乡镇工业电镀行业主要污染物排放量的估算方法

电镀分有氰电镀与无氰电镀两类。乡镇工业电镀行业的环境污染最主要是氰污染和铬污染。本文针对乡镇电镀行业的特点,调查了湖南省沅江市、四川省新都县、湖北省黄陂县、汉川县以及江苏省部分县市乡镇电镀厂,将收集资料及实际监测资料进行回归分析,得出乡镇电镀行业的污染物发生量大小与原材料的消耗有关,可以用多元回归方程估算乡镇电镀行业主要污染物发生量。这一估算方法简单易行,实用可靠,操作方便。     

库仑银量法测定氰化物

本文研究了在碱性介质中电生一价银作为库仑滴定剂的条件,实验结果表明,用金属银为发生阳极,在0.1N氢氧化钠溶液中,以0.2N氨作为电生银离子的络合剂,当电流密度在0.5—10毫安/厘米~2范围内,电生一价银的电流效率可以接近100％,用双银电极安培法指标终点,当指示阳极与指示阴极面识之比为2:1时.测定100—600微克氰的平均误差约为±0.2％,测定0.5微克氰时,误差为±2％。     

中药博落回生物碱提取新工艺研究

通过实验研究,探索博落回中总生物碱的提取新工艺,精制工艺,脱脂工艺,脱毒工艺及用HPLC法测定博落回中血根碱和白屈菜红碱含量.     

超滤膜材质对处理电泳漆液的影响

本文研究了聚砜，酞侧基聚砜，磺化聚砜，聚丙烯腈，醋酸纤维素，氰乙基醋酸纤维素，氯甲基化聚砜和季胺化聚砜等材质超滤膜的亲水性能，荷电性能以及它们对超滤阳极和阴极电泳漆液的影响，实验结果表明：亲水性较强，电负性较强的氰乙基醋酸纤维素和醋酸纤维素膜，适合用于处理阳极电泳漆液；而亲水性较强，电中性和电正性较强的氯甲基化聚砜和季胺化聚砜膜，则适合用于处理阴极电泳漆液。     

兔子宫内膜蛋白等电聚焦电泳载体两性电解质pH范围及比例的选择

兔子宫内膜蛋白是研究早期胚胎发育过程中胚泡附植机制的关键因素之一．为了对子宫内膜蛋白进行有效的分离，本研究探讨了用于等电聚焦电泳的载体两性电解质pH范围及其比例．研究结果表明：在只有pH3～9．5的情况下，蛋白质谱带主要分布于胶条碱性端1／3区域，酸性端无谱带；在载体两性电解质pH3-9．5：pH4～6=1：4的情况下，蛋白质谱带主要分布于胶条碱性端2／3部分；在载体两性电解质以pH3-9．5：pH4～6：pH6—9=1：4：1时，蛋白质谱带分布比较均匀，酸性端也有谱带分布．这说明在作子宫内膜蛋白的等电聚焦电泳时采用pH3～9．5：pH4～6：pH6～9=1：4：1比较理想．     

一株氰氟草酯降解新菌株Sphingopyxis sp.WP9的分离鉴定及降解特性

氰氟草酯是应用于稻田的一种除草剂,其广泛使用给水生生态带来了一定威胁.利用连续富集培养的方法,从农药厂活性污泥中筛选出一株氰氟草酯高效降解菌WP9.采用16S rRNA基因序列分析并结合菌落菌体形态和生理生化特性,将菌株WP9鉴定为鞘氨醇盒菌(Sphingopyxis).在以100 mg/L氰氟草酯为唯一碳源的无机盐培养基中,菌株WP9在120 h内可将其降解97.03%.菌株WP9降解炔草酯的最适温度和pH分别为30℃和7.0;当菌株WP9的接种量≥5%时,其对100 mg/L氰氟草酯的降解效果较好;当氰氟草酯浓度≤100 mg/L时,菌株WP9对氰氟草酯的平均降解速率随着底物浓度的增加而呈指数增长.通过超高效液相色谱-质谱联用技术(UPLC-MS)鉴定降解产物为氰氟草酸和氰氟草酚,推测氰氟草酯首先通过酯键水解生成氰氟草酸,然后氰氟草酸通过醚键水解生成氰氟草酚.本研究关于鞘氨醇盒菌对氰氟草酯降解的报道结果,可为开展氰氟草酯污染环境的生物修复提供新菌种和理论基础.(图8参30)     

氯代烃在铜电极上的电还原特性和pH值的影响

采用循环伏安法,对氯代烃类化合物在铜电极表面上的电还原特性进行了研究,结果表明,氯代烷烃类化合物能在铜电极表面被直接还原,氯代芳烃不易在铜电极上被直接还原．碱性条件有利于中间体碳负离子的形成;在酸性条件下,碳负离子与氢离子之间反应的几率增大,导致通过溶液的电流值增加．pH值对不同氯代烃在铜电极上的电还原特性有不同程度的影响,这主要取决于碳链(或苯环)上其它取代基的性质、结构、数量和它与氯在苯环上的相对位置．     

一株除草剂氰氟草酯降解菌的分离鉴定与降解特性

氰氟草酯(Calofop-buty1)是一种芳氧苯氧羧酸酯类除草剂,其迁移、转化和分解等行为对环境及人类健康具有潜在危害.为了解其微生物代谢机制,从长期使用氰氟草酯的稻田土壤中分离到1株氰氟草酯降解菌株,命名为QDZ-B.菌株QDZ-B的16S rDNA基因序列长度为1 400 bp,在RDP数据库比对结果表明其与寡养食单胞菌属菌株的同源性最近,与模式菌株嗜麦寡养食单胞菌Stenotrophomonas maltophilia(AB008509)的同源性为99.8%.根据表型特征、生理生化特性和16S rDNA序列同源性分析,将菌株QDZ-B鉴定为寡养单胞菌属(Stenotrophomonas sp.).接种量为5%时,菌株QDZ-B在基础盐液体培养基中5 d对100 mg L-1氰氟草酯的降解率约为88.2%.菌株QDZ-B的降解效果与接种量成正相关,但接种量大于5%时,降解效率趋于平稳.菌株QDZ-B降解氰氟草酯的最适温度为30℃,最适pH为7.0.通过质谱分析鉴定了3个菌株QDZ-B降解氰氟草酯的代谢产物,分别为氰氟草酸、氰氟草酰胺和2-氟-3-对-乙氧基苯氧基苯酰胺.     

安培法流动注射检测器的应用研究——废水中银离子的流动注射分析

本文研究了安培法检测器的流动注射技术,建立了痕量银的安培一流动注射分析方法.此法采用金管电极流通检测池,指示电极为φ1.0毫米,长5.1厘米的金管,以φ0.5毫米的银丝制成氯化银参考电极,本方法操作简便,快速,准确度和精密度都比较好,可用于测定照相、电镀、制镜、陶瓷及医药等废水中5Ppb—5ppm的银。     

环境监测—一个实例研究

一家公司在现有工厂中引进一种新制造工艺时,也需要进行新的化学品贮存和分配、水处理、废水处理和废气处理。该公司有强有力的法人环境政策,虽然并没有义务这样做,但该公司仍然实施了环境影响评价和环境监测计划。该监测计划始于新工艺开工前九个多月,提供了有关大气、土壤、地下水和地表水的质量的基线数据。 监测继续进行,以便评价该工艺的影响,并为废水和大气排放物治理装置的设计提供有用信息。自从原工艺采用以来,制造技术上已经有了二个重大变化。这些变化也需要进一步监测,主要是废水水质和大气排放方面的监测,以便改进其处理工艺。     

Efficient removal of heavy metals from electroplating wastewater using polymer ligands

Poly(hydroxamic acid)-poly(amidoxime) chelating ligands were synthesized from poly(methyl acrylate-co-acrylonitrile) grafted acacia cellulose for removing toxic metal ions from industrial wastewaters. These ligands showed higher adsorption capacity to copper (2.80 mmol?g⁻¹) at pH 6. In addition, sorption capacities to other metal ions such as iron, zinc, chromium, and nickel were also found high at pH 6. The metal ions sorption rate (t_1/2) was very fast. The rate of adsorption of copper, iron, zinc, chromium, nickel, cobalt, cadmium and lead were 4, 5, 7, 5, 5, 8, 9 and 11 min, respectively. Therefore, these ligands have an advantage to the metal ions removal using the column technique. We have successfully investigated the known concentration of metal ions using various parameters, which is essential for designing a fixed bed column with ligands. The wastewater from electroplating plants used in this study, having chromium, zinc, nickel, copper and iron, etc. For chromium wastewater, ICP analysis showed that the Cr removal was 99.8% and other metal ions such as Cu, Ni, Fe, Zn, Cd, Pb, Co and Mn removal were 94.7%, 99.2%, 99.9%, 99.9%, 99.5%, 99.9%, 95.6% and 97.6%, respectively. In case of cyanide wastewater, the metal removal, especially Ni and Zn removal were 96.5 and 95.2% at higher initial concentration. For acid/alkali wastewater, metal ions removing for Cd, Cr and Fe were 99.2%, 99.5% and 99.9%, respectively. Overall, these ligands are useful for metal removal by column method from industrial wastewater especially plating wastewater.     

Bewertung der potenziellen Grundwasserbelastung von deponierten Hochofengasschlämmen

Goal and Scope

Blast-furnace sludge is a waste originating from pig-iron production and contains contaminants such as lead, zinc, fluoride and cyanide assumably contaminating the groundwater by leaching.

Methods

We investigated the chemical composition of 27 samples of landfilled blast-furnace sludge in pore waters which were obtained by the centrifugation of fresh material and elution with water according to DIN 38414 part 4 (S 4).

Results

The pore waters as well as the eluates were neutral to alkaline (pH 7.3 to 10.7) and were dominated by alkali and alkaline-earth metals as well as sulphate and nitrate. The concentrations of all elements and compounds investigated were mostly clearly larger in the pore waters than in the eluates. The average concentrations of environmentally relevant constituents such as lead (0,18 mg?1), zinc (1,5 mg l?1), fluoride (10,6 mg l?1), and total cyanide (1.8 mg l?1) in the pore waters were distinctly larger than the inspection value of the German Federal soil Protection Ordinance for the pathway soil-groundwater. Lead, zinc, and total cyanide concentrations in the pore waters were largely underestimated by the eluates, as these concentrations were 70 to 90% lower in the eluates compared to the pore waters.

Conclusion

In the case of landfilled blast-furnace sludge, eluates according to DIN 38414 part 4 (S 4) provide low concentrations which are unrealistic to forecast concentrations in the seepage water.     

国内外化学镀镍老化液处理方法

简述了化学镀镍的工艺流程，镀液及老化液成分，以及国内外现有的对化学镀镍老化液处理方法，包括化学法、电解法、离子交换法和膜分离技术。     

Biosorption of zinc (II) using Spirogyra species from electroplating effluent

Zinc was removed from the metal plating effluent with the biosorbent consisting of filamentous algae Spirogyra sp. The sorption was pH dependent with best adsorption at pH 2.5. The metal uptake increased from 3.9% (for no dilution) to 36.8% (for 10 times dilution), indicating that sorption increased with dilution of sample. The adsorption was faster at initial contact time, gradually decreased and remains constant after certain optimum time. Percentage removal of zinc increased from 20.3% to 63.6% with increase in the temperature from 25 degrees C to 35 degrees C but further increase resulted in the decrease in adsorption. Freundlich isotherm was applied and it holds good for the adsorption data.     

Endogenous formation of hydrogen cyanide during distillation for the determination of total cyanide

This paper describes how organic compounds and nitrogen compounds induce the formation of hydrogen cyanide during the distillation process. Hydrogen cyanide formation was confirmed by X‐ray diffraction. The formation scheme for hydrogen cyanide from organic compounds is proposed.     

Uptake of cadmium and zinc by the mussel Mytilus edulis and inhibition by calcium channel and metabolic blockers

The mussel Mytilus edulis is extensively used to monitor metal contamination of estuarine and marine systems. Nonetheless, the mechanisms of metal uptake are poorly understood. To characterise the systems involved in cadmium and zinc uptake, the interaction between the two metals and the effects of different calcium channel blockers (diltiazem, nifedipine, verapamil) and inhibitors of active transport and metabolism (ouabain, sodium cyanide, 2,4 dinitrophenol) on the uptake of calcium, cadmium and zinc in Mytilus edulis have been studied. To separate direct from indirect effects of the inhibitors on metal uptake, their influence on the physiological condition of the mussels was also investigated. This was done by measuring clearance, respiration and excretion rates under the different exposure regimes and determining the scope for growth as an integrative index for physiological condition. The study has shown that the uptake of cadmium and zinc by Mytilus edulis can be modulated by calcium channel blockers and other inhibitors. The inhibitors also influenced physiological condition, but a significant correlation with the effects on metal uptake did not exist in most cases. Cadmium and zinc also inhibit each other's uptake, but the type of inhibition is not yet clear. The effects of the inhibitors on cadmium and zinc uptake are very different from the effects on calcium uptake, indicating that cadmium and zinc are preferentially taken up through other gateways. Overall, a significant degree of linear association is found between the effects of the inhibitors on the uptake of cadmium and zinc, suggesting common uptake routes. In addition, the effects of the calcium channel antagonist on the uptake of the metal ions are organ dependent, indicating that other types of channels are involved in the uptake of the metal ions in the gills and digestive system. Received: 16 February 1999 / Accepted: 23 September 1999     

Experimente zum Verbleib von Cyanid nach Aufnahme in Pflanzen

Free cyanide (prussic acid) can be degraded by many organisms. Experimental data on the kinetics of degradation by plants, however, are rare. We experimentally determined the mass balance of potassium cyanide in the system nutrient solution/plant/air In the presence of living willows (Salix alba) and light, free cyanide is almost completely eliminated from the nutrient solution, also by a willow cell suspension (> 99%) and even by a dried-out stem (> 80%). The loss is smaller when the willow is autoclaved (30%). Without a willow, the CN can be recovered to more than 89%. The loss depends on light and transpiration. Volatilization and the formation of complexed cyanide are of minor relevance for the elimination of free CN. The most plausible loss process is metabolism by plants. The transfer into the roots and stem does not change with the light/dark-rhythm. The transfer factor (mg CN/kg plant fw/mg CN/l solution) after 24 h, and related to the initial concentration in solution, is between 2 and 3 for roots, 0.1 to 0.6 for leaves and 0.2 for stems. In the roots of willows and elderberries which were growing on the former gas worksite in Holte, Denmark, high concentrations of cyanides were found. In leaves and fruits, concentrations are a factor of 10 to 1000-fold lower and up to as high as that found in non-exposed control plants. Due to these results, a cyanide-polluted site in Denmark has been remediated with poplar trees.     

单核Zn(Ⅱ)水合和水解形态的量子化学计算

利用量子化学计算气相中锌离子各种水合和水解形态的几何结构、电荷分布以及水合和水解反应的Gibbs自由能变和焓变．结果表明,除了水合锌离子外,锌离子各种水解络合物的配位数均小于6;对于深度水解产物Zn（OH）3^-和Zn（OH）4^2-,内层无水分子的键合．水合作用和水解作用互相抑制,水合作用阻碍了水解产物进一步水解（Zn（OH）2除外）,水解作用使得水合变得困难．内层键合水分子数的增加降低了水合形态中Zn上的电荷,使得水解形态Zn上的电荷升高．     

Patterns of bioaccumulation of an essential trace element (zinc) and a pollutant metal (cadmium) in larvae of the prawn Palaemon serratus

Palaemon serratus Pennant larvae from females caught near Roscoff (France) or the Bay of Biscay in 1983, were reared in the laboratory. From hatching to the first stage after metamorphosis, the larvae were exposed to zinc and cadmium introduced separately or together into the rearing medium. At the end of experimental contamination, the concentrations of the two metals in the organisms were determined. The level of zinc in organisms was mainly independent of its concentration in the water, suggesting that the bioaccumulation of this essential trace element is controlled by some physiological process. The accumulation of cadmium in the larvae paralleled the overloads of this metal in the water. Increased zinc concentrations in water have little or no effect on the cadmium levels in organisms. The most important interaction between these two metals is an antagonism exerted by cadmium on the biological uptake of zinc.     

Bestimmung von leicht freisetzbarem Cyanid in Böden und Wässern mit der Mikrodestillation

Easy-liberatable cyanide has to be analysed if soils and waters are contaminated by cyanide. The aim of this study was to determine easy-liberatable cyanide in these environmental samples using a micro-distillation apparatus by means of a modified digestion vessel. Pure aqueous solutions of different cyanide species, five contaminated and uncontaminated soil samples and two water samples were analysed by micro-distillation according to the German standards. Recovery was determined by analysis of spiked samples. When using the modified digestion vessels, the pH of 4 which is demanded by the standard method can be adjusted. The recovery of potassium cyanide and weakly-complexed zinc-cyanide ranged from 93–101% for standards, and from 87–98% for spiked samples. In contrast, the recovery of strong iron-cyanide complexes was below 4% both for pure solutions and spiked samples. The precision of the method expressed as a relative standard deviation was 25% in cases of very low easy-liberatable cyanide contents (< 1 mg CN kg^?1) and below 12% in case of high easy-liberatable cyanide contents (> 1 mg CN kg^?1) for contaminated soils. The determination of easily-liberatable cyanide in soils and waters using micro-distillation combined with the modified digestion sample is an alternative to other distillation methods.