| 220MW热电联产锅炉中痕量元素的迁移及分布特性 |
| |
| 引用本文： | 王超,刘小伟,吴建群,周子健,陈军,徐明厚.220MW热电联产锅炉中痕量元素的迁移及分布特性[J].化工学报,2014,65(9):3604-3608. |
| |
| 作者姓名： | 王超 刘小伟 吴建群 周子健 陈军 徐明厚 |
| |
| 作者单位： | 华中科技大学煤燃烧国家重点实验室, 湖北 武汉 430074 |
| |
| 基金项目： | 国家自然科学基金（51276072）；国家重点基础研究发展计划（973计划）（2013CB228501）；煤炭联合基金重点项目（U1261204） |
| |
| 摘 要： | 本实验在北京某220 MW热电联产锅炉上进行。采用承重撞击器系统对该锅炉选择性催化还原（SCR）前、电子除尘（ESP）前以及烟气脱硫（FGD）前的颗粒物进行采集，研究了痕量元素在烟道沿程上的迁移特性，另外，还给出了痕量元素在各固体燃烧产物中的分布。结果表明：ESP前的颗粒物上As、Cd、Cr和Pb的浓度明显高于SCR前的浓度；在从SCR到ESP的过程中，As、Cd、Cr、Pb从气态迁移到固态的质量分别占到了原煤中总质量的26%、16%、12%和11%；从ESP到FGD的过程中，颗粒物上As与Cd的浓度有略微增加，而Cr和Pb的浓度几乎不变；Mn在3个采样点的浓度几乎一致；大部分痕量元素存在于ESP捕获的飞灰中，在ESP出口处，As、Cd、Cr、Pb在<10 μm的4个粒径段上的质量随着粒径的减小而增大，而Mn的质量分布与颗粒物质量分布类似。
|
| 关 键 词： | 煤燃烧 热电联产锅炉 痕量元素 颗粒物 迁移 分布 污染 |
| 收稿时间： | 2013-12-18 |
| 修稿时间： | 2014-01-14 |
Migration and Distribution Characteristics of Trace Elements in 220 MW Cogeneration Boiler |
| |
| Wang Chao,Liu Xiaowei,Wu Jianqun,Zhou Zijian,Chen Jun,Xu Minghou.Migration and Distribution Characteristics of Trace Elements in 220 MW Cogeneration Boiler[J].Journal of Chemical Industry and Engineering(China),2014,65(9):3604-3608. |
| |
| Authors: | Wang Chao Liu Xiaowei Wu Jianqun Zhou Zijian Chen Jun Xu Minghou |
| |
| Affiliation: | State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology, Wuhan 430074, Hubei, China |
| |
| Abstract: | The experiment was carried out in a 220 MW cogeneration boiler in Beijing. Dekati Gravimetric Impacter system was applied to particulate matter (PM) sampling at the inlets of SCR, ESP and FGD in this boiler, to investigate the migration characteristics of trace elements in the flue gas tunnel. In addition, the distribution characteristics of trace elements in solid combustion residues were also studied. The results indicate that the concentrations of As, Cd, Cr and Pb in PM at the inlet of ESP are obviously higher than that at the inlet of SCR. The masses of gaseous As, Cd, Cr and Pb which convert to solid in the process of flue gas flowing from SCR to ESP, account for 26 %, 16 %, 12 %, 11 % of the total masses in coal respectively. In the process of flue gas flowing from ESP to FGD, the concentrations of As and Cd in PM slightly increase, while those of Cr and Pb are almost constant. The concentrations of Mn at the three sampling sites are almost the same. Most trace elements remain in the fly ash collected by ESP, and at the outlet of ESP, the masses of As, Cd, Cr and Pb in the four size segments with size <10 μm increase with the decreasing particle size, however, the mass distribution of Mn is similar with that of PM. |
| |
| Keywords: | coal combustion cogeneration boiler trace element particulate matter migration distribution pollution |
|
| 点击此处可从《化工学报》浏览原始摘要信息 |
|
点击此处可从《化工学报》下载全文 |
|
