Effects of fat replacement with a mixture of collagen and dietary fibre on small calibre fermented sausages

Effects of fat replacement on physicochemical, microbial and sensory properties of fermented sausages were determined after drying process and 4 weeks of storage. Fermented sausages were formulated with 20% pork back fat (control), and three reduced‐fat treatments were prepared by replacing 25%, 50%, and 75% of fat with a mixture of collagen, dietary fibre and ice (1:1:8). TBARS values of reduced‐fat treatments were significantly lower compared with control after drying (P ≤ 0.05). As fat replacing ratio increased, fat content decreased significantly (P ≤ 0.05), whereas moisture, protein and ash content increased significantly (P ≤ 0.05). There was no marked difference between the treatments in terms of microbial analysis, sensory colour, flavour, off‐flavour or overall acceptability (P > 0.05) during refrigerated storage. Therefore, replacing pork back fat with a mixture of collagen and dietary fibre in fermented sausages may contribute to reduce lipid oxidation and maintain sensory properties during storage.     

Enhancement of the nutritional status and quality of fresh pork sausages following the addition of linseed oil, fish oil and natural antioxidants

Fresh pork sausages (pork shoulder, pork back fat, water, rusk and seasoning) were manufactured where 15% of the pork back fat was substituted with linseed oil (LO) or fish oil (FO). Green tea catechins (GTC) and green coffee antioxidant (GCA) were added to both LO (LGTC 200 and LGCA 200) and FO (FGTC 200 and FGCA 200) substituted sausages at a level of 200 mg/kg. Raw and cooked pork sausages were either over-wrapped with oxygen permeable film (aerobic storage) or stored in modified atmosphere packages (MAP) containing 80% O₂:20% CO₂ or 70% N₂:30% CO₂, respectively for 7 days at 4 °C. Effects on fatty acid profiles, lipid oxidation, colour and sensorial properties were investigated. α-Linolenic acid increased from 1.34% (control) to 8.91% (LO) and up to 11.2% (LGTC 200 and LGCA 200). Addition of fish oil increased levels of EPA from 0.05% (control) to 2.83% (FO), 3.02% (FGTC 200) and 2.87% (FGCA 200) and DHA levels increased from 0.04% (control) to a maximum of 1.93% (FGTC 200). Lipid oxidation was low in raw and cooked linseed oil containing sausages. GTC (200 mg/kg) significantly (P < 0.05) reduced lipid oxidation in raw fish oil containing sausages after 7 days of storage. Colour parameters in raw pork sausages were unaffected by the packaging atmosphere. L^* lightness values were lower (P < 0.05) in LGTC 200 and a^* redness values lower (P < 0.05) in LGTC 200 and FGTC 200 after 7 days of storage. Sensory scores of cooked pork sausages were unaffected by linseed oil addition. Flavour and overall acceptability scores in cooked fish oil containing sausages were improved by GTC addition. Results obtained demonstrate potential for the production of nutritionally enhanced fresh pork sausages.     

Development of low-fat chicken bologna sausages enriched with inulin,oat fibre or psyllium

Growing demand for healthy meat products and the contemporary focus on the role of dietary fibre in nutrition have resulted in the development of reformulated meat products. This study investigated the enrichment of chicken bologna type sausages with 3% and 6% inulin, oat fibre or psyllium, while decreasing the fat content. Enrichment with 3% inulin or oat fibre was most suitable due to the comparable colour (a*: 10.96 vs. 10.16 for control, b*: 9.28 vs. 8.94 for control), texture parameters (adhesiveness: 0.26 N vs. 0.38 N for control, gumminess: 55.51N vs. 54.74 N for control, cohesiveness: 0.72 vs. 0.70 for control, hardness: 77.45 N vs. 78.03 N for control, springiness 0.94 vs. 0.93 for control, resilience: 0.39 vs. 0.37 for control, chewiness: 52.16 N vs. 50.93 N for control) and sensory properties to the control. Psyllium was less suitable regardless of the amount added to the bologna type chicken sausages. Enrichment with 6% dietary fibre had negative effects on the instrumental and sensory parameters. Sensory evaluation by consumers showed comparable acceptability for chicken bologna type sausages enriched with 3% inulin or oat fibre; however, sausages enriched with psyllium or 6% inulin or oat fibre were less acceptable.     

Physicochemical and fatty acid characteristics of stewed pork as affected by cooking method and time

This study was designed to investigate the effects of cooking on physicochemical and fatty acid characteristics of stewed pork. Pre‐fried or raw pork belly cubes were stewed for 60, 90, 120, 150 or 180 min. After cooking, proximate chemical composition, texture, sensory evaluation, lipid oxidation, fatty acid profiles and cholesterol content were determined. Prolonged cooking time resulted in higher percentages of dry matter, fat and fat loss in stewed cubes (P < 0.01), and pre‐frying also increased fat loss. Tenderness and elasticity values of texture profile analysis and sensory scores were the highest for the cubes stewed for 180 min or by pre‐frying combined with stewing for 150 min. Pre‐frying and extended cooking time significantly increased lipid oxidation (P < 0.01). Cooking modified fatty acid profiles which altered the derived cardiovascular indices, and reduced cholesterol content. Prolonged stewing improved eating quality and most nutritional values of pork belly.     

Production of squid emulsion sausages using pork skin and coconut powder mixture as fat replacers

How to improve the inferior properties of squid products is a big challenge for producers. Pork skin and coconut powder (PSCP) mixture were assessed as fat replacers in squid emulsion sausages. The modified treatment containing 100% PSCP had 62.58% less fat, 4.82% more protein and 8.79% more moisture than those of the control (P < 0.05). High PSCP concentration resulted in lower cooking loss, higher emulsion stability and better textural properties. Texture profile analysis (TPA) showed that the addition of PSCP significantly (P < 0.05) increased the hardness, cohesiveness and chewiness of the sausages. The three‐dimensional network structures of the sausages containing PSCP were more compact and homogeneous. Sensory evaluation results produced by a sensory panel comprised of 100 panellists indicated that the sausages had an excellent flavour and overall acceptability when the substitution was 60%. Therefore, pork skin and coconut powder can be used to replace the pork back fat in the squid emulsion sausage without sacrificing the quality.     

Energy content, sensory properties, and microbiological shelf life of German bologna-type sausages produced with citrate or phosphate and with inulin as fat replacer

ABSTRACT:  The aim of this study was to determine the feasibility of reducing energy content (9% to 48%) in bologna-type sausages by replacing fat with inulin and to study the effects of substituting citrate for phosphate in the traditional sausage formula. German-type mortadella was produced, and fat was replaced with increasing amounts of inulin as a frozen gel to yield 3%, 6%, 9%, and 12% inulin in the final product. In another part of the study, citrate was substituted for the phosphate in the recipe. All sausages produced were sliced, packaged under a modified atmosphere (70% N₂, 30% CO₂), and stored for 23 d at +7 °C. Sausage quality was determined by chemical and instrumental texture profile analyses, color measurement, sensory evaluation, and microbiological testing. Replacing fat with inulin led to significant energy content reductions of up to 47.5% (with 12% inulin). However, the sensory properties of these sausages were also different from those of the control mortadella: fracturability fell, hardness and adhesiveness rose, and color became darker. In general, the substitution of citrate for phosphate significantly reduced the negative effects of inulin. There were no significant differences in microbiological stability between different inulin batches but there were significant differences between phosphate and citrate batches. Overall, the energy content of bologna-type sausages produced with citrate and with up to 6% inulin as a fat replacer was 22% lower than that of the control sausages. Furthermore, the sensory attributes (texture, color) of these 6% inulin–citrate sausages were comparable to the control sausages, and the sausages were microbiologically stable for 23 d of storage.     

Functional dry fermented sausages manufactured with high levels of n‐3 fatty acids: nutritional benefits and evaluation of oxidation

Dry fermented sausages including fish oil extracts rich in n‐3 fatty acids were manufactured in order to obtain functional products, and their nutritional advantages and effects on oxidation process were compared with traditional ones. Modified products were manufactured with 5.3 g kg^?1 and 10.7 g kg^?1 of fish oil extract. Eicosapentaenoic acid (EPA) and docosahexaenoic acid (DHA) contents per 100 g of dry fermented sausages were 0.15 g and 0.13 g for the lower rate of addition and 0.33 g and 0.26 g, respectively, for the higher rate, compared with only 0.01 g EPA and 0.03 g DHA in the control products. No significant differences were found in the other fatty acids. A decrease in the n‐6/n‐3 ratios from 16.14 in the control to 7.78 in batch A and 5.32 in batch B was achieved. Thiobarbituric acid reactive substances values were similar in control (0.31 ppm) and in batch A products (0.34 ppm) but increased significantly in batch B products (1.22 ppm). No statistical differences were observed among batches for the content of cholesterol oxidation products (2.36–2.43 µg g^?1 fat) leading to similar percentages of oxidation. 7‐Ketocholesterol, considered an indicator of oxidation, was not present in any sample. Values obtained for L* and hue (arctg b*/a*) were comparable with those of meat products. Although no effect was observed in cholesterol oxidation product formation and instrumental measurements of colour, the highest level of n‐3 fatty acid seemed to accelerate the oxidation process significantly. Copyright © 2004 Society of Chemical Industry     

Enhancement of the nutritional status and quality of fresh pork sausages following the addition of linseed oil,fish oil and natural antioxidants

Fresh pork sausages (pork shoulder, pork back fat, water, rusk and seasoning) were manufactured where 15% of the pork back fat was substituted with linseed oil (LO) or fish oil (FO). Green tea catechins (GTC) and green coffee antioxidant (GCA) were added to both LO (LGTC 200 and LGCA 200) and FO (FGTC 200 and FGCA 200) substituted sausages at a level of 200 mg/kg. Raw and cooked pork sausages were either over-wrapped with oxygen permeable film (aerobic storage) or stored in modified atmosphere packages (MAP) containing 80% O₂:20% CO₂ or 70% N₂:30% CO₂, respectively for 7 days at 4 °C. Effects on fatty acid profiles, lipid oxidation, colour and sensorial properties were investigated. α-Linolenic acid increased from 1.34% (control) to 8.91% (LO) and up to 11.2% (LGTC 200 and LGCA 200). Addition of fish oil increased levels of EPA from 0.05% (control) to 2.83% (FO), 3.02% (FGTC 200) and 2.87% (FGCA 200) and DHA levels increased from 0.04% (control) to a maximum of 1.93% (FGTC 200). Lipid oxidation was low in raw and cooked linseed oil containing sausages. GTC (200 mg/kg) significantly (P < 0.05) reduced lipid oxidation in raw fish oil containing sausages after 7 days of storage. Colour parameters in raw pork sausages were unaffected by the packaging atmosphere. L¹ lightness values were lower (P < 0.05) in LGTC 200 and a¹ redness values lower (P < 0.05) in LGTC 200 and FGTC 200 after 7 days of storage. Sensory scores of cooked pork sausages were unaffected by linseed oil addition. Flavour and overall acceptability scores in cooked fish oil containing sausages were improved by GTC addition. Results obtained demonstrate potential for the production of nutritionally enhanced fresh pork sausages.     

Chitosan effects on quality properties of Greek style fresh pork sausages

The effect of chitosan (0.5% and 1%) added individually or in combination with nitrites (150 ppm) on microbiological (Total Viable Counts, Lactic acid bacteria, Pseudomonas spp., Brochothrix thermosphacta, Enterobacteriaceae, yeasts and moulds), physicochemical-chemical (pH, chemical composition, lipid oxidation) and sensory properties of fresh pork sausages stored at 4 °C for 28 days was investigated. Chitosan addition resulted in significant (p < 0.05) inhibition of microbial growth, while nitrites did not seem to protect sausages from microbial spoilage. A gradual reduction of nitrites was observed till the end of storage, when nitrites were almost depleted in all nitrite containing samples. The rate of lipid oxidation in fresh pork sausages was significantly decreased (p < 0.05) by addition of increasing levels of chitosan, while samples containing both chitosan and nitrites showed the lowest malondialdehyde (MDA) values, indicating a synergistic antioxidative effect. Consequently, the samples containing the combination of nitrites and chitosan at any level deteriorated less rapidly and were judged as more acceptable than all the other samples.     

Effect of dietary olive leaves (Olea europaea L.) on lipid and protein oxidation of refrigerated stored n‐3‐enriched pork

The objective of this study was to evaluate the effect of dietary olive leaves versus α‐tocopheryl acetate on lipid and protein oxidation of raw and cooked longissimus dorsi muscle from pigs fed diets supplemented with fish oil. Enrichment of pork with the very long chain n‐3 fatty acids increased (P ≤ 0.05) lipid oxidation in both raw and cooked chops during refrigerated storage, and decreased (P ≤ 0.05) the sensory attributes of the cooked chops, but had no effect (P > 0.05) on protein oxidation of both raw and cooked chops. Dietary olive leaves or α‐tocopheryl acetate had no effect (P > 0.05) on the fatty acid composition but decreased (P ≤ 0.05) lipid oxidation while exerting no effect (P > 0.05) on protein oxidation in both raw and cooked chops during refrigerated storage. In addition, dietary olive leaves at 10 g kg^?1 feed and α‐tocopheryl acetate at 200 mg kg^?1 feed exerted (P ≤ 0.05) a beneficial effect on the sensory attributes of cooked n‐3‐enriched chops.     

Effect of plant polyphenols and ascorbic acid on lipid oxidation,residual nitrite and N‐nitrosamines formation in dry‐cured sausage

The effects of green tea,grape seed polyphenols and ascorbic acid on pH, water activity (a_w), microbiological counts, TBARS, residual nitrite and N‐nitrosamines were determined in dry‐cured sausages during the ripening period. Results showed that TBARS increased gradually during ripening (P < 0.05), but were significantly reduced with plant polyphenols and ascorbic acid (P < 0.05). Green tea polyphenol (GTP) was most effective (P < 0.05) in reducing TBARS. Plant polyphenols and ascorbic acid significantly decreased residual nitrite, ascorbic acid being most effective (P < 0.05). The amount of N‐nitrosamines increased during ripening, but was significantly reduced with plant polyphenols and ascorbic acid (P < 0.05). Plant polyphenols had no significant effects on moisture content, a_w, pH or microbiological counts in dry‐cured sausage during ripening (P > 0.05). It was concluded that plant polyphenols and ascorbic acid were effective in maintaining the quality and safety of dry‐cured sausages.     

Effect of sampling fat location and cooking on fatty acid composition of beef steaks

To investigate the impact of sampling fat location and cooking on fatty acid composition of beef steaks, 21 raw steaks from crossbred steers were dissected to obtain outer (OSC) and inner subcutaneous fat (ISC), seam fat, marbling, and lean muscle. Twenty-one cooked steaks were dissected to obtain OSC, ISC, seam fat, surface and inner muscle. Trans-vaccenic acid and c9, t11-CLA percentages were lower (P < 0.05) in lean muscle than subcutaneous (s.c.) fat or marbling. Monounsaturated: saturated fatty acid ratios were lower (P < 0.05) in seam fat and marbling than s.c. fat or lean muscle. Linoleic and linolenic acid levels were highest in lean muscle and longer chain n−6 and n−3 fatty acids were only detected in lean muscle. Cooking did not change fatty acid composition dramatically except that n−6: n−3 ratio in s.c. and seam fat decreased after cooking (P < 0.05).     

Comparative studies of quality changes in white and dark muscles from common carp (Cyprinus carpio) during refrigerated (4 °C) storage

Differences between white and dark muscles from common carp (Cyprinus carpio) in sensory assessment, total viable counts (TVC), total volatile basic nitrogen (TVB‐N), pH, electrical conductivity (EC), biogenic amines (BAs), nucleotide degradation products and colours were investigated under air and vacuum conditions during refrigerated (4 °C) storage. Compared with white muscle, dark muscle had a higher lipid content, but lower crude protein and moisture content. TVC, TVB‐N, pH, and L* value were higher in white muscle, while K value and a* value were higher in dark muscle. Under both conditions, white and dark muscles had significant (P < 0.05) differences in tyramine and cadaverine content. Although dark muscle was significantly (P < 0.05) lower in ATP content, it had higher rate of IMP degradation and K value increase. Taking sensory and microbial indexes into consideration, dark muscle appeared to have a longer shelf life than white muscle under both conditions.     

Effects of fat reduction and fat replacer addition on some quality characteristics of frankfurter-type sausages

Some quality characteristics of frankfurters manufactured in three different fat levels (20%, 10% and 5%) and added citrus fibre (CF) and soy protein concentrate (SPC) were investigated. While moisture content of frankfurters increased with decreasing fat levels, protein contents increased. Lower fat levels resulted in lower water‐holding capacity (WHC), cooking losses and penetrometer values. Lower L* values and higher a* values were obtained in low fat frankfurters. SPC significantly increased the cooking losses in the sausages with 5% and 20% fat, but decreased in the sausages with 10% fat. The lower cooking loss values were obtained in sausages added CF for all fat levels. Addition of fat replacers decreased the L values but did not affect the a and b values. Addition of fat replacers increased hardness in case of low fat levels. The softer product was obtained with high‐fat formulation than low‐fat formulation. Lower taste scores were observed with addition of fat replacers.     

Effect of grape dietary fibre on the storage stability of innovative functional seafood products made from farmed meagre (Argyrosomus regius)

Two groups of farmed meagre (Argyrosomus regius) sausages were studied regarding quality changes and antioxidant capacity during a 98‐day storage experiment at 2 ± 2 °C. Control sausages contained 3.9% (w/w) of inner pea dietary fibre (IPDF) and the other group contained 0.9% (w/w) IPDF plus 3.0% (w/w) of antioxidant grape dietary fibre (AGDF). The control and AGDF meagre sausages presented a high nutritional value, given their low caloric content, fatty acid profile, amino acid composition and high DF content. Both products were remarkably stable over storage time. The AGDF had an effective antioxidant capacity, proven not only by the radical scavenging activity (90.0–91.0% vs. 82.1–85.4%) and reducing power (8.13–9.10 mg ascorbic acid equivalent g^‐1 vs. 4.16–4.24 mg ascorbic acid equivalent g^?1) measurements, but also by the lower thiobarbituric acid reactive species (TBARS) values (0.78–1.10 vs. 1.50–2.08 mg malonaldehyde kg^?1) over storage time. AGDF seemed to present antimicrobial effect, since on the 63rd day (beginning of significant microbial growth), the control sausages had more than 3 log CFU g^?1 and AGDF sausages much <3 log CFU g^?1. The sensory assessment pointed to some loss of textural quality, more accentuated in the AGDF sausages.     

Preparation and evaluation of low‐calorie functional ice cream containing inulin,lactulose and Bifidobacterium lactis

This study was aimed to investigate the effects of replacing 5% fat and sugar by inulin and lactulose, respectively, on the survival of Bifidobacterium lactis and physicochemical and sensorial characteristics of the ice cream. Total solids, pH, melting rate and sensory scores of low‐fat and/or low‐sugar ice cream samples did not differ significantly from the control. Overrun and hardness of low‐fat samples were significantly higher than that of the control group (P < 0.01). The viable counts of B. lactis in the low‐sugar synbiotic ice creams were significantly lower than that of other groups at the end of 90‐day storage (P < 0.01).     

Evaluation of the prebiotic potential of five kiwifruit cultivars after simulated gastrointestinal digestion and fermentation with human faecal bacteria

We studied the in vitro prebiotic potential of five different cultivars of kiwifruit including the green‐fleshed ‘Hayward’ and ‘Zesh004’ and the gold‐fleshed ‘Hort16A’, ‘Zesy002’ and ‘Zesy003’. The kiwifruit (25 g fresh weight equivalent) were subjected to simulated gastrointestinal digestion before fermentation for 16 h with faecal microbiota from ten individual donors. Microbial metabolites including lactate were quantified while changes in microbiome composition were determined by 16S rRNA sequencing. Lactate concentrations were highest with ‘Hayward’ (P = 0.01) and correlated with the amount of the kiwifruit fibre and polyphenols, chlorogenic acid and cryptochlorogenic acid. All the kiwifruit behaved similar to inulin in increasing the relative abundance of Bifidobacterium (P < 0.001), but unlike inulin, significantly (P < 0.001) increased the abundances of Ruminococcaceae and decreased Bacteroides. In comparison with inulin, the green‐fleshed kiwifruit selectively increased Lachnospira (P = 0.008) while the gold‐fleshed kiwi fruit increased Akkermansia (P < 0.001). These data suggest that the fibre and polyphenol content of the kiwifruit play a role in modulating gut microbial metabolism. Further clinical studies with these kiwifruit cultivars are required to confirm the potential prebiotic benefits that may be achieved by normal dietary intervention.     

Physicochemical properties and sensory evaluation of Mesona Blumes gum/rice starch mixed gels as fat-substitutes in Chinese Cantonese-style sausage

Effect of Mesona Blumes gum (MBG)/rice starch mixed gels on the fat substitute of Chinese Cantonese-style sausage was investigated in this study, monitored with physicochemical properties and sensory evaluation analyses. Experimental results suggest that there were no significant differences among pH, yield, residual nitrite and TBARS of high-fat (28%), low-fat (18%) and fat-substituted (18%) sausages. The same fat content of low-fat and fat-substituted sausages would aid to compare their physicochemical properties more effectively. In addition, the emulsifying stability and water holding capacity of fat-substituted sausages were better than those of the other groups. During refrigerated storage (4 °C, 3 weeks), fat-substituted sausages reflected similar hardness, chewiness and shear force properties with those of high fat sausages and higher than those of low fat sausages. Furthermore, results of the sensory evaluation indicated that fat-substituted sausages showed superior total acceptability compared with low-fat one after a 2 week refrigerated storage, but was slightly less than that of high-fat one at the same condition. Therefore, MBG/rice starch gels can be effectively used as a fat substitute in Chinese Cantonese-style sausage allowing the manufacture of healthier sausages.