高铝TRIP钢的微观组织与残余奥氏体稳定性研究

主要研究了高Al TRIP钢的显微组织与残余奥氏体的稳定性。通过光学显微镜、SEM、TEM观察了其微观组织。通过TEM观察了钢中马氏体与贝氏体的形貌。通过电子衍射斑分析,得出了残余奥氏体与马氏体的位向关系为K-S位向关系,奥氏体母相与贝氏体的位向关系为N-W位向关系。为研究残余奥氏体机械稳定性,对试验用钢进行了不同应变量的单向拉伸,用X射线测量了残余奥氏体体积分数。结果表明,真应变小于0.11时残余奥氏体体积分数随应变量增加而减少。真应变量大于0.11后,残余奥氏体体积分数随应变量增加变化不大。为了研究残余奥氏体热稳定性,将试验用钢冷却至不同的温度。发现高Al TRIP钢残余奥氏体热稳定性很高,深冷至-196℃条件下不发生马氏体转变。     

热轧相变诱发塑性钢的热模拟实验

 利用Gleeble 1500热应力 应变模拟机研究了铌含量、热变形参数(终轧温度和卷取温度)对相变诱发塑性(TRIP)钢组织和性能的影响。实验结果表明：不含铌实验钢的残余奥氏体量、残余奥氏体相中的碳含量、宏观维氏硬度和抗拉强度与常规低碳硅锰系TRIP钢的水平相当；增加铌含量，残余奥氏体量和残余奥氏体相中的碳含量有所下降，而宏观维氏硬度和抗拉强度提高；铌含量为0014%、终轧温度为780 ℃、卷取温度为400 ℃时，残余奥氏体量、残余奥氏体相中的碳含量与宏观维氏硬度和抗拉强度具有最佳组合。     

铌含量和热处理工艺对TRIP钢组织和力学性能的影响

通过两相区退火和贝氏体转变区等温处理,研究了铌含量和贝氏体等温处理温度对低碳 TRIP钢(w(Mn)=1.38%,w(Si)=0.6%,w(Al)=0.5%)组织和力学性能的影响.实验结果表明:增加铌含量,实验钢的残余奥氏体量减少,抗拉强度和屈服强度增加;当铌的质量分数为0.014%时,实验钢的伸长率和强塑积较高;贝氏体等温处理温度为400 ℃时,实验钢的残余奥氏体量较多,力学性能较好.     

贝氏体等温温度对超高强冷轧TRIP钢组织性能的影响

将C-Si-Mn钢加热至800℃保温120 s后,分别快速冷却至350～410℃保温600 s以模拟贝氏体等温转变工艺。通过扫描电镜(SEM)和拉伸测试的方法研究了贝氏体等温温度对超高强相变诱导塑性钢(TRIP钢)微观组织和力学性能的影响规律。结果表明,冷轧TRIP钢的微观组织由铁素体、贝氏体、马氏体和残余奥氏体组成;贝氏体和残余奥氏体形成于等温转变阶段,而马氏体形成于等温后的终冷阶段。随着贝氏体等温温度增加,固溶C原子扩散系数提高,促进残余奥氏体中碳化物的析出。因此,奥氏体中的平均固溶C含量降低,使得TRIP钢残余奥氏体分数降低,马氏体体积分数增加。贝氏体等温温度由350℃增加至410℃时,TRIP钢屈服强度由720 MPa降低至573 MPa,抗拉强度由1 195 MPa提高至1 312 MPa,伸长率A_(80)由17.8%降低至12.5%。贝氏体等温温度为350℃时,冷轧TRIP钢具有优良的综合力学性能,强塑积达到21 270 MPa·%。     

等温时间对低硅含铝热轧TRIP钢组织性能的影响

 为了实现低硅含铝热轧TRIP钢的工业应用，以低硅含铝热轧TRIP钢为研究对象，采用扫描电子显微镜、透射电子显微镜、拉伸试验和X射线衍射等试验方法，研究了不同等温时间对试验钢显微组织和力学性能的影响。结果表明，试验钢的显微组织主要由多边形铁素体、贝氏体铁素体和残余奥氏体组成，随着等温时间的增加，板条贝氏体的体积分数升高，粒状贝氏体的体积分数降低；当等温时间为20 min时，试验钢的综合力学性能最佳，抗拉强度为732.25 MPa，断后伸长率为36%，强塑积为26.36 GPa·%；残余奥氏体的体积分数和碳含量先升高后降低，等温时间为20 min时试验钢表现出较强的加工硬化行为。     

热处理对TRIP 590钢微观组织及力学性能的影响

采用Gleeble3800热模拟机对TRIP钢拉伸试样进行不同工艺条件的快速热处理模拟实验,并采用金相分析、显微硬度测试等方法对试样进行组织观察和性能测试,目的是通过适宜的热处理工艺促使材料微观组织中出现适量的残余奥氏体组织,增强该材料在变形过程的相变诱导塑性(TRIP)效应,强化材料结果表明:在两相区内,TRIP钢中的残余奥氏体含量随着退火温度和退火时间的增加而增大,以25℃/s缓慢加热到700℃,再以150℃/s的速率快速加热到820℃保温120s后淬火处理,处理后的试样,残余奥氏体体积分数达到13％,显微硬度最高,达到262HV.     

Nb含量对TRIP钢组织和性能的影响

利用Gleeble-1500热模拟机对不同Nb含量的TRIP钢的热轧过程进行了热模拟实验.研究了Nb含量对TRIP钢组织和性能的影响.实验结果表明：Nb的加入使得实验钢的组织得到细化,贝氏体量增多;增加Nb含量,残余奥氏体量和残余奥氏体含碳量有所降低,宏观维氏硬度值增加;Nb的质量分数为0.014%时,残余奥氏体量为19.2%、残余奥氏体含碳量为1.422%、宏观维氏硬度为258HV和抗拉强度为851 MPa.     

冷轧TRIP590钢带的成分优化

 化学成分和热处理工艺是影响TRIP钢力学性能的关键因素。通过热模拟试验方法研究了不同成分试验钢在临界区退火过程中的微观组织变化规律。结果表明：随着两相区退火温度的升高,铁素体平均晶粒尺寸逐渐减小,铁素体体积分数随着加热温度的升高而降低;残余奥氏体量和其中的C质量分数先随着退火温度的升高而降低,达到一个低谷以后,再随退火温度的升高而升高;在相同的退火温度下,随着Nb的加入,多边形铁素体晶粒尺寸细化,铁素体体积分数逐渐减少;既加Nb又高Si的试验钢钢中残奥数量最多,不加Nb的试验钢中残奥数量最少。TRIP钢试制结果表明,钢带组织类型为典型的TRIP钢组织,多边形铁素体平均晶粒尺寸约8μm,体积分数67%,残余奥氏体体积分数为5.58%,残余奥氏体中C质量分数为1.34%,同时,力学性能也完全满足TRIP590的性能要求。     

连续退火的无Si TRIP钢的组织和力学性能

在实验室用Gleeble3500热模拟试验机制备了一种无Si TRIP钢.利用拉伸试验机、扫描电镜、透射电镜、X射线衍射以及热膨胀仪对其力学性能、微观组织和相变规律进行研究,在此基础上分析了贝氏体相变温度和时间对力学性能和残余奥氏体的影响.无Si TRIP钢呈现出良好的整体力学性能,抗拉强度分布在740~810 MPa,延伸率均在25%以上,最高可达32%以上;贝氏体等温温度为420℃时能获得最佳的综合力学性能,抗拉强度随贝氏体相变时间增加而下降,延伸率随之上升,而屈服强度没有显著变化.无Si TRIP制的铁素体晶粒大小约为3~4μm,比含Si TRIP钢铁素体晶粒细小;残余奥氏体的体积分数在8%~10%,比含Si TRIP钢低约3%;420℃保温300 s后贝氏体相变基本结束,而碳的扩散仍然在进行;无Si TRIP钢贝氏体相变速率比含Si TRIP钢快,贝氏体相变总量也更多.      

两相区退火温度对TRIP钢组织性能的影响

 针对600 MPa级别TRIP钢,进行了760、780、800、820、840、860 ℃两相区退火温度试验,利用扫描电镜和拉伸试验机等设备,分析了其对应的组织比例和力学性能检验结果,得出结论：随着两相区退火温度的升高,铁素体体积分数逐渐减少,钢板的抗拉强度值不断增加,但伸长率值却先下降再升高,在820 ℃伸长率有最大值,这与820 ℃时较高残余奥氏体体积分数和最大残奥中碳质量分数相对应,说明TRIP效应可以改善钢板的塑性指标,获得最佳强塑组合;在800～820 ℃的两相区转变温度范围内,强塑积可以达到2.17×104 MPa·%,为600 MPa级TRIP钢退火工艺提供了实际指导。     

Voices of fear and anxiety and sadness and depression: The effects of speech rate and loudness on fear and anxiety and sadness and depression.

Two studies investigated the role of expressive vocal behavior (specifically, speech rate and loudness) in fear and anxiety and in sadness and depression. In the 1st study, participants spoke about personally experienced fear and anxiety-arousing and neutral events using 3 different voice styles: fast and loud, normal, and slow and soft. In the 2nd study, participants spoke about personally experienced sad or depressing and neutral events using the same 3 voice styles. In both studies, the participants' highest levels of subjective affective and cardiovascular (CV) arousal occurred when they spoke about the emotional events in a mood-congruent voice style: fast and loud in the case of fear and anxiety, and slow and soft in the case of sadness or depression. Mood-incongruent voice styles canceled the heightened levels of CV arousal normally associated with these negative emotions. The voice-style manipulation had no significant effect on the participants' levels of CV arousal during the neutral discussions. (PsycINFO Database Record (c) 2010 APA, all rights reserved)     

Synthesis and analysis of mixed chlorinated-fluorinated dibenzo-p-dioxins and dibenzofurans and assessment of formation and occurrence of the fluorinated and chlorinated-fluorinated dibenzo-p-dioxins and dibenzofurans

Despite the use of multimodal therapy, higher-grade glioma is still uniformly fatal in the adult population. There is a considerable difference between the length of survival in each given patient, even within the same tumor type and malignancy grade group, suggesting that there are factors that might differentially influence outcome. To identify such factors, 107 patients with anaplastic or malignant glioma were retrospectively investigated. Clinical parameters and paraclinical data on the p53, mdm2, and EGFR genes at the DNA or protein level were evaluated by univariate analysis and Cox proportional hazards regression modeling. Kaplan-Meier survival estimation demonstrated that immunohistochemical positivity for mdm2 protein in patients with anaplastic astrocytoma or with glioblastoma multiforme was associated with a shorter survival time (p = 0.02). P53 gene mutations and immunopositivity for the epidermal growth factor receptor (EGFR) protein were not significantly related to poor prognosis. The Cox proportional hazards model revealed immunohistochemical positivity for p53, mdm2, or for both of them, the presence of postoperative irradiation, and the extent of surgical resection of tumor to be variables significantly associated with prolonged survival. EGFR overexpression, age over 60 years, and Karnofsky performance score below 40 points did not significantly shorten survival time. In conclusion, the present study identified immunohistochemically detected mdm2-protein overexpression as a statistically significant negative prognostic parameter in patients bearing anaplastic or malignant glioma. Association analysis of variables revealed a possible correlation between mdm2 and p53, which is also consistent with the biological interaction mode of both proteins in vivo.     

Sexuality and aging--usual and successful

BACKGROUND: As aging research increasingly reflects an effort to dissociate true time-driven changes from those that can be improved, sexuality in later life remains largely unexplored. Several problems are evident. There is a lack of normative data, a lack of a conceptual framework relating to the biology, psychology, and sociology of sex, and an attitudinal resistance that obscures the entire topic. METHODS: We conducted a three-part instructional series on major topics involved with sexuality and aging. We surveyed our group of attendees (n 158, average age 68 for males, 65 for females) before and after the series. RESULTS: A remarkably robust sex life was evidenced by both the men and the women, even until advanced old age. Yet, a substantially decreased involvement was reported from 10 years earlier. Despite current activities, people of both sexes wished they were participating even more than they currently were. Impotency was identified as the major negative feature for the men; relationship problems were for the women. A questionnaire 6 months after the series reported improved sexual attitudes, but no change in sexual activities from the earlier survey. CONCLUSION: Sexuality is a major quality-of-life issue which persists into old age. Our study showed that the usual sexual practices reported by our group were not considered by them to be ideal. The intervention of this instructional series provided improved sexual attitudes but not performance. Additional studies are encouraged.     

Spondylolysis and spondylolisthesis and sports

Spondylolysis and spondylolisthesis occur predominantly in the lower lumbar spine. Besides congenital defects such as predisposition of spondylolysis the correlation between competitive sports activities and an increased incidence of spondylolysis is proved. In early stages, complete healing can be achieved by conservative treatment (abstinence from sports activities for 3 months, orthesis). Persistence of pain, neurologic symptoms and progression of vertebral slipping are indications for operative treatment (reconstruction of the isthmus, dorso-ventral spondylodesis). The exercise tolerance depends on the extent of instability, progression of vertebral slipping and clinical symptoms. The limits of exercise tolerance vary among the individual athletes and require the decision of the physician. Backstroke swimming, abdominal and back muscle strengthening exercises, and types of sport involving smooth movements are advisable. Sports education in school is possible without restriction in patients with stable spondylolysis and in those with spondylolisthesis without unfavourable concomitant factors.     

Larks and owls and health, wealth, and wisdom

OBJECTIVE: To test the validity of Benjamin Franklin's maxim "early to bed and early to rise makes a man healthy, wealthy, and wise." DESIGN: Cross sectional analysis of sleeping patterns in a nationally representative group of elderly people, and longitudinal investigation of mortality. SETTING: Eight areas in Britain (five in England, two in Scotland, and one in Wales). SUBJECTS: 1229 men and women aged 65 and over who in 1973-4 had taken part in a survey funded by the Department of Health and Social Security and for whom data on sleeping patterns, health, socioeconomic circumstances, and cognitive function had been recorded. MAIN OUTCOME MEASURES: Self reported income, access to a car, standard of accommodation, performance on a test of cognitive function, state of health and mortality during 23 years of follow up. RESULTS: 356 people (29%) were defined as larks (to bed before 11 pm and up before 8 am) and 318 (26%) were defined as owls (to bed at or after 11 pm and up at or after 8 am). There was no indication that larks were richer than those with other sleeping patterns. On the contrary, owls had the largest mean income and were more likely to have access to a car. There was also no evidence that larks were superior to those with other sleeping patterns with regard to their cognitive performance or their state of health. Both larks and owls had a slightly reduced risk of death compared with the rest of the study sample, but this was accounted for by the fact that they spent less time in bed at night. In the study sample as a whole, longer periods of time in bed were associated with increased mortality. After adjustment for age, sex, the presence of illness, and other risk factors, people who spent 12 or more hours in bed had a relative risk of death of 1.7 (1.2 to 2.5) compared with those who were in bed for 9 hours. The lowest risk occurred in people who spent 8 hours in bed (adjusted relative risk 0.8; 0.7 to 1.0). CONCLUSION: These findings do not support Franklin's claim. A "late to bed and late to rise" lifestyle does not seem to lead to socioeconomic, cognitive, or health disadvantage, but a longer time spent in bed may be associated with increased mortality.     

IQ and ego-resiliency: Conceptual and empirical connections and separateness.

The constructs of intelligence and ego-resiliency are discussed. The personality implications of "pure intelligence" and "pure ego-resilience" were identified. Intelligence (IQ) was indexed by the Wechsler Adult Intelligence Scale-Revised (WAIS—R) and ego-resiliency by an inventory scale. Residual scores measuring "pure intelligence" and "pure ego-resilience" were correlated with the items of the observer based California Q-sort, used to describe participants. Persons relatively high on ego-resilience tend to be more competent and comfortable in the "fuzzier" interpersonal world; persons defined primarily by raw IQ tend to be effective in the "clearer" world of structured work but tend also to be uneasy with affect and less able to realize satisfying human connections. Gender differences exist in the relations of ego-resilience and intelligence and in their adaptive relevance. (PsycINFO Database Record (c) 2010 APA, all rights reserved)     

Conserving and retaining equalities and inequalities through observation and correction.

Investigated the effects of modeling and corrective feedback on the conservation of equalities and inequalities, with items spanning 3 stimulus dimensions (length, number, and 2-dimensional space). Ss were 48 kindergartners (24 boys, 24 girls). Brief observation of a model, briefer correction training (joining positive feedback with verbal rule provision), and the combination of observation and correction were all successful in producing learning and, without further training, transfer and retention of conservation. Unlike the controls (who also never correctly answered any equality items), the trained experimental Ss gave evidence of spontaneously generalizing their new learning to a task that required nonverbal behavior to manifest conservation. (17 ref) (PsycINFO Database Record (c) 2010 APA, all rights reserved)     

深云立交桥梁检测及加固改造

根据深云立交桥梁的检测结果，对该桥目前的整体状况、工作状态，及其使用情况做出综合评价，对桥的病害原因进行了分析，并提出合理的加固方案。     

关于摩尔浓度及其与硬度转换关系问题的讨论

众所周知，国际单位制物质的量采用摩尔(mol)表示，近几年出版的给排水专业书籍，为了与国际单位制接轨，逐渐将摩尔的使用频率不断提高，被给排水技术人员广泛应用的新版给排水设计手册，将表示物质浓度的单位“当量／升”或“毫克当量／升”．改为mol／l或mmol／l，虽然编者对其基本单元定义作了说明，但在实际运用上仍会出现误解，