| 五相开绕组电机起动阶段电流控制策略研究 |
| |
| 引用本文： | 郑再平,李琪琦,李旭阳,王开春,杨斌.五相开绕组电机起动阶段电流控制策略研究[J].微电机,2021,0(1):57-62+67. |
| |
| 作者姓名： | 郑再平 李琪琦 李旭阳 王开春 杨斌 |
| |
| 作者单位： | (北京精密机电控制设备研究所,北京 100076) |
| |
| 摘 要： | 基于运载火箭起动/发电一体化系统高可靠性、高功率密度的需求，针对起动时间短、起动负载大的特点，对不增加铜损且使得相电流幅值最小的三次谐波电流注入率的计算方法开展研究。首先，建立五相开绕组永磁同步电机的数学模型，推导三次谐波电流注入率的解析模型。然后，搭建仿真模型，初步验证以相电流幅值最小为目标的三次谐波电流注入率计算结果的正确性。最终，在原理样机上进行了实验，在负载转矩同为40N·m的情况下，将相电流幅值从31.5A降到27A，降低了14.28%。实验结果与仿真结果基本一致，进一步证明了注入率的正确性。
|
| 关 键 词： | 起动/发电一体化系统 五相开绕组永磁同步电机 三次谐波电流注入 相电流幅值最小 |
Research on Current Control Strategy of Five-phase Open-winding Motors during Starting |
| |
| ZHENG Zaiping,LI Qiqi,LI Xuyang,WANG Kaichun,YANG Bin.Research on Current Control Strategy of Five-phase Open-winding Motors during Starting[J].Micromotors,2021,0(1):57-62+67. |
| |
| Authors: | ZHENG Zaiping LI Qiqi LI Xuyang WANG Kaichun YANG Bin |
| |
| Affiliation: | (Beijing Institute of Precise Mechatronics and ControlsBeijing 100076China) |
| |
| Abstract: | The calculation method of the injection rate of the third harmonic current that does not increase the copper loss and minimizes the phase current amplitude was studied,based on the requirements of high reliability and high power density of the integrated starter/generator system of the launcher,and aimed on the characteristics of short start time and large start load.First,a mathematical model of a five-phase open-winding permanent magnet synchronous motor was established,and an analytical model of the injection rate of the third harmonic current was derived.Then,a simulation model was built to preliminarily verify the correctness of the calculation result of the injection rate of the third harmonic current with the smallest phase current amplitude as the target.Finally,experiments were carried out based on the principle prototype.When the load torque is also 40Nm,the third harmonic current was injected with an injection rate of 0.18,which reduced the phase current amplitude from 31.5A to 27A,a decrease of 14.28%.The experimental results and simulation results are basically consistent,which further proves the correctness of the calculation method. |
| |
| Keywords: | starting/generation system five-phase open-winding permanent magnet synchronous motor third harmonic current injection minimize the phase current amplitude |
| 本文献已被 CNKI 维普 等数据库收录！ |
| 点击此处可从《微电机》浏览原始摘要信息 |
|
点击此处可从《微电机》下载全文 |
|
