Adsorption mechanism of polycarboxylate-based superplasticizer in CFBC ash-Portland cement paste

Circulating fluidized bed combustion （CFBC） ash exhibits the desirable pozzolanic activity which makes it a potential supplementary cementitious material to replace cement for concrete production. However, the high unburnt carbon content and porous surface structure of CFBC ash may adsorb water reducer and thereby significantly reduce the efficiency of water-reducing agents. The adsorption mechanism of polycarboxylate superplasticizer in CFBC ash-Portland cement paste was investigated by ultraviolet-visible spectrophotometer, and the conception of ＂invalid adsorption site＂ of CFBC ash was presented. The results show that the adsorption behavior of polycarboxylate superplasticizer in coal ash-Portland cement paste can be described by Langmuir isothermal adsorption equation. The adsorption capacity of CFBC ash-Portland cement paste is higher than that of pulverized coal combustion （PCC） fly ash-Portland cement paste. Moreover, the adsorption amount of polycarboxylate superplasticizer increases with the ratio of ash-to-cement in the paste. At last, the fluidity of CFBC ash-Portland cement paste is lower than that of the PCC fly ash paste. This work suggests that when CFBC ash is used as concrete admixture, the poor flowability of the cementitious system due to the high adsorption of water and water-reducing agent should be taken into consideration.     

Effect of Fly Ash on Rheological Properties of Cement Paste

This paper is aimed to study the factors influencing rheological properties of cement paste with fly ash,including the quantity of cement replaced by fly ash,types of the fly ash,degree of cement hydration and the microstructure of cement paste. By changing the water-cement ratio,mixing different amounts of fly ash,adding different types fly ash,the rheological parameters of cement paste are measured with a rheometer,and the needle penetration are tested by Vical needle. A ultrasound velocity test was aslo employed to monitor hydration of paste at early ages. Combinations of different factors on the rheological properties of cement paste are studied. The objective is to reveal the effect mechanism of material nature and proportion of each component on the rheological properties of cement paste with fly ash.     

高性能混凝土及不同配合比方案的应用研究

高性能混凝土的研究与应用,对于高面板坝工程混凝土面板的防裂具有重要意义.在原材料中合理掺入外加剂、粉煤灰、有机纤维等配料是获得高性能混凝土的重要途径.根据具体的工程情况,可采用不同的配合比方案,如外加剂+粉煤灰+有机纤维"多掺"方案、联掺或单掺高效减水剂+引气剂方案等.配制高性能混凝土,应尽量选择高标号的硅酸盐水泥或普通硅酸盐水泥,并应根据水泥中活性混合材料的类型及含量,合理确定粉煤灰的最佳掺量.实践证明,通过优化混凝土配合比,可减少甚至避免混凝土面板裂缝的产生.     

养护制度对粉煤灰复合水泥浆体干燥收缩及孔径分布的影响

将水泥试件在水中养护6天和13天后放入干燥养护箱中,测定其质量损失和干燥收缩。采用氮吸附方法测定不同龄期时的孔径分布。结果表明:粉煤灰复合水泥浆体,干燥收缩早期变化较为明显,随着龄期延长,变化逐渐变缓;水养时间延长,干燥收缩减小;不同水养时间养护后,粉煤灰复合水泥浆体4-40nm孔径体积含量减小,相应干燥收缩减小。     

Effect of competitive adsorption between sodium tripolyphosphate and naphthalene superplasticizer on fluidity of cement paste

The adsorption amount, ζ-potential of cement particles and fluidity of cement paste were tested to research the competitive adsorption between naphthalene superplasticizer(FDN) and STPP. The experimental results showed that the presence of STPP could significantly improve the fluidity of cement paste and reduce the fluidity loss with FDN. There existed a competitive adsorption between STPP and FDN. STPP and calcium ions formed complexes; they preferentially adsorbed onto surface of cement particles and preempt adsorption points of FDN; and it reduced adsorption amount of FDN. In the absence of STPP, saturation adsorption amount of FDN was 5.93 mg/g; but when the dosage of STPP was 0.1%, it reduced to 4.3 mg/g(about 72.5%). The adsorption amount of FDN was reduced by STPP, but ζ-potential of cement particles enhanced and fluidity of cement paste increased because of strong negative charge effect of the complexes. Adsorption of the complexes would delay Ca2+ into liquid and inhibit formation of active adsorption points. Then, content of FDN in liquid increased with the addition of STPP and ζ-potential of cement particles became stable. In this way, fluidity loss of cement paste reduced.     

磺化淀粉-聚羧酸复合减水剂的制备与表征

由于保护环境的原因,以天然高分子为原料来合成高效减水剂已经成为混凝土外加剂研究领域的新热点.本文研究了采用磺化糊精取代部分功能大单体来合成复合聚羧酸减水剂的方法.结果显示:当磺化糊精取代功能单体40%、复合聚羧酸减水剂掺量为0.5%时,水泥净浆的初始流动度达255,mm,1,h 后其流动度仍为250,mm.淀粉酸解后,增加亲水的羟基基团导致初期水化缓慢,而增加 Zeta 电位使水泥颗粒更易于分散.在复合减水剂中,长链 Starch 与短链的聚羧酸减水剂主链将被吸附于水泥颗粒表面上,交替发生静电与空间位阻作用,起到了增加减水率和降低缓凝的效果.     

不同黏土对掺减水剂水泥净浆流动度影响

目的 研究4种不同黏土对掺聚羧酸减水剂及萘系减水剂水泥净浆流动度的影响规律并从黏土的吸附性能角度探究其影响机理.方法 采用水泥净浆流动度试验方法比较了4种黏土对掺聚羧酸减水剂水泥净浆流动度的影响,通过TOC总有机碳测试仪测定了4种黏土对聚羧酸减水剂的吸附量.结果 4种黏土对水泥净浆流动度的影响差异较大,其中钙基蒙脱土和钠基蒙脱土的掺量为2％时,掺聚羧酸减水剂水泥净浆已基本没有流动度,掺萘系减水剂的水泥净浆流动度也有所下降,但降幅稍小,而伊利土和高岭土对掺减水剂水泥净浆流动度无明显负面影响;钙基蒙脱土和钠基蒙脱土对聚羧酸减水剂的吸附量较大,伊利土、高岭土对聚羧酸减水剂的吸附能力和水泥相当.结论蒙脱土对掺聚羧酸减水剂水泥净浆流动度负面影响极为严重,而伊利土和高岭土对掺减水剂水泥净浆基本没有负面影响.     

聚羧酸超塑化剂的性能研究

研究了含有亲水性羧基、酸酐基团、磺酸基、聚环氧乙烷侧链的三种羧酸类共聚物对水泥浆体流变性能和水泥粒子表面Zeta电位的影响，并与萘系高效减水剂进行了对比．在改善水泥浆体的流变性能方面，三种聚羧酸超塑化剂的最佳掺量和饱和掺量均为0．3％～0．45％；对水泥粒子表面Zeta电位的影响方面聚羧酸超塑化剂远小于萘系高效减水剂，证实了两类减水剂的分散作用机理的区别．[编者按]     

粉煤灰复合水泥对改善混凝土性能的试验研究

复合水泥对混凝土性能的影响，尤其是耐久性能的影响，一直是人们普遍关心的问题．通过混凝土抗压强度试验和混凝土耐久性加速试验，对以粉煤灰作为主要混合材的复合水泥配制的混凝土的综合性能进行了研究．研究表明，复合水泥基混凝土3d，28d强度大于粉煤灰混凝土，和同强度等级的普通硅酸盐水泥基混凝土较为接近，而抗氯离子渗透性能则明显优于普通水泥基混凝土和粉煤灰混凝土．用粉煤灰作为主要混合材的高性能复合水泥来配制混凝土，是改善混凝土综合性能的非常有效的方法．     

粉煤灰与矿粉改进减水剂与水泥相容性的研究

采用萘系、聚羧酸系减水剂与粉煤灰、矿粉双掺法,进行水泥流动性的试验,测定净浆流动度损失,研究粉煤灰、矿粉对减水剂与水泥相容性影响,研究发现,粉煤灰、矿粉能有效改进萘系、聚羧酸系减水剂与水泥的相容性;而聚羧酸系减水剂与水泥的相容性比萘系减水剂好．     

水泥沥青浆体中减水剂与乳化沥青的竞争吸附行为

为揭示水泥沥青砂浆(CA砂浆)中水泥对乳化沥青和减水剂的吸附规律,采用微量热仪分析了减水剂、乳化沥青(单掺及同掺)对水泥水化诱导期的延迟作用.采用"固含法"研究了减水剂种类对水泥-乳化沥青经时吸附规律的影响,以及减水剂在不同添加顺序时对水泥-乳化沥青经时吸附规律的影响.采用偏光显微镜对减水剂作用下水泥-乳化沥青的吸附行为进行了原位观测.结果表明:CA砂浆中的乳化沥青和减水剂均能显著延迟水泥的水化诱导期,两者同掺使延迟作用产生了明显的协同效应;聚羧酸减水剂与乳化沥青对水泥的吸附作用存在明显的竞争关系,两者同掺时水泥优先吸附减水剂分子,减水剂耗尽后,水泥再吸附乳化沥青.减水剂后掺时可使部分吸附的乳化沥青发生解吸附.     

粉煤灰复合水泥浆体干燥收缩与孔结构关系的研究

采用氮吸附法研究了不同掺量粉煤灰对水泥浆体孔结构的影响,分析了干燥收缩与孔径分布、孔隙率、比表面积的关系。结果表明:粉煤灰的掺入使复合水泥浆体孔隙率、比表面积增加,细化样品孔结构的同时使较小毛细孔的比例减小,从而一定程度抑制了干燥收缩。     

INITIAL BINDING CAPACTIES OF CHLORIDE ION OF COMPONENTS IN HIGH-PERFORMANCE CONCRETE

An investigation is reported on the influence of different components of high performance concrete (HPC) on the initial binding capacities (IBC) of chloride ion. The testing results demonstrate that cement has the largest IBC, and the relative binding ratio is as high as 30% of total ion amount. Among the mineral admixtures, fly ash has the largest IBC of chloride ion. The IBC of silica fume is about 14.4% ,which is smaller than that of fly ash. The IBC of refined ground blast-furnace slag (microslag) is abnormal due to the influence of sulfate ion contained. The addition of superplasticizer and corrosion inhibitor containing calcium nitrite weakens the IBC of mixtures. The fluidity and pore-filling effect of mineral admixtures are studied with paste samples with W/C ratio of 0.3. The influence mechanism of various components in high-performance concrete in IBC is studied further through SEM and Mercury Instrusion Porosimetry tests with paste samples at the age of 3 days.     

固硫渣混合水泥的研究及钙矾石相的定量分析

通过试验系统地研究了固硫渣混合水泥的配制方法及其性能的测试结果，论述了硬化水泥浆体中钙矾石相的定量分析方法．通过对不同龄期固硫渣水泥硬化浆体中钙矾石相的定量分析，总结了钙矾石相形成量随龄期变化的趋势．为推广使用固硫渣混合水泥和制订出相应的规范提供了理论依据．     

Effect of fly ash and early strength agent on durability of concrete exposed to the cyclic sulfate environment

The effect of fly ash and early strength agent on resistance of concrete to the cyclic sulfate environment was studied. Concrete specimens made with ordinary portland cement or ordinary portland cement incorporating fly ash with the replacement of 10% or 20%, or 1% early strength agent and fly ash with the replacement of 20%, were made and subjected to 250 cycles of exposure to the cyclic sulfate environment. Concrete properties including loss of mass, chloride ion diffusion coefficient, compressive strength and flexural strength were measured. Microstructure and chemical component of samples were determined by means of X-ray diffraction, scanning electron microscopy and energy dispersive spectroscopy. The experimental results indicated that effect of fly ash on the cyclic sulfate resistance of concretes was mostly dependent on the amount of fly ash. Early strength agent improved performances of concrete with 20% fly ash exposed to cyclic sulfate environment.     

硅酸盐水泥导电性能的研究

通过一系列实验对影响普通水泥和粉煤灰水泥导电性能的主要因素进行了探讨。结果表明:在相同条件下,粉煤灰水泥的导电性能优于普通水泥,。在水泥中掺入一定量的石墨和金属可显著提高其导电性能。所得结果具有一定的实用意义.     

Rheological properties of self-compacting concrete paste containing chemical admixtures

Self-compacting concrete (SCC) was used for the filling layer of CRTSIII plate ballastless track, which needs excellent workability. The rheological properties of SCC cement paste containing chemical admixtures (CA) such as polycarboxylate-based superplasticizer (PCE), air-entraining agent (AE) and defoamer (DF) were investigated using a Brookfield R/S SST2000 soft solid tester with a vane geometry spindle. The cementitious materials were designed as one, two and, three components systems by addition of ordinary portland cement (OPC) with these chemical admixtures. The rheological properties of one-component system (PCE paste) were improved with increasing the content of PCE. For two components systems of PCE-AE and PCE-DF, yield stress and plastic viscosity reduced firstly and increased afterward with the increasing of AE content. And the plastic viscosity reached the optimum when the content of AE is 0.004wt%. In general, the trend of yield stress and plastic viscosity decreased with the increasing of the DF content. For three components systems, PCE-AE-DF systems, the rheological properties were improved compared with the sample with AE or DF, which attributed to mixes of the active components mentioned above (CA) which could have a synergetic effect.     

外掺材料对多孔水泥混凝土胶浆强度的影响研究

文章采用超细粉煤灰与硅灰的复合技术配制多孔水泥混凝土水泥浆体试件.通过与双掺硅灰和减水剂、双掺粉煤灰和减水剂以及复合掺粉煤灰、硅灰和减水剂的情况对比,系统研究了硅灰粉煤灰作为外掺挤对多孔水泥混凝土水泥浆体的强度的影响.实验结果表明,由于硅灰与超细粉煤灰的复合,在水泥浆体形成过程中,这2种材料充分发挥了各自的功能效应,使得多孔水泥混凝土水泥浆体的强度性能显著提高.文章通过扫描电镜试验,剖析了超细粉煤灰与硅灰复合效应的机理,论证了用超细粉煤灰和硅灰以及减水剂复合配制多孔水泥混凝土水泥浆体的可行性.     

低需水的新拌水泥浆体流变性研究

在对水泥浆体流变模型和流变性能影响因素分析的基础上，研究了外加剂掺量、SO3含量、矿渣掺量等对新拌水泥浆流变性能的影响。用旋转粘度计对新拌水泥浆进行了动态检测，低需水量水泥的新拌水泥浆具有良好的流变性能，同时它的流变模型符合宾汉姆流变模型。     

复合浆体中粉煤灰和水泥水化反应程度的测定

采用盐酸选择溶解法测定粉煤灰的水化程度,再结合水化热法计算复合浆体中水泥的水化程度。试样结果表明,在水化早期粉煤灰仅作为惰性材料填充于复合浆体的孔隙中。随着粉煤灰掺量的增大,水泥的水化程度越高,单位体积中水化产物的总体数量仍为减少。