Incidence of aflatoxin B1 in the Egyptian cured meat basterma and control by gamma-irradiation

In the present studies trials have been carried out to investigate the occurrence of aflatoxin B1 in the Egyptian cured meat basterma and to control such contamination by gamma-rays. Basterma was prepared from fresh salted meat coated with spice paste and stored at room temperature. The total mould counts of basterma samples varied from 10(3) to 10(6) cfu/g in summer months and from 10(2) to 10(5) cfu/g in winter months. Aspergillus, Penicillium, Mucor, Rhizopus, Fusarium and Cladosporium were the most common fungal genera isolated from basterma samples and its components. Basterma samples contained total aflatoxins at levels from 2.8 to 47 microg x kg(-1). Aflatoxins were determined in the spice paste at levels from 9.6 to 120 microg x kg(-1) and in pepper (285.6 microg x kg(-1)), garlic (224.4 microg x kg(-1)), fenugreek (194.2 microg x kg(-1)), coriander (16 and capsicum (42.4 microg x kg(-1)). At an irradiation dose level of 3 kGy, only one sample each of pepper, fenugreek, and spice paste were contaminated with aflatoxins and all basterma samples and its components were free from aflatoxins at an irradiation dose level of 5 kGy.     

Shelf‐life extension of vacuum‐packaged sea bream (Sparus aurata) fillets by combined γ‐irradiation and refrigeration: microbiological,chemical and sensory changes

The combined effect of γ‐irradiation and refrigeration on the shelf‐life of vacuum‐packaged sea bream (Sparus aurata) fillets was studied by monitoring the microbiological, chemical and sensory changes of non‐irradiated and irradiated fish samples using low‐dose irradiation doses of 1 and 3 kGy. Fish species such as sea bream and sea bass are very popular in the Mediterranean countries due to their high quality characteristics, and their preservation is a constant challenge given their extreme perishability. Irradiation (3 kGy) dramatically reduced populations of bacteria, namely, total viable counts (3 vs 7 log cfu g^?1) for the non‐irradiated samples, Pseudomonas spp (<2 vs 7.6 log cfu g^?1), H₂S‐producing bacteria typical of Shewanella putrefaciens (<2 vs 5.9 log cfu g^?1), Enterobacteriaceae (<2 vs 6.0 log cfu g^?1) and lactic acid bacteria (<2 vs 3.5 log cfu g^?1) after 10 days of storage. The effect was more pronounced at the higher dose (3 kGy). Lactic acid bacteria, Enterobacteriaceae and H₂S‐producing bacteria typical of Shewanella putrefaciens showed higher sensitivity to γ‐radiation than did the rest of the microbial species. Of the chemical indicators of spoilage, Trimethylamine (TMA) values of non‐irradiated sea bream increased very slowly, whereas for irradiated samples significantly lower values were obtained reaching a final value of 7.9 and 6.3 mg N per 100 g muscle at 1 and 3 kGy respectively (day 42). Total volatile basic nitrogen (TVB‐N) values increased slowly attaining a value of 67.3 mg N per 100 g for non‐irradiated sea bream during refrigerated storage, whereas for irradiated fish, lower values of 52.8 and 43.1 mg N per 100 g muscle were recorded (day 42). Thiobarbituric acid (TBA) values for irradiated sea bream samples were higher than respective non‐irradiated fish and increased slowly until day 21 of storage, reaching final values of 1.1 (non‐irradiated), 2.0 (1 kGy) and 2.2 mg malonaldehyde kg^?1 muscle (3 kGy), respectively (day 42). Sensory evaluation showed a good correlation with bacterial populations. On the basis of overall acceptability scores (sensory evaluation) a shelf‐life of 28 days (3 kGy) was obtained for vacuum‐packaged sea bream, compared with a shelf‐life of 9–10 days for the non‐irradiated sample. Copyright © 2004 Society of Chemical Industry     

Gamma irradiation as a means to eliminate Listeria monocytogenes from frozen chicken meat

Cells of Listeria monocytogenes ATCC 35152 were sensitive to gamma irradiation in phosphate buffer, pH 7.00 (D₁₀, dose required for 10% survival—0.15 kGy) at 0–5°C. The cells showed higher radiation survival when irradiated under frozen condition, with a D₁₀ of 0.3 kGy. The protection offered by shrimp/chicken/kheema homogenates (100 g litre^?1) was evidenced by even higher D₁₀ values (0.5 kGy) at both 0–5°C and cryogenic temperature. Boneless chicken meat samples were artificially inoculated with L monocytogenes ATCC 35152 cells at low (5 × 10³) colony-forming unit (cfu) g^?1 and high (5 × 10⁶ cfu g^?1) concentrations and irradiated at 1, 3, 4, 6 kGy doses under cryogenic conditions. The efficacy of the radiation process was evaluated by detecting L monocytogenes during storage at 2–4°C in the irradiated samples. These studies, when repeated with three other serotypes of L monocytogenes, clearly suggested the need for a dose of 3 kGy for elimination of 10³ cfu cells of L monocytogenes g^?1 from air-packed frozen chicken meat.     

Reduction of ochratoxin A in dry-cured meat products using gamma-irradiation

This study investigated the efficiency of gamma (γ)-irradiation in the reduction of ochratoxin A (OTA) present in dry-cured meat products prepared from intentionally contaminated raw materials from OTA-treated pigs. OTA concentrations determined in the samples (n = 24) ranged from 25.8 μg kg^–1 in bacon to 17.8 μg kg^–1 in smoked ham. After γ-irradiation at doses of 3, 7 and 10 kGy (i.e. the doses used in the food industry), a dose-depended OTA reduction was observed; however, it was not statistically significant. The mean OTA reduction achieved with 3-, 7- and 10-kGy γ-doses was approximated to 8.5%, 13.9% and 22.5%, respectively. The storage of irradiated samples (1 month, 4°C) did not significantly affect OTA levels. Based on the correlation between the OTA reduction level and basic chemical composition of dry-cured meat samples, OTA reduction may be linked to the samples’ fat content. The results indicate that γ-irradiation can reduce OTA levels in dry-cured meat products, but only to a limited extent due to the complexity of the matrix.     

Ochratoxin A in red pepper flakes commercialised in Turkey

The aim of this study was to investigate the presence of Ochratoxin A (OTA) in red pepper flakes commercialised in Turkey. A total of 75 samples were collected from different supermarkets and traditional bazaars in Istanbul during 2012–2013. OTA analysis was performed by high-performance liquid chromatography equipped with fluorescence detection after immunoaffinity column clean-up. The method was linear in the range 0.05–40 μg kg^?1 (r² = 0.9997). Twenty-seven out of 31 (87.1%) packed red pepper flake samples contained OTA at concentrations ranging from 0.6 to 1.0 μg kg^?1, whereas 100% of the unpacked red pepper flake samples contained OTA, in the range 1.1–31.7 μg kg^?1. Overall, only 4 unpacked samples (5.3%) contained OTA, with a mean value of 23.4 μg kg^?1, which is higher than the European Union limit. It is suggested that OTA content should be carefully considered in red pepper flake samples especially marketed in unpacked form.     

Simple determination of formaldehyde in fermented foods by HS‐SPME‐GC/MS

We describe an automatic method to detect formaldehyde (FA) in some fermented foods. This method is based on derivatisation with 2,2,2‐trifluoroethylhydrazine (TFEH) and consecutive headspace solid‐phase micro‐extraction and gas chromatography‐mass spectrometry. FA in food reacted for 30 min at 40 °C with 2,2,2‐TFEH in a headspace vial, and the formed FA‐TFEH derivative was simultaneously vaporised and adsorbed on 85‐μm carboxen–polydimethylsiloxane. Under the established condition, the limit of detection was 0.1 μg kg^?1 by using 1.0‐g solid food and 1.0‐mL liquid food, and the relative standard deviation was less than 10% at FA concentrations between 0.050 and 0.500 mg kg^?1. The concentrations of FA in several traditional Korean foods including gimchi, watery radish gimchi, soybean paste, red pepper paste, soy sauce and bean‐paste soup were measured. All food samples had detectable levels of FA (0.104–13.05 mg kg^?1).     

Aflatoxins in composite spices collected from local markets of Karachi,Pakistan

This survey was carried out to evaluate the occurrence of total aflatoxins (AFs; B₁+B₂+G₁+G₂) in unpacked composite spices. A total of 75 samples of composite spices such as biryani, karhai, tikka, nihari and korma masalas were collected from local markets of Karachi, Pakistan, and analysed using HPLC technique. The results indicated that AFs were detected in 77% (n = 58) samples ranging from 0.68 to 25.74 µg kg^?1 with a mean of 4.63 ± 0.95 µg kg^?1. In 88% (n = 66) samples, AFs level was below the maximum limits (ML = 10 µg kg^?1) as imposed by EU. Furthermore, 61% (n = 46) tested samples contained AFs level between 1 and 10 µg kg^?1, 9% (n = 7) exhibited AFs contamination ranged 10?20 µg kg^?1 and only 3% (n = 2) of the investigated samples contained AFs levels higher than the ML of 20 µg kg^?1 for total aflatoxins as set by the USA. It was concluded that there is need to establish a strict and continuous national monitoring plan to improve safety and quality of spices in Pakistan.     

Antimicrobial Effects of Nisin,Essential Oil,and γ‐Irradiation Treatments against High Load of Salmonella typhimurium on Mini‐carrots

This study aimed at using essential oil (EO) alone or combined EO with nisin and γ‐irradiation to control Salmonella Typhimurium during the refrigerated storage of mini‐carrots. Peeled mini‐carrots were inoculated with S. Typhimurium at a final concentration of approximately 7 log CFU/g. Inoculated samples were coated by 5 different coating solutions: (i) nisin solution at final concentration of 10³ IU/mL; (ii) mountain savory EO solution at 0.35%; (iii) carvacrol solution at 0.35%; (iv) mountain savory EO at 0.35% plus nisin solution of 10³ IU/mL; or (v) carvacrol at 0.35% plus nisin solution of 10³ IU/mL. Coated mini‐carrots were then irradiated at 0.5 or 1.0 kGy and compared to an unirradiated control sample. Samples were kept at 4 °C and microbial analyses were conducted at days 1, 3, 6, and 9. The results showed that mini‐carrots coated by carvacrol plus nisin solution or mountain savory EO plus nisin solution in combination with irradiation at 1.0 kGy completely eliminated S. Typhimurium to under the detection limit during the storage. Thus, the combined treatments using carvacrol plus nisin or mountain savory EO plus nisin coating solution and irradiation at 1.0 kGy could be used as an effective method for controlling S. Typhimurium in mini‐carrots.     

Vitamin E levels,thiobarbituric acid test and sensory evaluation of breast muscles from broilers fed α‐tocopheryl acetate‐ and β‐carotene‐supplemented diets

The objective of this study was to investigate the effect of dietary α‐tocopheryl acetate and β‐carotene supplementation on lipid oxidation of breast meat from broilers fed lard as the fat source. Supplementation of broilers with 100 mg kg^?1 α‐tocopheryl acetate increased the vitamin E levels in raw breast samples significantly (p < 0.05), whereas the presence of 1.5 mg kg^?1 dietary β‐carotene tended to decrease vitamin E deposition. The presence of vitamin E delayed lipid oxidation significantly, but thiobarbituric acid values of samples from broilers fed the β‐carotene‐supplemented diet did not differ from those of control samples. Vitamin E reduced sensory meat rancidity, whilst vitamin E, β‐carotene and their combination modified meat texture. The results show the effectiveness of dietary α‐tocopheryl acetate supplementation in protecting broiler meat against lipid oxidation. Copyright © 2004 Society of Chemical Industry     

Aflatoxin evaluation in ready-to-eat brazil nuts using reversed-phase liquid chromatography and post-column derivatisation

A high-performance liquid chromatography-fluorescence (HPLC-FD) method for aflatoxin quantification in brazil nuts was developed. Samples of brazil nuts collected in Brazilian markets were extracted with methanol:water and cleaned using an immunoaffinity column. Aflatoxins were eluted with methanol and a post-column derivatisation was performed with bromine, using a Kobra Cell system. The optimised method for total aflatoxins was sensitive, with detection and quantification limits of 0.05 and 0.25 µg kg^–1, respectively. The method was accurate, with recovery values of 87.6%; 85.3% and 85.0% for 0.5, 5.0 and 14.6 µg kg^–1 spiked levels, respectively. It was shown that the method was applicable to brazil nuts. From a total of 95 brazil nut samples analysed from 21 São Paulo supermarket samples and 51 Manaus and 23 Belém street markets samples, 37.9% showed detectable levels of aflatoxins and three exceeded the recommended Codex Alimentarius limit of 10 µg kg^–1 for ready-to-eat brazil nuts.     

Determination of flonicamid and its metabolites in bell pepper using ultra-high-performance liquid chromatography coupled to high-resolution mass spectrometry (Orbitrap)

The development and validation of a method to determine flonicamid and its metabolites as TFNA (4-trifluoromethylnicotinic acid), TFNG (N-(4-trifluoromethylnicotinoyl) glycine) and TFNA-AM (4-trifluoromethylnicotinamide) in bell pepper samples by ultra-high-performance liquid chromatography coupled to Orbitrap mass spectrometry (UHPLC-Orbitrap-MS) was performed. A fast and simple extraction procedure with acidified acetonitrile and salts (magnesium sulfate and sodium chloride) was used. The methodology was validated, checking for specificity, recovery, precision, limits of detection (LODs) and limits of quantification (LOQs). The recoveries ranged from 84% to 98%, and precisions were lower than 17%. Finally, LODs ranged from 1 µg kg^–1 (flonicamid) to 6 µg kg^–1 (TFNA-AM), while LOQs ranged from 10 µg kg^–1 (flonicamid) to 30 µg kg^–1 (TFNA-AM). Bell pepper samples were analysed and concentrations up to 98 µg kg^–1 (flonicamid) were detected, although the sum of flonicamid and metabolites did not exceed the maximum residue limit (MRL) set by the European Union.     

RADIATION STERILIZATION OF RED CHILI PEPPER (CAPSICUM FRUTESCENS)

The effect of radapertization using ⁶⁰Co gamma radiation on the chemical and organoleptic properties of ground and whole dry pungent red pepper has been investigated. The fungal population was eliminated with a dose of 7.5 kGy and a dose of 10 kGy was required to radapertize the samples. Irradiation up to 10 kGy did not produce any significant (P > 0.05) changes in the contents of capsaicin and carbohydrate. Oleoresin content was significantly (P < 0.05) increased from 24.45 to 31.61% and lipid from 16.80 to 19.30%. The observed effect on apparent oleoresin and lipid contents was due to enhanced extractability. Storage time had no effect on the sensory properties of the spice but rather enhanced microbial load reduction in the medium dose (5.0 and 7.5 kGy) treated samples. A dose of 10 kGy has been certified to pose no health hazard to humans; hence decontamination of red pepper with up to 10 kGy gamma radiation does not require any further toxicological study and is therefore recommended.     

Aflatoxins in animal feed in Iran

One hundred and forty-six samples of animal feed (barley, n = 60; wheat bran, n = 22; wheat dry pulp, n = 29; and canola meal, n = 35) were collected in 2011 from Mashhad (Khorasan, Iran). Aflatoxins (AFs) were determined in these samples after immunoaffinity column clean-up by high-performance liquid chromatography (HPLC) with fluorescence detection. Aflatoxin B₁ (AFB₁) contamination was found in 28 samples: in five of the barley samples (8.3%) at a mean level of 0.48 µg·kg^?1, in two wheat bran samples (9.0%) at a mean level of 0.88 µg·kg^?1, in 10 wheat dry pulp samples (34.5%) at a mean level of 0.30 µg·kg^?1 and in 11 canola meal samples (31.4%) at a mean level of 0.92 µg·kg^?1. AFB₁ levels were below the maximum levels of Iran regulations (5 µg·kg^?1) and the EU maximum limit (5 µg·kg^?1).     

Co-occurrence of aflatoxins,ochratoxin A and citrinin in “egusi” melon (Colocynthis citrullus L.) seeds consumed in Ireland and the United Kingdom

The natural co-occurrence of aflatoxins (AFs), ochratoxin A (OTA) and citrinin (CIT) in melon seed samples obtained from retailers and households in Ireland and the United Kingdom (UK) was evaluated. AFs and OTA were determined by HPLC with fluorescence detection while CIT was analysed by HPLC-MS/MS. AFB₁ was detected in all (100%) samples (mean = 9.7 μg kg^?1; range = 0.2–66.5 μg kg^?1). Mean total AFs was 12.0 μg kg^?1 (range = 0.3–82 μg kg^?1). Commercially retailed samples showed a significantly higher AFB₁ contamination (p < 0.05) than the household samples. OTA occurred in 3 (13.6%) samples, while 4 (18.2%) were contaminated with CIT at very low levels. In this study, 68% of the melon seed samples were contaminated above the 2 μg kg^?1 EU limit for AFB₁ in oilseeds. These results highlight the need for the development of strategies to reduce AF contamination in “egusi” for human consumption.     

Aflatoxins and ochratoxin A in export quality raisins collected from different areas of Pakistan

During 2012–2014, 170 samples of export quality raisins were collected from different vendors in Pakistan. The collected samples were analysed for the presence of aflatoxins (AFs) and Ochratoxin A (OTA) contamination using high-performance liquid chromatography technique. The limit of detection and limit of quantification of AFs/OTA were 0.12/0.10 and 0.36/0.30 µg kg^?1, respectively. Only 5% of the samples were contaminated with AFs, ranging 0.15–2.58 µg kg^?1 with a mean of 0.05 ± 0.26 µg kg^?1. None of the raisin samples exhibited AFs contamination above the maximum limit (ML = 4 µg kg^?1) as set by the European Union (EU). About 72% of the samples were contaminated with OTA, ranging 0.14–12.75 µg kg^?1 with a mean of 2.10 ± 1.9 µg kg^?1. However, in 95.3% of the tested samples, OTA level was lower than the ML of 10 µg kg^?1 as regulated by the EU. Apparently, a strict and continuous monitoring plan, including regulatory limits, improves food safety and quality for all types of commodities.     

Household dietary exposure to aflatoxins from maize and maize products in Kenya

Aflatoxicosis has repeatedly affected Kenyans, particularly in the eastern region, due to consumption of contaminated maize. However, save for the cases of acute toxicity, the levels of sub-lethal exposure have not been adequately assessed. It is believed that this type of exposure does exist even during the seasons when acute toxicity does not occur. This study, therefore, was designed to assess the exposure of households to aflatoxins through consumption of maize and maize products. Twenty samples each of maize kernels, muthokoi and maize meal were randomly sampled from households in Kibwezi District of Makueni County in Eastern Kenya and analysed for aflatoxin contamination. The samples were quantitatively analysed for aflatoxin contamination using HPLC. The uncertainty and variability in dietary exposure was quantitatively modelled in Ms Excel using Monte Carlo simulation in @Risk software. Aflatoxins were found in 45% of maize kernels at between 18 and 480 μg kg^–1, 20% of muthokoi at between 12 and 123 μg kg^–1, and 35% of maize meal at between 6 and 30 μg kg^–1. The mean dietary exposure to aflatoxin in maize kernels was 292 ± 1567 ng kg^?1 body weight day^?1, while the mean dietary exposure to aflatoxin in maize meal and muthokoi were 59 ± 62 and 27 ± 154 ng kg^?1 body weight day^?1 respectively. The results showed that the amount and frequency of consumption of the three foods is the more important contributing factor than the mean aflatoxin concentration levels, to the risk of dietary exposure to aflatoxins.     

Effects of γ-irradiation on the flavour of dry shiitake (lentinus edodes sing)

Dry shiitake (Lentinus edodes Sing) was irradiated with doses of 5 and 10 kGy using ⁶⁰Co. The total volatile compounds were decreased by more than 50%. Irradiation increased the concentrations of some minor volatile compounds, such as 3-methyl-2-butanol and I-hexanol. However, the major flavour compounds including eight-carbon and sulphur-containing compounds were significantly reduced. The ratio of the eight-carbon compounds, such as 3-octanone, 3-octanol and 1-octen-3-ol, to total volatiles decreased from 72% in the control to 21% in the 10 kGy irradiated samples. The unidentified compounds which may have been formed by decomposition or polymerization following irradiation of precursors need to be studied in greater depth.     

Effects of electron beam irradiation on microbial inactivation and quality of kimchi paste during storage

The effects of electron beam irradiation on microbial inactivation and quality of noninoculated and inoculated (Listeria monocytogenes) kimchi pastes were examined. Kimchi paste samples were irradiated at doses of 2, 4, 6, 8 and 10 kGy and stored for 21 days at 4 °C. Irradiation (10 kGy) reduced the populations of total aerobic bacteria, lactic acid bacteria, and yeast and moulds in the samples by 1.72, 2.24 and 0.86 log CFU g^?1, respectively, compared to the control. In particular, coliforms were not detected at 8 and 10 kGy, and the population of L. monocytogenes in inoculated samples was significantly decreased by 2.67 log CFU g^?1. Electron beam irradiation delayed the changes in O₂ and CO₂ concentrations, pH, acidity and reducing sugar content observed in kimchi paste during storage. These results suggest that electron beam irradiation can be used to improve the microbiological safety and shelf life of kimchi paste.     

Influence of gamma irradiation on growth and survival of Escherichia coli O157:H7 and quality of cig kofte, a traditional raw meat product

Cig kofte is a traditional Turkish food containing raw ground meat. Samples inoculated with Escherichia coli O157:H7 were irradiated at 0.5–6 kGy with a ⁶⁰Co source and stored at 4 and 25 °C. Total aerobic mesophilic count decreased with increasing irradiation doses, D₁₀ value was 0.83 kGy. Escherichia coli O157:H7 count decreased from 5.1 log₁₀ CFU g^?1 to an undetectable level (<1 log₁₀ CFU g^?1) after 1‐day storage at 4 °C following irradiation at 2 kGy, D₁₀‐value was 0.29 kGy. Irradiation doses up to 2 kGy did not affect sensory quality after 1 day. There was colour loss in samples irradiated at 2 kGy or above and stored for longer periods. Storage of the irradiated products at abused temperature must be avoided for safety assurance. Irradiation at 2 kGy has a great potential for extending the shelf‐life of cig kofte and assuring safety by decreasing the number of E. coli O157:H7 and other bacteria, but further studies with suitable package designs are needed to decrease quality degradation during extended storage.     

Control of Yersinia enterocolitica in raw pork and pork products by γ-irradiation

γ-Radiation response of Y. enterocolitica 5692 and 152 was studied at 0°C and at −40°C in phosphate buffer (pH 7.00) as well as in 10% raw meat/salami homogenate. The strains investigated did not differ in their response and were found to be sensitive to γ-radiation but exhibited a tailing phenomenon in the survival curve. The D₁₀ in homogenate was 0.25 kGy at 0°C. This response was not affected at −40°C. Storage studies of packs, inoculated artificially with heavy inoculum of Y. enterocolitica (10⁶ cfu/g) showed that while samples of salami and cooked ham could be decontaminated at doses of 4 and 3 kGy respectively; cells could not be eliminated from raw pork meat even at the higher dose of 6 kGy. The role of different treatments given prior to irradiation for revival of Y. enterocolitica after irradiation storage was also studied. The dose of 1 kGy at −40°C was efficient in eradicating low numbers (<10³) of naturally occuring Y. enterocolitica from raw pork meat without any revival during storage at refrigeration temperature.