the chemical composition at the furnace bottom in the Kraft recovery boiler of a pulp production process. The concentrations of each involved chemical species were calculated through an optimization approach, minimizing the Gibbs free energy of the system. Various systems were proposed and tested, assuming different chemical species and phases number. Because serious initialization problems were found at this stage for some of the proposed systems, an optimization heuristic method (PSO) was used for the first approach to the problem. Once the appropriate phases number and chemical species in the system were determined, the initialization problems disappeared and the use of a deterministic optimization method (SQP) became viable. The proposed approach has shown to be satisfactory to reproduce industrial data and also data reported in the open scientific literature.     

木制品真空浸蜡实验研究

主要对在真空的条件下用液蜡作浸溃液、做木块被浸溃物的真空浸溃实验过程作了详细的介绍,分别介绍实验前的准备,实验中的现象及注意事项,试验结论等。然后说明在真空条件下的浸渍质量优于常规浸渍的质量,并得到一些浸渍质量与真空度和浸渍时间的定量关系,从而给出研究高质量浸渍结果的实验方法。     

高砷铜精矿浸出液制备砷酸铜及热力学研究

高砷铜精矿浸出液中因含砷较高存在砷害问题,砷回收利用具有重要的意义。研究针对某高砷硫化铜精矿除杂后的浸出液,探讨了以砷酸铜形式综合利用砷的热力学及工艺参数。绘制了Cu-As-H2O系电位-pH图,进行了砷酸铜制备工艺过程的热力学分析,对净化后的某高砷硫化铜精矿浸出液,以氨水为中和剂,当pH=5.0~8.0,温度80~90℃时,制得了CuAs2O4、C4H6As6Cu4O16、Cu5As2O10.5H2O、Cu5As4O15.9H2O、Cu2AsO4OH.3H2O及Cu2AsO4OH 6种不同结构的砷酸铜,沉砷后溶液中砷含量为9.11~35.82 mg/L。     

原子吸收光谱法测定甘草片剂中铁和锌

铁和锌是人体及植物生长必需的微量元素，其分析方法倍受关注。中草药因毒副作用小，富含人体所需的多种微量元素，成为人们进行身体保健、治疗疾病的首选。甘草片剂是广泛使用的一种中草药，它具有镇咳、平喘的作用。为了测定甘草片剂中的微量元素，采用火焰原子吸收光谱法绘制了铁和锌的标准曲线，对甘草片剂进行了消解，测定了铁和锌的含量。并通过加标回收的方法，得出该测定方法简单可行，精密度和灵敏度高，相对标准偏差为0．236％-0．718％，回收率为94．5％-98．5％。     

碱性条件下稻草NH4OH-KOH蒸煮黑液的絮凝处理

利用聚合氯化铝-聚丙烯酰胺处理稻草NH4OH-KOH蒸煮黑液。系统讨论了聚合氯化铝用量、聚丙烯酰胺用量、反应温度和黑液pH值等工艺参数对絮凝效果的影响，继而确定了适宜絮凝工艺条件。结果表明，该絮凝体系对黑液COD去除率为68%，木质素去除率为92%。仪器测试表明絮凝沉淀物中除含有大量木质素外，氮、钾等营养元素的含量分别为23. 73%、6. 24%(均为干基)，为絮凝沉淀物制备固体有机肥料创造条件；上层清液pH 为9. 20，呈碱性，杂质含量低，补加NH4OH/KOH后可作为蒸煮液循环使用，使稻草制浆更易于实施清洁生产。     

喷雾干燥在环保领域中的应用

环境保护是我国的基本国策之一,近年来呈蓬勃发展之势.本文主要介绍了喷雾干燥在半干法烟气脱硫、味精废水综合利用、造纸黑液处理等环保领域内的广泛应用.     

中小型造纸厂黑液碱回收探讨

对中小型造纸厂黑液碱回收，到目前为止尚无被公众认可的成熟技术。借鉴前人的经验和教训，从另一个角度思考造纸黑液的酸析残液中碱分离技术，采用环烷酸萃取技术，能理想地将酸析残液中Na^ 与可溶性有机物进行分离，分离效率达60％以上。该法优点是操作简单，生产成本低，工艺稳定性好；缺点是调配成的萃取剂异味较重，Na^ 回收率有待进一步提高。